JTB00493NAS2

Service Bulletin Details

Public Details for: JTB00493NAS2

Situation: a 'howl' noise may be evident from the vehicle at low-speed overrun (between 1,800-1,100 rpm).


- 2017 - 2016 -

Models from 2017
2017 JAGUAR F-PACE
2017 JAGUAR XE
2017 JAGUAR XF
Models from 2016
2016 JAGUAR XF 
Page 1 of 8
TECHNICAL BULLETIN
JTB00493NAS2
15 JUL 2016
© Jaguar Land Rover North America, LLC
NOTE: The information in Technical Bulletins is intended for use by trained, professional Technicians with the knowledge, tools, and
equipment required to do the job properly and safely. It informs these Technicians of conditions that may occur on some vehicles, or
provides information that could assist in proper vehicle service. The procedures should not be performed by 'do-it-yourselfers'. If you
are not a Retailer, do not assume that a condition described affects your vehicle. Contact an authorized Jaguar service facility to
determine whether this bulletin applies to a specific vehicle.
This reissue replaces all previous versions. Please destroy all previous versions.
Changes are highlighted in gray
SECTION: 307-00
'Howl' Noise From Automatic Transmission Oil Cooler On Low-Speed Overrun
AFFECTED VEHICLE RANGE:
XE (X760)
Model Year:
VIN:
Assembly
Plant:
XF (X260)
Model Year:
VIN:
Assembly
Plant:
F-PACE (X761)
Model Year:
VIN:
Assembly
Plant:
GTDi 2.0L Petrol/V6 S/C 3.0L Petrol , Vehicles With:
8HP70 8-Speed Automatic Transmission AWD/8HP45
8-Speed Automatic Transmission AWD/8HP45 8-Speed
Automatic Transmission RWD
2017
942528-956079
Solihull
V6 S/C 3.0L Petrol , Vehicles With: 8HP70 8-Speed
Automatic Transmission AWD/8HP45 8-Speed Automatic
Transmission AWD/8HP45 8-Speed Automatic
Transmission RWD
2016-2017
Y00461-Y36056
Castle Bromwich
V6 S/C 3.0L Petrol , Vehicles With: 8HP70 8-Speed
Automatic Transmission AWD/8HP45 8-Speed Automatic
Transmission AWD/8HP45 8-Speed Automatic
Transmission RWD
2017
046303-065988
Solihull
MARKETS:
NAS
CONDITION SUMMARY:
Situation: A 'howl' noise may be evident from the vehicle at low-speed overrun (between 1,800-1,100 RPM).
Cause: This may be caused by the automatic transmission oil cooler transmitting an oil flow noise through the front
subframe which causes excessive Noise, Vibration and Harshness (NVH) into the cabin area.
Action: Should a customer express this concern, follow the Service Instruction below.
PARTS:
XR817826
Foam Pad
4
TOOLS:
Refer to Workshop Manual for any required special tools.
WARRANTY:
NOTE: Repair procedures are under constant review, and therefore times are subject to change; those
quoted here must be taken as guidance only. Always refer to TOPIx to obtain the latest repair time.
NOTE: DDW requires the use of causal part numbers. Labor only claims must show the causal part
number with a quantity of zero.
DESCRIPTION
SRO
TIME (HOURS)
http://topix.jaguar.jlrext.com/topix/service/document/671826
CONDITION CODE
CAUSAL PART
8/3/2016
Page 2 of 8
Oil cooler bracket - NVH pad - Renew
44.91.46
0.5
42
C2Z18818
NOTE: Normal Warranty procedures apply.
SERVICE INSTRUCTION:
NOTE: Graphics may have parts removed for clarity.
1. Remove the air deflector (see TOPIx Workshop Manual section 501-02: Front End Body Panels - Air Deflector).
2. Remove the bolt from the automatic transmission oil cooler bracket.
3.
NOTE: Do not disconnect any coolant or oil pipe from the automatic transmission oil cooler.
Position the automatic transmission oil cooler to one side.
http://topix.jaguar.jlrext.com/topix/service/document/671826
8/3/2016
Page 3 of 8
4. Remove the automatic transmission oil cooler bracket.
http://topix.jaguar.jlrext.com/topix/service/document/671826
8/3/2016
Page 4 of 8
5.
NOTE: If no NVH pad is fitted, go to the next step.
Remove and discard the NVH pad from the automatic transmission oil cooler bracket.
6. Clean the surface of the automatic transmission oil cooler bracket.
http://topix.jaguar.jlrext.com/topix/service/document/671826
8/3/2016
Page 5 of 8
7. Install the new NVH pads as shown.
http://topix.jaguar.jlrext.com/topix/service/document/671826
8/3/2016
Page 6 of 8
8.
NOTE: Torque: 9 Nm +/- 1
Install the automatic transmission oil cooler bracket.
9. Install the automatic transmission oil cooler.
http://topix.jaguar.jlrext.com/topix/service/document/671826
8/3/2016
Page 7 of 8
10.
NOTE: Torque: 5 Nm
Install the bolt to the transmission oil cooler bracket.
http://topix.jaguar.jlrext.com/topix/service/document/671826
8/3/2016
Page 8 of 8
11. Install the air deflector (see TOPIx Workshop Manual section 501-02: Front End Body Panels - Air Deflector).
http://topix.jaguar.jlrext.com/topix/service/document/671826
8/3/2016

© dot.report 2024

Use of this information constitutes acceptance for use in an AS IS condition. There are NO warranties, implied or otherwise, with regard to this information or its use. Any use of this information is at the user's risk. It is the responsibility of user to evaluate the accuracy, completeness or usefulness of any information, opinion, advice or other content. EACH USER WILL BE SOLELY RESPONSIBLE FOR ANY consequences of his or her direct or indirect use of this web site. ALL WARRANTIES OF ANY KIND ARE EXPRESSLY DISCLAIMED. This site will NOT BE LIABLE FOR ANY DIRECT, INDIRECT or any other kind of loss.