Ford E-150 2008

• Recall 118672 [USA]: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. this failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
  Mobilityworks (wmk inc.) is recalling certain model year 2006-2014 ford e-150, e-250, and e-350 vans modified by mobilityworks to be equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
  mobilityworks will notify owners, and ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on december 15, 2015. Owners may contact mobilityworks customer service at 1-800-769-8267, or ricon customer service at 1-800-322-2884. Note: these vehicles and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 109203 [USA]: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. when the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
  Cummings mobility conversion & supply (cummings) is recalling certain model year 2006-2014 ford e-150, e-250, e-350, chevrolet express, 2006-2008 dodge sprinter, and 2009-2014 mercedes-benz sprinter, and 2013 ford transit connect vehicles manufactured january 1, 2006, to october 8, 2014, equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation after january 1, 2006. The platform side plate of the affected wheelchair lifts may crack.
  cummings will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began january 13, 2015. Owners may contact cumming's customer service at 1-800-639-5438 or ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14e-041.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 104686 [USA]: A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. if this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.
  Mobility specialists, inc. (mobility specialists) is recalling certain model year 2007-2008 ford e-150 vans modified by mobility specialists and equipped with braun ncl-2, and nvl-2 wheel chair lifts. Over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.
  mobility specialists will notify owners and will replace the affected parts, free of charge. The recall began in july 2014. Owners may contact mobility specialists customer service at 1-877-777-5438.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 97480 [USA]: If the cable does not clear the wheel chair lift it may contact the power lug and, if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, a short circuit may occur that could result in a fire.
  Mobility works is recalling certain model year 2006-2012 ford e-150, e-250 and e-350 vehicles manufactured august 2006 through august 2012. The vehicles are equipped with certain ricon s series and k series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.
  mobility works will notify owners and ricon will provide a supplemental cover kit and instructions, free of charge. This recall campaign is expected to begin july 15, 2013. Owners may contact mobility works at 1-877-275-4912 and ricon at 1-818-267-3000.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 94190 [USA]: A fuel leak in the presence of an ignition source may result in a fire.
  Ford is recalling certain replacement fuel tanks that could be installed into model year 2004 through 2008 e-150, e-250, and e-350 vans and wagons. The affected fuel tanks have an extra obdii sensor hole on the top of the tank that may not be properly sealed and may leak fuel.
  ford will notify owners, and dealers will replace the fuel tanks free of charge. The safety recall began on november 28, 2011. Owners may contact ford motor company customer relationship center at 1-800-232-5952.
  ford's recall campaign number is 11s22.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 68588 [USA]: When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
  Mobility transportation (mts) is recalling certain model year 2007 through 2009 conversion vans built on ford e150, e250, and e350 chassis from september 16, 2008 through april 15, 2009 and fitted with certain ricon s series and k series l-model wheelchair lifts. Due to a problem in the software that controls the lift's "up" function, should the "up" button be released before the floor level limit switch is activated, the lift may continue its upward travel and may overrun the floor level cut off point.
  mts will notify owners and the repairs will be performed by authorized ricon dealers free of charge. A software solution for this safety defect is under investigation. Until the software solution is available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. The safety recall began on october 18, 2010. Owners may contact ricon at 1-818-267-3000 or mts at 1-734-453-6452.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 80582 [USA]: The user of the lift could be injured should the lift move without the restraint belt properly buckled.
  Mobility transportation (mts) is recalling certain model year 2007 through 2009 conversion vans built on ford e150, e250, and e350 chassis from september 16, 2008 through april 15, 2009 and fitted with ricon public use lifts. The restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. Ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. In this case, the restraint belt would appear to be latched, and the operator could run the lift. If the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.
  mts is working with ricon and ricon will be performing the remedy for this campaign. Please see ricon's defect report 09e-060. Ricon will provide customers with a warning decal and a dvd-based training aid. The safety recall began on october 18, 2010. Owners may contact ricon at 1-818-267-3000 or mts at 1-734-453-6452.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 82745 [USA]: When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
  Mobility works is recalling certain model year 2008 and 2009 conversion vans built on ford e150, e250, and e350 chassis and chevrolet 2500 chassis after november 2007 and fitted with certain ricon s series and k series l-model wheelchair lifts. Due to a problem in the software that controls the lift's "up" function, should the "up" button be released before the floor level limit switch is activated, the lift may continue its upward travel and may overrun the floor level cut off point.
