A1020192059446_2

10 Oil loss from the filler cap
10 20 19 2059446/2 July 14, 2020. Supersedes Technical Service Bulletin Group 10 number 20-18 dated May 12,
2020 for reasons listed below.
Model(s)
Year
VIN Range
Vehicle-Specific Equipment
Q5, SQ5
2017
All
3.0 TFSI
Q5, SQ5
2018
000001 - 212605
3.0 TFSI
A4, A5, A5
Sportback,
A5
Cabriolet,
A6, A7, A8,
RS5, RS5
Cabriolet,
RS6, RS7,
S4, S5
Cabriolet,
S6, S7, S8,
Q7, and
SQ7
2017 - 2018
All
3.0 TFSI
A4, S4
2019
000001 - 056412
3.0 TFSI
A5, A5
Sportback,
A5
Cabriolet,
RS5, RS5
Cabriolet,
and S5
Cabriolet
2019
000001 - 027694
3.0 TFSI
A6, A7, S6,
and S7
2019
000001 - 118457
3.0 TFSI
A8, S8
2019
000001 - 011487
3.0 TFSI
Q7, SQ7
2019
000001 - 004275
3.0 TFSI
Condition
REVISION HISTORY
Revision
Date
Purpose
2
-
Revised header (Corrected Elsa display issue)
1
05/12/2020
Initial publication
Page 1 of 4
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.
Customer states:
 Oil loss in the engine compartment, front end, and the filler cap.
 There is a smell coming from the engine compartment.
Workshop findings:
 There are traces of oil around the filler cap.
Technical Background
A faulty membrane in the breather line 06M103210 ** can result in excess pressure in the crankcase and
therefore some oil loss through the filler cap.
Production Solution
A breather line with an improved membrane has been implemented in production.
Service
Replace the breather line
06M103210 ** (different
variants available, only order by
VIN).
Figure 1. Breather line that needs to be replaced.
Warranty
Claim Type:
 110 up to 48 Months/50,000 Miles.
 G10 for CPO Covered Vehicles – Verify Owner.
 If the vehicle is outside any warranty, this Technical Service Bulletin is informational
only.
Page 2 of 4
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.
Service Number:
1050
Damage Code:
0050
Labor Operations:
Remove + install crankcase breather hose
1052 1943
Or
1052 1993
Remove + install crankcase breather hose
Diagnostic Time:
Claim Comment:
See SRT with
associated
operations
1052 1999
30 TU
Or
Or
1052 1943 (Q8
only)
See SRT with
associated
operations
Clean (If required)
1052 2999
5 TU
GFF
No allowance
0 TU
Road test prior to the service procedure
No allowance
0 TU
Road test after the service procedure
No allowance
0 TU
As per TSB #2059446/2
All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures
Manual. Claims are subject to review or audit by Audi Warranty.
Required Parts and Tools
Always check with your Parts Department and/or ETKA for the latest information and parts bulletins.
Part Number
Part Description
Quantity
See ETKA
Fasteners, Bolts, Nuts, and Screws as needed per the
Repair Manual
See ETKA/ELSA
Order by VIN
Breather Line
01
Additional Information
All parts and service references provided in this TSB (2059446) are subject to change and/or removal.
©2020 Audi of America, Inc. All rights reserved. The information contained in this document is based on the
latest information available at the time of printing and is subject to the copyright and other intellectual property
Page 3 of 4
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes
at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or
transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites without the prior expressed written permission of the
publisher.
Page 4 of 4
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.