LSB006523
Service Bulletin Details
Public Details for: LSB006523
Tt: engine oil leak between the lower oil pan and crank case
- 2024 - 2023 - 2022 - 2021 - 2020 -
Models from 2024
2024 TOYOTA CAMRY |
2024 TOYOTA HIGHLANDER HYBRID |
2024 TOYOTA RAV4 |
2024 TOYOTA SIENNA |
Models from 2022
Models from 2021
Models from 2020
2020 TOYOTA AVALON |
2020 TOYOTA AVALON HYBRID |
2020 TOYOTA CAMRY |
2020 TOYOTA CAMRY HYBRID |
2020 TOYOTA HIGHLANDER |
2020 TOYOTA HIGHLANDER HYBRID |
2020 TOYOTA RAV4 |
2020 TOYOTA RAV4 HYBRID |
L-SB-0065-23 December 18, 2023 MIL ON With DTC P24517F Service Category Vehicle Interior Section Meter/Gauge/Display Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2023 RX500H VDS(s): BCMEA Engine(s): T24 Introduction Some 2023 model year RX 500h vehicles may exhibit a MIL ON condition with Diagnostic Trouble Code (DTC) P24517F – Evaporative Emission System Switching Valve Actuator Stuck Off present. This DTC may erroneously be displayed when the fault is related to DTC P14502A – Fuel Tank Pressure Sensor Signal Stuck in Range. The Engine Control Model (ECM) (SAE term: Powertrain Control Module/PCM) logic has been modified so DTC P24517F will not be erroneously detected. Follow the Repair Procedure in this bulletin to address these conditions. Production Change Information This bulletin applies to vehicles produced BEFORE the Production Change Effective VIN shown below. MODEL YEAR MODEL ENGINE PRODUCTION CHANGE EFFECTIVE VIN 2023 RX 500h T24A-FTS 2T2BCMEA#PC009721 Warranty Information OP CODE DESCRIPTION TIME OFP T1 T2 EL2322 Reprogram the ECM (PCM) 0.7 89661-0EK##* 8A 74 *Warranty claim MUST be submitted with the correct 10-digit OFP. Choose the correct OFP for the vehicle being repaired by searching for the parts in the Electronic Parts Catalog using the VIN filter. APPLICABLE WARRANTY This repair is covered under the Lexus Federal Emissions Warranty. This warranty is in effect for 96 months or 80,000 miles, whichever occurs first, from the vehicle’s in-service date. Warranty application is limited to occurrence of the specified condition described in this bulletin. © 2023 Lexus, a division of Toyota Motor Sales, USA Page 1 of 4 L-SB-0065-23 December 18, 2023 Page 2 of 4 MIL ON With DTC P24517F Parts Information PART NUMBER PART NAME QTY 89661-0EK## Computer, Engine Control 1 NOTE The ECM (PCM) should NOT be replaced as part of the Repair Procedure. Required Tools & Equipment SPECIAL SERVICE TOOLS (SST) PART NUMBER QTY Battery Diagnostic Tool DCA-8000P T 1 *Essential SST. NOTE Additional SSTs may be ordered by calling 1-800-933-8335. REQUIRED EQUIPMENT SUPPLIER Techstream ADVI* PART NUMBER QTY TSADVUNIT Techstream 2.0 TS2UNIT ADE 1 Techstream Lite TSLITEPDLR01 Techstream Lite (Green Cable) TSLP2DLR01 *Essential SST. NOTE Only ONE of the Techstream units listed above is required. GTS+ software version 2023.04.003.02 or later is required. Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at 1-800-368-6787. Use Techstream or an approved J2534 interface to perform flash reprogramming updates. Visit techinfo.toyota.com for more information regarding J2534 reprogramming. © 2023 Lexus, a division of Toyota Motor Sales, USA L-SB-0065-23 December 18, 2023 Page 3 of 4 MIL ON With DTC P24517F Calibration Information CALIBRATION ID MODEL YEAR MODEL ENGINE PREVIOUS NEW 8A2220E08000 8A2220E08100 2023 RX 500h T24A-FTS 8A2220E08400 8A2220E08200 8A2220E08300 Repair Procedure 1. Confirm the condition exists. Does the vehicle exhibit a MIL ON condition with DTC P24517F (Evaporative Emission System Switching Valve Actuator Stuck Off) present? YES — Continue to step 2. NO — This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual. 2. Use GTS+ to confirm if the ECM (PCM) calibration has been updated. Is the calibration ID listed in GTS+ the latest ECM (PCM) calibration? YES — This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual. NO — Continue to step 3. 3. Save the freeze frame data (FFD) and then flash reprogram the ECM (PCM). NOTE The battery diagnostic tool MUST be used in Power Supply Mode to maintain battery voltage at 13.5V while flash reprogramming the vehicle. For details on how to use the battery diagnostic station, refer to the DCA-8000 Instruction Manual located at TIS – Diagnostics – Tools & Equipment – Battery Diagnostics. Follow the procedures outlined in L-SB-0036-22 GTS+ ECU Flash Reprogramming With Security Signature, and flash the ECM (PCM) with the NEW calibration file update. © 2023 Lexus, a division of Toyota Motor Sales, USA L-SB-0065-23 December 18, 2023 Page 4 of 4 MIL ON With DTC P24517F Repair Procedure (continued) 4. Utilize the saved FFD and diagnose DTCs P14502A and P24517F. Run a Health Check and refer to the Typical Malfunction Thresholds section in the applicable Repair Manual to confirm which DTC(s) may be the root cause. Refer to TIS, applicable model and model year Repair Manual: 2023 RX 500h (DTC P14502A): Engine/Hybrid System – Engine Control – “T24A-FTS (Engine Control): SFI System (for 1Motor-HEV Model): P145011,P145015,P14502A,P14502F; Fuel Tank Pressure Sensor Circuit Short to Ground” 2023 RX 500h (DTC P24517F): Engine/Hybrid System – Engine Control – “T24A-FTS (Engine Control): SFI System (for 1Motor-HEV Model): P145011,P145015,P14502A,P14502F; Fuel Tank Pressure Sensor Circuit Short to Ground” 5. Using GTS+, clear ANY DTCs and test-drive the vehicle in accordance with the driving pattern described in the confirmation driving pattern to confirm the condition is no longer present. Refer to TIS, applicable model and model year Repair Manual: 2023 RX 500h (DTC P14502A): Engine/Hybrid System – Engine Control – “T24A-FTS (Engine Control): SFI System (for 1Motor-HEV Model): P145011,P145015,P14502A,P14502F; Fuel Tank Pressure Sensor Circuit Short to Ground” 2023 RX 500h (DTC P14502A): Engine/Hybrid System – Engine Control – “T24A-FTS (Engine Control): SFI System (for 1Motor-HEV Model): P24507E,P24517F; Evaporative Emission System Switching Valve Actuator Stuck On” © 2023 Lexus, a division of Toyota Motor Sales, USA