TSB010123
Service Bulletin Details
Public Details for: TSB010123
Tsb: some 2023 model year crown vehicles may exhibit a mil on condition with diagnostic trouble code (dtc) P2C9000 (crankcase ventilation system - hose a disconnected) present without any related hoses disconnected. The engine control modul
- 2023 -
Models from 2023
2023 TOYOTA CROWN |
T-SB-0101-23 December 20, 2023 MIL ON With DTC P2C9000 Service Category Vehicle Interior Section Meter/Gauge/Display Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2023 Crown VDS(s): AFAAF Engine(s): T24 Introduction Some 2023 model year Crown vehicles may exhibit a MIL ON condition with Diagnostic Trouble Code (DTC) P2C9000 (Crankcase Ventilation System - Hose A Disconnected) present without any related hoses disconnected. The Engine Control Module (ECM) (SAE term: Powertrain Control Module/PCM) logic has been modified to reduce the possibility of this condition. Follow the Repair Procedure in this bulletin to address this condition. Production Change Information This bulletin applies to vehicles produced BEFORE the Production Change Effective VIN shown below. MODEL YEAR MODEL ENGINE PRODUCTION CHANGE EFFECTIVE VIN 2023 Crown T24A-FTS JTDAFAAF5P3004503 Warranty Information OP CODE DESCRIPTION TIME OFP T1 T2 EL2320 Reprogram the ECM (PCM) 0.7 89661-4D650 8A 74 APPLICABLE WARRANTY This repair is covered under the Toyota Federal Emissions Warranty. This warranty is in effect for 96 months or 80,000 miles, whichever occurs first, from the vehicle’s in-service date. Warranty application is limited to occurrence of the specified condition described in this bulletin. © 2023 Toyota Motor Sales, USA Page 1 of 3 T-SB-0101-23 December 20, 2023 Page 2 of 3 MIL ON With DTC P2C9000 Parts Information PART NUMBER PART NAME QTY 89661-4D650 Computer, Engine Control 1 NOTE The ECM (PCM) should NOT be replaced as part of the Repair Procedure. Required Tools & Equipment SPECIAL SERVICE TOOLS (SST) PART NUMBER QTY Battery Diagnostic Tool DCA-8000P T 1 *Essential SST. NOTE Additional SSTs may be ordered by calling 1-800-933-8335. REQUIRED EQUIPMENT SUPPLIER PART NUMBER Techstream ADVI* TSADVUNIT Techstream 2.0 TS2UNIT ADE 1 Techstream Lite TSLITEPDLR01 Techstream Lite (Green Cable) TSLP2DLR01 *Essential SST. NOTE Only ONE of the Techstream units listed above is required. GTS+ software version 2023.04.003.02 or later is required. Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at 1-800-368-6787. Use Techstream or an approved J2534 interface to perform flash reprogramming updates. Visit techinfo.toyota.com for more information regarding J2534 reprogramming. Calibration Information CALIBRATION ID MODEL YEAR MODEL ENGINE PREVIOUS NEW 8A2223009200 2023 Crown QTY T24A-FTS 8A2223009100 8A2223009000 © 2023 Toyota Motor Sales, USA 8A2223009300 T-SB-0101-23 December 20, 2023 Page 3 of 3 MIL ON With DTC P2C9000 Repair Procedure 1. Confirm the condition exists. Does the vehicle exhibit a MIL ON condition with the DTC P2C9000 (Crankcase Ventilation System – Hose A Disconnected) present without ANY related hoses disconnected? YES — Continue to step 2. NO — This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual. 2. Diagnose the DTC P2C9000. Refer to TIS, applicable model and model year Repair Manual: 2023 Crown: Engine/Hybrid System – Engine Control – “T24A-FTS (Engine Control): SFI System: P2C9000; Crankcase Ventilation System – Hose “A” Disconnected” Does the diagnosis indicate ANY of the procedure steps in the Repair Manual as the cause? YES — This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual. NO — Continue to step 3. 3. Flash reprogram the ECM (PCM). NOTE The battery diagnostic tool MUST be used in Power Supply Mode to maintain battery voltage at 13.5V while flash reprogramming the vehicle. For details on how to use the battery diagnostic station, refer to the DCA-8000 Instruction Manual located at TIS – Diagnostics – Tools & Equipment – Battery Diagnostics. Follow the procedures outlined in T-SB-0107-20 GTS+ ECU Flash Reprogramming With Security Signature, and flash the ECM (PCM) with the NEW calibration file update. 4. Using GTS+, clear ANY DTCs and test-drive the vehicle in accordance with the driving pattern described in the confirmation driving pattern to confirm the condition is no longer present. Refer to TIS, applicable model and model year Repair Manual: 2023 Crown: Engine/Hybrid System – Engine Control – “T24A-FTS (Engine Control): SFI System: P2C9000; Crankcase Ventilation System – Hose “A” Disconnected” © 2023 Toyota Motor Sales, USA