A5723282072187_2

Technical Service Bulletin
57 Ghost Fault "B200096: Control Module Faulty, Symptom 131164" Stored in 0046
57 23 28 2072187/2 December 20, 2023. Supersedes Technical Service Bulletin Group 57 number 23-24 dated
November 22, 2023 for reasons listed below.
Model(s)
Year
VIN Range
Vehicle-Specific Equipment
A6, A6 allroad,
S6, RS 6 Avant,
A7, S7, RS 7,
A8, S8, Q5, Q5 e
quattro, Q5
Sportback, SQ5,
and SQ5
Sportback
2024
All
Not Applicable
Condition
REVISION HISTORY
Revision
Date
Purpose
2
-
Revised Service (Solution provided)
Revised Warranty (Table added)
1
11/22/2023
Initial publication
Customer states:
No customer concerns, it is found during PDI or any other diagnostic work.
Workshop findings:
The following DTC and symptom code are stored in the Comfort System Control Module, J393 (address word
0046), even though there is no problem in the vehicle:
• B200096: Control Module Faulty (Symptom 131164)
Technical Background
Software issue in the convenience control unit J393 (diagnostic address 0046).
Production Solution
© 2023 Audi of America, Inc.
Internal
Page 1 of 3
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this
document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
Technical Service Bulletin
Not applicable.
Service
Run the control module replacement test plan “0046 - Replace control unit” in ODIS (version 23.1.3 or
higher), without actually replacing the control unit. This will delete the DTC.
Warranty
Claim Type:
•
110 Up to 48 Months/50,000 Miles.
•
G10 for CPO Covered Vehicles – Verify Owner.
•
If the vehicle is outside of any warranty, this Technical Service Bulletin is
informational only.
Service Number:
5789
Damage Code:
0040
Diagnostic Time:
GFF
0150 0060
Time stated on
the diagnostic
protocol
(Max 50 TU)
Claim Comment:
Road test prior to the service procedure
No allowance
0 TU
Road test after the service procedure
No allowance
0 TU
As per TSB 2072187/2
All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and
Procedures Manual. Claims are subject to review or audit by Audi Warranty.
Additional Information
All part and service references provided in this TSB (2072187) are subject to change and/or removal. Always
check with your Parts Department and/or ETKA for the latest information and parts bulletins. Please check
the Repair Manual for fasteners, bolts, nuts, and screws that require replacement during the repair.
© 2023 Audi of America, Inc.
Internal
Page 2 of 3
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this
document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
Technical Service Bulletin
©2023 Audi of America, Inc. All rights reserved. The information contained in this document is based on the
latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes
at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or
transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites without the prior expressed written permission of the
publisher.
© 2023 Audi of America, Inc.
Internal
Page 3 of 3
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this
document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.