  mobility works will notify owners and the repairs will be performed by authorized ricon dealers free of charge. A software solution for this safety defect is under investigation. Until the software solution is available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. The safety recall began on august 20, 2010. Owners may contact ricon at 1-818-267-3000 or mobility works at 1-800-769-8267.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 68680 [USA]: The user of the lift could be injured should the lift move without the restraint belt properly buckled.
  Comm-trans is recalling certain model year 2007-2009 ada conversion vans built on ford e-150, e-250, and e-350 chassis between december 7, 2007 and december 23, 2009 and fitted with ricon public use lifts. The restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. Ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. In this case, the restraint belt would appear to be latched, and the operator could run the lift. If the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.
  comm-trans is working with ricon and ricon will be performing the remedy for this campaign. Please see ricon's defect report 09e-060. Ricon will provide customers with a warning decal and a dvd-based training aid. The safety recall began on july 6, 2010. Owners may contact ricon at 1-818-267-3000 or comm-trans at 1-901-726-9394.
  this recall only pertains to vehicles altered by comm-trans and has no relation to any vehicles manufactured by ford motor company.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 81943 [USA]: When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
  Comm-trans is recalling certain model year 2007-2009 ada conversion vans built on ford e-150, e-250, and e-350 chassis between december 7, 2007 and december 23, 2009 and fitted with certain ricon s series and k series l-model wheelchair lifts. Due to a problem in the software that controls the lift's "up" function, should the "up" button be released before the floor level limit switch is activated, the lift may continue its upward travel and may overrun the floor level cut off point.
  comm-trans will notify owners and the repairs will be performed by authorized ricon dealers free of charge. A software solution for this safety defect is under investigation. Until the software solution is available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. The safety recall began on july 6, 2010. Owners may contact ricon at 1-818-267-3000 or comm-trans at 1-901-726-9394.
  this recall only pertains to vehicles altered by comm-trans and has no relation to any vehicles manufactured by ford motor company.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 87815 [USA]: The user of the lift could be injured should the lift move unintentionally.
  Cummings is recalling 42 my 2006-2008 ford e150, e350, chevrolet express, my 2006 ford e250, gmc savanna, dodge sprinter conversion vans, and my 2007 newmar dutchstar motor homes equipped with ricon platform style wheelchair lifts. These buses fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installation in motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area.
  cummings is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). Owners may contact ricon at 1-818-267-3000 or cummings at 1-763-498-7887.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 85162 [USA]: A lift occupant can be injured should the lift begin to stow unintentionally.
  Cummings is recalling 42 my 2006-2008 ford e150, e350, chevrolet express, my 2006 ford e250, gmc savanna, dodge sprinter conversion vans, and my 2007 newmar dutchstar motor homes equipped with ricon platform style wheelchair lifts. These lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift systems for motor vehicles." the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. The pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. The lift could stow even though someone or something is still on the lift.
  cummings is working with ricon to correct the wheelchair lifts free of charge (please see 07e097). Owners may contact ricon at 1-818-267-3000 or cummings at 1-763-498-7887.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 80949 [USA]: The user of the lift could be injured should the lift move unintentionally.
  Accubuilt is recalling 890 my 2006-2008 ford e150, e250, and e350 cargo vans equipped with ricon platform style wheelchair lifts. These buses fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installation in motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area.
  accubuilt is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). The recall is expected to begin on or about october 6, 2008. Owners may contact ricon at 1-818-267-3000 or accubuilt at 1-800-837-8624.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 78252 [USA]: A lift occupant can be injured should the lift begin to stow unintentionally.
  Accubuilt is recalling 890 my 2006-2008 ford e150, e250, and e350 cargo vans equipped with ricon platform style wheelchair lifts. These lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift systems for motor vehicles." the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. The pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. The lift could stow even though someone or something is still on the lift.
  accubuilt is working with ricon to correct the wheelchair lifts free of charge (please see 07e097). Owners may contact ricon at 1-818-267-3000 or accubuilt at 1-800-837-8624.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 78016 [USA]: The user of the lift could be injured should the lift move unintentionally.
  Mobilityworks is recalling 224 my 2007-2008 ford e150, my 2006-2008 e250, my 2004-2007 e350, my 2006 e450, my 2005-2007 chevrolet 2500, my 2007 chevrolet 1500, and my 2006 dodge 2500 vans equipped with ricon platform style wheelchair lifts. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installations in motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area.
  mobilityworks is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). Owners may contact ricon at 1-818-267-3000 or mobility works at 1-800-769-8267.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

