V601803_2045672
Service Bulletin Details
Public Details for: V601803_2045672
Updated to change warranty table time unit statement.
Models from 2018
2018 VOLKSWAGEN GOLF ALLTRACK |
Models from 2016
2016 VOLKSWAGEN GOLF SPORTWAGEN |
Models from 2015
2015 VOLKSWAGEN GOLF SPORTWAGEN |
Technical Service Bulletin 60-18-03 Water Leak From Rear Of Panoramic Sunroof Transaction No: 2045672/5 Release date: 7/18/2019 Condition Applicable Vehicles Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To Golf Sportwagen, Alltrack 2015-2018 All All AU_FM500001 AU_JM765566 Revision Table Instance Number Published Date Version Number Reason For Update 2045672/5 7/18/19 60-18-03 Update to warranty table time unit. 2045672/4 10/2/18 V601803 Update to update model year applicability. 2045672/1 10/24/16 V601607 Original publication. The rear sunroof drains may be pinched shut by foam blocks on the headliner, not allowing the sunroof frame to drain properly (See Figure 1). Page 1 of 6 © 2019 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin 60-18-03 Water Leak From Rear Of Panoramic Sunroof Transaction No: 2045672/5 Release date: 7/18/2019 Technical Background Incorrect assembly in production allows too much length in the sunroof drain between the second and third securing clips. This causes excess slack in the drain hose allowing the foam block to contact the hose. Production Solution Assembly process assured as of VIN: AU_ JM765566. Service Inspect the Rear Sunroof Drain Hoses 1. Open the sunroof all the way. 2. Open the sunshade 2/3rds of the way. 3. Using the pry lever 80-200, slide it along between the cover frame (Figure 2, -2-) and the headliner (Figure 2, -1-) until the lever comes in contact with one of the clips (Figure 2, -3-). Note: Clean the pry lever 80-200 prior to using to avoid soiling the headliner. 4. Unclip the cover frame (Figure 2, -2-) in the area near the clips (Figure 2, -3-) using the pry lever 80-200 (Figure 2, -arrow-). Figure 2 Page 2 of 6 © 2019 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin 60-18-03 Water Leak From Rear Of Panoramic Sunroof Transaction No: 2045672/5 Release date: 7/18/2019 5. Remove the C-Pillar trim panels. See repair manual group 70 in ELSA. 6. Remove the D-Pillar trim panels. See repair manual group 70 in ELSA. 7. Loosen the rear roof grab handles from the mounts in the grab handle brackets. DO NOT completely remove. See repair manual group 68 in ELSA. 8. Remove the luggage compartment lamp. See repair group 96 in ELSA. 9. Carefully lower the rear of the headliner and inspect the rear sunroof drain hoses. The drain hoses should be replaced if they show signs of being pinched by the foam blocks on the headliner (Figure 3). Note: Care must be taken when working with the headliner. The headliner bends easily. Damage to the headliner during this repair is not covered by warranty. Replace the headliner if it is bent. Figure 3: Impression on rear sunroof drain from contact with headliner foam block. Tip: If the sunroof drains are pinched continue to next step. If the sunroof drains are not pinched, this bulletin does not apply and further diagnosis is required. Page 3 of 6 © 2019 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin 60-18-03 Water Leak From Rear Of Panoramic Sunroof Transaction No: 2045672/5 Release date: 7/18/2019 Replace Rear Sunroof Drain(s) Hose and Ensure the Correct Routing of the Hose(s) 1. Finish removing the headliner. See repair manual group 70 in ELSA. 2. Remove and replace the rear sunroof drain hoses. See repair manual group 60 in ELSA. Tip: The new hoses (longer than original) should be cut to match the length of the original hoses prior to the installation. During installation of the new drain hoses, ensure the hoses are pulled taught between the 2nd and 3rd mounting clips with no excess slack in the hoses (See Figures 4 and 5). Figures 4 and 5: Correct routing of left and right rear drain hoses with no slack between the 2nd and 3rd mounting clips. 3. Reinstall the headliner ensuring the foam blocks do not contact either of the sunroof drain hoses (See Figures 6 and 7). Figures 6 and 7, Rear drain hoses routed behind foam blocks on headliner. 4. Reinstall all removed trim pieces in the reverse order of removal. 5. Water test vehicle to ensure there are no further water leaks. Page 4 of 6 © 2019 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin 60-18-03 Water Leak From Rear Of Panoramic Sunroof Transaction No: 2045672/5 Release date: 7/18/2019 Warranty To determine if this procedure is covered under Warranty, always refer to the Warranty Policies and Procedures Manual 1) Model(s) Year(s) Eng. Code(s) Trans. Code(s) Golf Sportwagen, Alltrack 2015-2018 All All VIN Range From VIN Range To AU_FM500001 AU_JM765566 SAGA Coding Claim Type: Use applicable Claim Type 1) Damage Service Number: HST Damage Location (Depends on Service No.) -- 000 Code 6048 0010 Parts Manufacturer Golf Sportwagen, Alltrack Labor Operation 3) : Headliner Remove and Reinstall 3ME 2) 70841903 = See Elsa for latest time units. Labor Operation 3) : Remove and Reinstall 2 Rear 60482060 = See Elsa for latest time units. Water Drains Labor Operation 3) : Water Test 60480399 = 20 TU Causal Part: Select Labor Operation 60482060 Diagnostic Time 4) GFF Time expenditure 01500000 = 00 TU max. Road Test 01210002 = 00 TU NO NO 01210004 = 00 TU Technical Diagnosis 01320000 = 20 TU max. YES Claim Comment: Input “As per Technical Bulletin 2045672” in comment section of Warranty Claim. 1) Vehicle may be outside any Warranty in which case this Technical Bulletin is informational only. Page 5 of 6 © 2019 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin 60-18-03 Water Leak From Rear Of Panoramic Sunroof 2) Code per warranty vendor code policy. 3) Labor Time Units (TUs) are subject to change with ELSA updates. 4) Documentation required per Warranty Policies and Procedures Manual. Transaction No: 2045672/5 Release date: 7/18/2019 Required Parts and Tools Part No: Part Description Quantity 5G0 877 228 Water Drain Hose 2 For Special Tools see Repair Manual. Additional Information All part and service references provided in this Technical Bulletin are subject to change and/or Page 6 of 6 © 2019 Volkswagen Group of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.