131320312454
Service Bulletin Details
Public Details for: 131320312454
Under certain driving conditions, the linkage for the waste gate actuation can encounter excessive wear which leads to play at the waste gate flap. This leads to boost escaping through a loose flap, which sets dtc P0299 (negative pressure d
- 2013 - 2012 - 2011 - 2010 - 2009 -
Models from 2011
2011 AUDI A4 |
2011 AUDI A5 |
2011 AUDI A5 CABRIOLET |
2011 AUDI Q5 |
Models from 2010
2010 AUDI A4 |
2010 AUDI A5 |
2010 AUDI A5 CABRIOLET |
Models from 2009
2009 AUDI A4 |
2009 AUDI A5 |
2009 AUDI A5 CABRIOLET |
Technical Service Bulletin 21 Mil on - P0299 Negative pressure deviation, turbocharger excessive wastegate play 21 13 13 2031245/4 April 4, 2013. Supersedes Technical Service Bulletin Group 21 number 13-12 dated April 1, 2013 for reasons listed below. Model(s) Year A4 2009 - 2013 A5 2009 - 2013 A5 Cab 2009 - 2013 Q5 2011 - 2013 A6 2012 - 2013 VIN Range Vehicle-Specific Equipment All 6 speed automatic (0B6) Condition REVISION HISTORY Revision Date Purpose 4 - Revised header data (Corrected Elsa display error) 3 4/1/13 Revised header data (Modified affected vehicles) 2 3/6/13 Revised Warranty (SRT times) 1 10/25/12 Original publication BOTH of the following apply: • MIL on, DTC P0299 (Negative Pressure Deviation) is stored. • Turbocharger waste gate flap has play. Technical Background Under certain driving conditions, the linkage for the waste gate actuation can encounter excessive wear which leads to play at the waste gate flap. This leads to boost escaping through a loose flap, which sets DTC P0299 (Negative Pressure Deviation). © 2013 Audi of America, Inc. Page 1 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Production Solution Not applicable. Service 1. Remove turbocharger as per ELSA instructions: Repair Manual >> Engine / Engine Mechanical >> 21 Turbocharger, G-Charger >> Removal and Installation >> Turbocharger. 2. Install clip 06J145220B on a replacement turbocharger’s link plate and actuating rod joint as illustrated (Figures 1 and 2). Figure 1. Fit the clip from the side. Figure 2. Turn the clip counter clockwise till the lugs slot in. © 2013 Audi of America, Inc. Page 2 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Tip: • The spring clip must not be overstretched. The maximum opening of the spring clip is 14 mm (Figure 3, 1). • The spring clip must be replaced after every removal. Figure 3. (1) Maximum opening of clip, (2) Position of original circlip 3. After fitting the spring clip, check for correct fit (Figure 4). Figure 4. Correctly-fitted clip. 4. After fitting the spring clip, check the position of the original circlip (Figure 5, 2) and correct it if necessary. Figure 5. (1) Maximum opening of clip, (2) Position of original circlip © 2013 Audi of America, Inc. Page 3 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin 5. Install the new turbocharger as per Repair Manual >> Engine >> Engine Mechanical >> 21 Turbocharger, GCharger >> Removal and Installation >> Turbocharger. Note: Do not install clip on a used or pre-damaged turbocharger, as the same level of improvement as on a new part is not achieved. Warranty Claim Type: Use applicable claim type. If vehicle is outside any warranty, this Technical Service Bulletin is informational only. Service Number: 2130 Damage Code: 0018 Labor Operations: Turbocharger remove + reinstall 2130 1913 370 TU Turbocharger replace 2130 5563 30 TU Install clip on turbocharger 2130 2199 10 TU Diagnostic Time: GFF – Checking and clearing fault codes included 0150 0000 in existing labor operations Time stated on diagnostic protocol (Max 40 TU) Road test prior to service procedure 0121 0002 10 TU Road test after service procedure 0121 0004 10 TU Technical diagnosis at dealer’s discretion (Refer to Section 2.2.1.2 and Audi Warranty Online for DADP allowance details) Claim Comment: As per TSB #2031245/4 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. © 2013 Audi of America, Inc. Page 4 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Required Parts and Tools Part Number Part Description Quantity 06J145220B Clip 1 8K0253115H Gasket 1 WHT002514 Shouldered hex. Nut, self-locking 4 N 10730201 Stud 4 06F145757L Gasket 2 06F253039F Gasket 1 N 0138149 Seal ring 6 N 0138514 Seal ring 2 06H145702S Turbocharger 1 Additional Information All parts and service references provided in this TSB are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information. ©2013 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites without the prior expressed written permission of the publisher. © 2013 Audi of America, Inc. Page 5 of 5 All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.