Chrysler Concorde 1996

• Recall 41981 [USA]: Either circumstance may result in the vehicle rolling away without warning.
  On certain passenger vehicles, the floor shifter ignition-park interlock may fail and allow the shifter to be moved out of the park position with the key removed. An inoperative interlock may also allow the key to be removed when the shifter has not been placed in the park position.
  dealers will install a new load-limiting push rod into the floor shifter lever of the affected vehicles. Owner notification began on june 14, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.
  daimlerchrysler recall no. C45.Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 14267 [USA]: Fuel leakage in the presence of an ignition source can result in a fire.
  Vehicle description: passenger vehicles built with 3.5l engines. The fuel injection delivery system can leak fuel from some of the sealing o-rings or from hair line cracks in the thermoset fuel injection rail.
  dealers will replace the fuel rail o-rings and reinforce the outlet (passenger) side fuel rail. Vehicles showing fuel leakage on the outlet fuel rail must have the outlet rail replaced which includes changing the upper and lower injector o-rings. However, if a vehicle is leaking fuel from the o-rings or from a cracked fuel line, the vehicle should be taken into a dealer to have this repaired as soon as possible.
  owner notification began during january 1999. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 2004003 [Canada]: Other
  On certain vehicles equipped with an automatic transmission and a floor-mounted shifter, the ignition-park interlock may become defeated and allow the shifter to be moved out of the park position with the key removed. An inoperative interlock may also allow the key to be removed when the shifter has not been placed in the park position. This may result in the vehicle rolling away without warning. Correction: dealer will inspect the function of the ignition-park interlock system. Vehicles found with functional interlock systems will have a load-limiting push rod installed into the floor shifter lever. Vehicles with a non-functional ignition-park interlock system will have the shifter assembly replaced.

  Show Content

• Recall 1998167 [Canada]: Fuel supply
  Note: vehicles equipped with 3.5 litre engine. The fuel injection delivery system may leak fuel from some of the sealing "o-rings" or from hairline cracks in the thermoplastic fuel injection rail. In the presence of an ignition source such a condition could result in a fire. Correction: the nitrile rubber "o-rings" will be replaced with "o-rings" made of an improved material. The fuel rail will also be evaluated and replaced as required.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Fuel rail, brake fluid, chassis investigation # DP04007

  There is no summary currently available
  

  Show Content

• Auto trans ignition-park interlock investigation # EA03011

  The manufacturer reports above are based on daimlerchrysler?S (dc) analysis of model year (my) 1998 (population = 356,384) and 1999 (population = 486,948) ja, jx and lh family subject vehicle data (earlier mys excluded).The population number includes all mys.The precise number of duplicates between odi and dc reports cannot be determined due to missing or incomplete information.The fatality incident involved an elderly person who attempted to stop a roll away vehicle and received fatal injuries.Odi also gathered information on my 1997-99 prowler vehicles in this investigation. The prowler vehicles were manufactured with a different design shifter mechanism (the shift lever is shorter).There are no complaints of prowler interlock failure in odi?S database, and dc has received no reports either.The prowler is excluded from the recall scope.The investigation involved a condition where the interlock system could fail (or be made inoperative by the operator) during vehicle use, possibly inadvertently.The interlock system is required under fmvss 114.With the transmission in the park position and the ignition key off, the combined action of pressing the shift button and pulling the shift lever rearward may result in the operator overcoming the interlock system and cause the mechanical linkage of the system to disconnect.When this occurs, there is no overt indication to an operator that the system is defeated, and an increased risk of vehicle roll-away exists.Under recall 04v021, dc will replace damaged shift mechanisms, and will install on all vehicles a device which inhibits the operator?S ability to overcome the interlock and defeat the system.Beginning with my 2000, dc incorporated a brake and transmission shifter interlock (btsi) system into the subject vehicles.Introduction of btsi involved design changes to the shift mechanism, one of which resulted in reduced mechanical advantage (rma) of the shift button.The rma shifter requires increased forces to overcome the interlock system, making the shifter less susceptible to damage.
  

  Show Content

• Steering system rack and pinion investigation # EA99031

  There is no summary currently available
  

  Show Content

• Fuel injection delivery system fuel leak investigation # RQ98018

  
  

  Show Content

I'm sorry, but i don't remember the exact milage on the car. The speed limit was 40 , but i was not going that fast because 1) the road was wet because it had just rained lightly, maybe 8 minutes prior 2) i saw the other driver's car was in my lane. I was hit pretty much head on. My air bags did not deploy! I had to be cut out of my car.Thus my beautiful concord was a total loss. It had been in excellent condition.

