3512082032211
Service Bulletin Details
Models from 2012
2012 AUDI S4 |
2012 AUDI S5 CABRIOLET |
Models from 2011
2011 AUDI S4 |
2011 AUDI S5 CABRIOLET |
Models from 2010
2010 AUDI S4 |
2010 AUDI S5 CABRIOLET |
Technical Service Bulletin 35 Gearbox warning light on (DTCs P179E00, P179F00, P0700, P060A) 35 12 08 2032211/1 December 21, 2012. Model(s) Year S4 2010-12 S5 Cabriolet 2010-12 VIN Range Vehicle-Specific Equipment All 0B5 S-Tronic transmission Condition The driver information system displays the message: Two possible scenarios exist for this TSB to apply: Condition 1 The following entries are logged individually or in combination, with P179E logged first (using DTC environmental data): P179E – Drive range sensor Electrical P0700 (DFCC: 20196) – Control Module Malfunctioning P1758 (DFCC: 8464) – Terminal 15 Voltage supply Open circuit P060A (DFCC: 8126, 8345) – Control Module Internal Processor Monitoring If P179E is not logged first this TSB does not apply (using DTC environmental data), Continue with standard diagnosis. Condition 2 The following entries are logged individually or in combination in the diagnosis protocol. The times the DTCs are logged are not relevant: P179E (DFCC: 8050, 8051, 8052, 8053) – Drive range sensor Electrical P179F (DFCC: 8054, 8055, 8056, 8057) Sensor for transmission range, malfunction P0716 (DFCC: 8096, 8101) Transmission Input Speed Sensor 1 Implausible Signal Page 1 of 6 © 2012 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin P171F (DFCC: 8097, 8102) – Input Turbine/Speed Sensor Circuit 2 Range/Performance P0715 (DFCC: 8094, 8103) – Transmission Input Speed Sensor 1 Electrical Malfunction P2765 (DFCC: 8095, 8104) – Transmission Input Speed Sensor 2 Electrical Malfunction P0501 (DFCC: 8098) – Vehicle Speed Sensor 1 Range/Performance P2159 (DFCC: 8099) – Vehicle Speed Sensor 2 range/Performance The DFCC is the 4-6 digit code that is typically listed before the fault code (Figure 1). Figure 1. DFCC 4-6 digit code listed before the fault code. Tip: Fault codes and DFCC codes must match exactly or this TSB should not be followed. Technical Background Incorrect driving mode sensor module. Production Solution Not applicable. Page 2 of 6 © 2012 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Service 1. If faults shown in Condition above along with the matching DFCC’ s are present, replace the G676 sensor module with c board by following instructions in ELSA >> Repair manual >>Transmission >>S Tronic Transmission Internal Components Gears, Shafts >>Removal and Installation >> Sensor Module with Transmission Input Speed Sensor -G612-,-G632-, -G67 Circuit Board 3 2. When replacing the sensor module, its wiring loom must also be replaced. Note: These instructions require transmission case disassembly. Audi Academy course #950224 is required viewing bef attempting repair service. Complete the course and the assessment #950224B before attempting repair or warranty claim may denied. This can be found on the Audi Academy CRC site. Tip: Use caution when lifting or lowering intermediate housing to avoid damage to components (Figure 2). Figure 2. Caution points: Drip tray- Sensor module connector. Page 3 of 6 © 2012 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Warranty Claim Type: Use applicable claim type. If vehicle is outside any warranty, this Technical Service Bulletin is informational only. Service Number: 3512 Damage Code: 0012 Labor Operations: Remove and install 3435 19xx gearbox See ELSA Web for applicable labor operation Replaced sensor module 3512 1950 570 TU 0150 0000 Time stated on diagnostic G676 Diagnostic Time: GFF to perform basic protocol (Max 100 TU) setting and adaptation after replacing sensor Road test prior to service No allowance 0 TU 0121 0004 10 TU procedure Road test after service procedure Technical diagnosis at dealer’ s discretion (Refer to Section 2.2.1.2 and Audi Warranty Online for DADP allowance details) Claim Comment: As per TSB 2032211/1 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. Page 4 of 6 © 2012 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin Required Parts and Tools Part Number Part Description Quantity 0B5321371E Gasket for transmission pan 1 N10405702 Bolts for Mechatronics unit 6 G052513A2 Front Final Drive oil (MTF) 5.0 Liters G052529A2 Dual clutch gearbox oil (ATF) 7.5 Liters 0B5927321F Module 1 0B5321391A Harness 1 AMV18800102 Sealing paste 1 0B5301515H Pump with seals 1 WHT001955 Bolt 1 WHT002459 Bolt 28 WHT001958B Bolt 2 0B5301227C Seal kit 1 0B5323525B O-ring 1 0B5311113F Seal 1 0B5315105TC Oil pipe with seals 1 0B5315105TA Oil pipe with seals 1 0B5325571 Sleeve with seals 1 Page 5 of 6 © 2012 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Technical Service Bulletin 0B5311944B Seal 4 0B5321473 Oil pipe 1 WHT003380 Seal 1 WHT003379 Seal 1 0B5301311E Oil drip tray (Replace if broken) 1 Additional Information All parts and service references provided in this TSB are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information. Page 6 of 6 © 2012 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.