Ford F-450 Super Duty 2014

• Recall 105716 [USA]: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
  Jerr-dan corporation (jerr-dan) is recalling certain model year 2009-2014 ford f-350 super duty, f-450 super duty, and f-550 superduty chassis modified by jerr-dan and equipped with certain muncie power products pto assemblies. In the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
  jerr-dan will notify owners, and dealers will install a new pressure switch kit that moves away from the exhaust system, free of charge. The recall began in october 2014. Owners may contact jerr-dan customer service at 1-800-926-9666.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 2019420 [Canada]: Other
  Issue: this recall is for aftermarket replacement rear window glass produced by vitro automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: this is a voluntary recall that is not being conducted under the requirements of the motor vehicle safety act. Safety risk: glass that breaks in to large pieces could create a risk of injury. Corrective actions: the company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “dot 287” along with the lettering “vmr” (replacement market) and a date code that is before july 2019. This information is printed on the bottom corner of the glass. Consumers should contact vitro's customer service at 1-412-995-6457 or [email protected] to arrange for replacement of the glass.

  Show Content

• Recall 2015125 [Canada]: Engine
  Certain ambulance or fire package vehicles with 6.7l diesel engines may experience a "stop safety now" warning message and 5 audible chimes if an exhaust gas temperature (egt) sensor fault is detected. Engine torque would be gradually reduced by 70 percent over a period of 45 seconds to a power-reduced level that is maintained. During this time, there would be no effect on steering, braking, lighting, electrical, or restraint systems, allowing the operator to maneuver the vehicle to a safe location. Such an occurrence could also result in an engine shut down and subsequent inability to quickly restart the vehicle. If this condition were to occur when an ambulance or fire engine vehicle was transporting a patient or providing medical assistance, it could delay medical treatment and increase the risk of injury to the patient. Correction: dealers will reprogram the powertrain control module with updated software.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Vehicle commanded engine shutdown investigation # RQ14005

  The office of defects investigation (odi) opened this rq to investigate allegations that the scope and remedy of safety recall 13v-535 were inadequate. Recall 13v-535 was limited to a relatively small population of "ambulance package" vehicles and odi received complaints of pickup trucks and "fire engine prep package" vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between february 22, 2010 and january 30, 2015 that may be affected by defective egt sensors and powertrain control module (pcm) software calibration. The subject vehicles are equipped with four (4) egt sensors to monitor engine operating conditions. An egt sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the powertrain control module (pcm) implements a failure management effects mode (fmem) and the driver receives a "stop safely now" (ssn) system warning on the instrument cluster message center. The fmem triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The pcm then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the pcm software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute "cool down" period.Ford and its component supplier(s) made numerous changes to the pcm software calibration and the design, material and manufacture of the egt sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to "ambulance package" and "fire engine prep package" vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15v-175) to address the 13v-535 remedy concerns in the "ambulance package" vehicles and "fire engine prep package" vehicles. The 15v-175 remedy reprograms the pcm with a new software calibration that stops a single egt sensor fault to cause the vehicle to enter the fmem shutdown mode.Ford also initiated an epa emissions recall (14e03) for all subject vehicles that reprograms the pcm with the software calibration employed in safety recall 15v-175. Finally, ford initiated a customer satisfaction program (15m01) providing extended warranty coverage of 8 years or 80,000 miles for the the egt sensors on certain my2011-2012 subject vehicles.Due to the epa emissions recall, that had a 66.6% completion rate in fords december 2015 progress report to the epa, the defect trend is in decline. Odi is not aware of any crashes, deaths or injuries related to the alleged defect.Odi believes the alleged defect poses a safety risk but notes that the epa emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this recall query is closed.This action is not a finding that no defect exists and nhtsa will take further action if such action is warranted.
  

  Show Content

I was in an accident on 7/6/2015. I received burns on both hands and left forearm. I also received a torn rotator cuff and chest bruising from seat belt. I do not think the airbag should have caused burns to my skin. I would like to know if this should have occurred.

Common OBD-II Error Codes

• P2043 [1] Reductant Temperature Sensor Circuit Range/Performance
• P205C [1] Reductant Tank Temperature Sensor Circuit Low