Tl* the contact owns a 1996 chrysler concorde. The contact stated that her vehicle was included and repaired in the recall under nhtsa campaign number: 98v184000 (fuel system, gasoline). While parked, the contact noticed a strong fuel smell. The vehicle was taken to a local mechanic for diagnosis. The mechanic stated that the driver's side fuel rail had fractured causing a fuel leak. The manufacturer was made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 60,000. *tr

Quick-struts after market replacement parts may be defective. This product is called a monroe quick- strut. The failed part was returned for warranty replacement: part #171939. The top of the strut, nut, and steal washer "tore free" of the plate which compresses the spring. The 'top plate' part of the assembly remained anchored to the car by three nuts located in the trunk. This plate no longer contained the strut and the compressed spring as supplied in quick strut assembly. The assembly as purchased, has a nut and washer mounted in two inches of rubber molded in the plate on top of the strut spring assembly. That rubber component failed. This becomes obvious after the parts are removed from the vehicle. The oem part contains a large washer located on the top which would prevent this type of failure. This failure could result in loss of control of the vehicle while driving. *tr

We smelled gas from the engine area. Upon further inspection noted a leak in the fuel injection system . Gas was dripping every 1 second near the o ring by the outlet fuel rail. Help!. This vehicle is not a 3.5l engine but a 3.3l 1996 chrysler concorde. I know the 3.5l had a recall on this did the 3.3l have one also and noone notice????? Also when you put the floor shifter into gear i.E. Drive, the vehicle does not move forward, or if in reverse that either. Then it jerks into gear almost like the shifter or leavers are not working. I have had this vehicle looked at for transmission problems and that is not the issue. I do believe it may be a shifter issue and then the o ring leaking gas like a dripping faucet. *tr

Strong smell of gasoline coming from the engine compartment on my 1996 chrysler concorde lxi 3.5l vin f. This car was bought used in september 2010 and the odor has become much stronger in the past 3 months. I am fearing a fire may occur. Gas mileage has greatly decreased to about 12-15 mph. *tr

1. "busy rattle", not loud, but continuous, most noticeable on smooth roads above 30 mph, from front frame sub-assembly, four mounting bolts. The sub-frame assembly is also called the "motor carrier" and is bolted from the bottom up to the frame (above). Each bolt goes through a large rubber bushing (also called an insulator). With 75,000 thousand miles and no oil leaks, the rubber bushings are all dried out and flaking apart. Each insulator cost over a hundred dollars and is only available from chrysler. The cost of replacing via a quote from pep boys is over seven hundred dollars. The replacement parts are made from a hard yellow plastic type material and should be more durable. 2. According to the mechanic at pep boys the vibration will wear the bolts and eventually the engine could drop down. 3. Pep boys recommends the bushings and the bolts to be replaced. The new bushings from chrysler have a 1 year warranty. Reviewed the complaints for this problem and did not see any accidents caused by the rattle or a report that the engine actually could fall out on the road. The data base is not well organized as it is segmented by monthly reports. I can see how the noise might cause one to increase the radio volume and not hear an emergency vehicle. These bushings will be replaced. *tr

A popping sound was coming from the front left side of the vehicle when the brakes were applied. Steering wheel constantly vibrates and has since i've owned the vehicle. A july 2008 safety inspection revealed "excessive play" in the steering linkage and left outer tierod was bad. Repairs performed and the same thing happened yet again three months later. After learning of all the complaints related to steering problems in chrysler vehicles, i now fear for my safety and that of my family. Chrysler needs to held responsible for the dangerous products they are putting on the market. *tr

I've had a 1996 chrysler concorde lx for about 1 yr. It has always had problems when i put the key in the ignition 99% of the time i have to keep turning the key until it turns on, if it even does, and a few months ago everytime my car does turn on, all the interior lights stay on while driving and the door locks keep going up and down. It hasn't been drivable for at least 2 months now. Replaced relays, fuses, starter, alternator, battery! I even took it to a shop which the manager is a family friend, he had it for 2 wks. Ran a full diagnostic and also the battery which is new and have exchanged several times will not hold a charge. It has new battery ground cable new cable from alternator to starter connection, new spark plugs and wires and still has all these problems. And now if the car will turn on the abs light comes on. Car was overheating and it now has a new thermostat. This is the worst vehicle i have ever owned! And now the power steering pump has begun leaking. And a few times i have noticed the gears shift. The most frightening thing is when it does start, it will drive good for about 2 blocks and then, it just totally shuts down with no warning lights or signs prior to shutting down. I am a disabled individual and am so stressed out because it is literally undrivable. After i bought this car the 1st thing i noticed after about a week was the problem when turning the key in ignition over and over again till it would finally start. Sometimes i would sit in the car 15 minutes before it would start. I'm surprised i haven't heard anyone else mention this problem. I have a lemon and don't know what to do. I've missed dr. Appts. And also my son is disabled and we're just having the most terrible time with no reliable transportation. Can u please post if any of these issues are some of chryslers unreported defects or recalls. Please help! *tr

My husband, 2 children, ages 4 and 6, and myself were driving on the interstate when our 1996 chrysler concorde suddenly shifted into neutral and started rolling backward down a hill. We hadn't had any problems up to this point. Our car only has 40,000 original miles on it. A transmission repair firm told us it was our transmission and gave us a diagnostic code of "P1787". We can't afford to fix right now. We have tried it on our residential street and it goes for a few yards and transmission slips. I have had a lot of medical problems this year and not having safe transportation has made it impossible to get medical care, not to mention the fact that my children could have been hurt by this vehicle malfunctioning. *tr

Common OBD-II Error Codes

• P361A [1] P361A
• P1787 [1] P/ES Circuit Out Of Self Test Range