A201807 2052368-
Service Bulletin Details
Public Details for: A201807 2052368-
This bulletin contains instructions for repairing when the fuel gauge does not show full.
Models from 2018
2018 AUDI A8 |
Models from 2017
2017 AUDI A8 |
Models from 2016
2016 AUDI A8 |
20 Fuel gauge does not show full after filling up tank 20 18 07 2052368/2 September 26, 2018. Supersedes Technical Service Bulletin Group 20 number 18-06 dated September 12, 2018 for reasons listed below. Model(s) Year VIN Range Vehicle-Specific Equipment A8 2016 - 2018 All Not Applicable Condition REVISION HISTORY Revision Date Purpose 2 - Revised header (Corrected Elsa display issue) Revised Warranty (Updated Labor Operations) 1 09/12/2018 Initial publication Customer states: Fuel gauge does not show full after filling up, it only shows 5/8ths of a tank (Figure 1). Fuel gauge shows correct level after a short delay. Fuel gauge only shows full after driving for a short distance. MIL may be illuminated. Figure 1. Only shows 5/8ths of a tank instead of full. Workshop findings: One or more of the customer statements can be reproduced. If DTC P046100 is found in the ECM, check and update if necessary using TSB 2043357: 20 MIL on (DTC P046100 - Fuel level sensor, circuit range/performance). If any other DTCs are found proceed with GFF and repairs. Page 1 of 4 © 2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. If the customer’s concern included fuel gauge only showing 5/8ths after filling fuel tank, replace fuel sensor with updated part (green dot). Technical Background Delayed response from fuel gauge sensor 3 (G237). Production Solution Improved sensor housing. Service Follow instructions in the Elsa Repair Manual to replace fuel sensor 3 (G237). Warranty Claim Type: 110 up to 48 Months/50,000 Miles. G10 for CPO Covered Vehicles – Verify Owner. If vehicle is outside any warranty, this Technical Service Bulletin is informational only. Service Number: 2015 Damage Code: 0010 Labor Operations: Fuel gauge sender remove + reinstall 2015 1952 See SRT Fuel tank remove + reinstall 2010 1951 See SRT 2 Wheels remove + reinstall 4405 2000 See SRT Rear axle assembly remove + reinstall 4205 1952 See SRT Vehicle front and rear measured 4495 0300 See SRT Front wheel track adjust 4488 1550 See SRT Front wheel camber adjust 4489 1550 See SRT Page 2 of 4 © 2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Diagnostic Time: Claim Comment: Noise dampening pan remove + reinstall 1082 1900 See SRT Rear wheel track adjusted 4493 1550 See SRT Rear wheel camber adjusted 4494 1550 See SRT Preparation Driver Assist Calibration (Air suspension only) 9092 0051 See SRT Camera Driver Assist Sys adjust (Air suspension only) 9638 1550 See SRT GFF – Checking and clearing fault codes included in existing labor operations 0150 0000 Time stated on diagnostic protocol (Max 30 TU, with Air suspension 50 TU) Road test prior to service procedure No allowance 0 TU Road test after service procedure 0121 0004 10 TU As per TSB #2052368/2 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. Required Parts and Tools Always check with your Parts Department and/or ETKA for the latest information and parts bulletins. Part Number Part Description Quantity See ETKA Fasteners, Bolts, Nuts and Screws as needed per the Repair Manual See ETKA/ELSA 4H0201317AA Fuel sensor 01 Additional Information The following Technical Service Bulletin(s) will be necessary to complete this procedure: TSB 2043357, 20 MIL on (DTC P046100 - Fuel level sensor, circuit range/performance). All parts and service references provided in this TSB (2052368) are subject to change and/or removal. Page 3 of 4 © 2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. ©2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites without the prior expressed written permission of the publisher. Page 4 of 4 © 2018 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.