Air bag code 33 flashing on dash . Ford states driver side seat belt buckle to be replaced at $ 527.00 . Is this not a safety issue by that ford should address at no cost to the consumer ? Please help .

Tl* the contact owns a 2008 ford e-150. The contact stated that the vehicle rode roughly as if it were being driven over rocky terrain. In addition, the air pressure indicator was illuminated. The vehicle was taken to an independent mechanic, but it could not be repaired. The vehicle was not repaired. The dealer and manufacturer were not made aware of the failure. The failure mileage was 90,000. The vin was invalid.

While applying the brakes to park the car the was a loud rifle shot sound, flash and vehicle jolt from under the hood. And the break warning light came on. During repair the mechanic found that the problem was the with the master cylinder cruse control cancelling switch. The switch blew apart and ignited the atomized break fluid that was expelled from the master cylinder. Fortunately the exploding break fluid self extinguished avoiding an engine compartment fire. Since the triggering of this event was the act of applying the brakes it was only by chance that it didn't happen at highway speeds. The event totally disabled the front brakes and at highway speeds the brake fluid mist would have likely ignited further back in the engine compartment or under the chassis. There have been numerous recalls of ford products over a 20+ year period for this switch component causing both fires and deaths but this vehicle's s/n was not on the list for getting notified. Looks like someone didn't do their "homework" on this one, i am not sure this vehicle is safe to drive. I have the repair bill for the replacement work and the gentleman showed me the blown out shell of the switch. I picked up one of the parts from our parking slab. I have notified ford by email.

Tl* the contact owns a 2008 ford e-150. The contact stated that the vehicle failed to shift from reverse into drive. The vehicle was taken to a dealer, who diagnosed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 53,000.

Tl* the contact owns a 2008 ford econoline van e150. The contact stated that while driving approximately 25 mph, the vehicle stalled without warning. The contact tried to restart the vehicle. The check engine and electronic throttle warning lights illuminated. The vehicle was able to be restarted but when the failure would recur when the engine rpms increased over 2,000. The vehicle was not taken to a dealer. The manufacturer was notified of the problem. The approximate failure mileage was 66,325.

Tl* the contact owns a 2008 ford e-150. The contact stated that while driving at various speeds, a rattling noise emitted from the under carriage. The vehicle was taken to a private mechanic who found that the catalytic converter welding had failed and caused the pipes to fracture. The vehicle was not repaired. The approximate failure mileage was 89,000 and the current mileage was 93,000.

Burnt cam from lack of oiling. Dealer unable to repair, said new engine only option. Ford would not pay for new engine. Warranty stated drivetrain warranty good for 60,000 miles or five years.

Tl* the contact owns a 2008 ford e-150 van. The contact was driving 45 mph when the electronic throttle control warning light illuminated and the vehicle proceeded to stall. The vehicle was taken to the dealer six times regarding the failure. The manufacturer was contacted. The vehicle was not repaired. The failure mileage was 98,452 and the current mileage 101,600. Updated 04/25/12 *bf updated 06/07/12 *js

Common OBD-II Error Codes

• P0733 [1] Gear 3 Incorrect ratio
• P0734 [1] Gear 4 Incorrect ratio