09-029-15-3062

Service Bulletin
Mazda North American Operations
Irvine, CA 92618-2922
© 2015 Mazda Motor of America, Inc.
Subject:
Bulletin No:
09-029/15
Last Issued:
08/04/2015
FUEL FILLER LID DOES NOT OPEN OR CLOSE
APPLICABLE MODEL(S)NINS
2011-14 Mazda2
2012-15 Mazda5 vehicles with VINs lower than JM1CW******191244 (produced before June 2, 2015)
2013-16 CX-5 vehicles with VINs lower than JM3KE******668045 (produced before May 20, 2015)
DESCRIPTION
On some vehicles, the fuel filler lid will not open/close. This may be caused by snow with road salt being
brought into the footwell area. The melted salt water then flows along the opener lever (A) and enters into the
cable (B) causing the inner-cable to corrode and seize.
3062a
To correct the problem, a flange has been added to the fuel filler lid opener lever (A) to prevent water from flowing along the lever to the fuel filler lid cable.
0
3062b
Customers having this concern should have their vehicle repaired using the following repair procedure.
Page 1 of 2
CONSUMER NOTICE: The information and instructions in this bulletin are intended for use by skilled technicians. Mazda technicians utilize the proper tools/
equipment and take training to correctly and safely maintain Mazda vehicles. These instructions should not be performed by "do-it-yourselfers." Customers
should not assume this bulletin applies to their vehicle or that their vehicle will develop the described concern. To determine if the information applies,
customers should contact their nearest authorized Mazda dealership. Mazda North American Operations reserves the right to alter the specifications and
contents of this bulletin without obligation or advance notice. All rights reserved. No part of this bulletin may be reproduced in any form or by any means,
electronic or mechanical---including photocopying and recording and the use of any kind of information storage and retrieval system ---without permission in
writing.
Bulletin No: 09-029/15
Last Issued: 08/04/2015
© 2015 Mazda Motor of America, Inc.
REPAIR PROCEDURE
1. Verify customer complaint.
2. Replace the fuel-filler lid opener and fuel-filler lid opener cable with modified ones. Refer to MS3 on line
instructions or Workshop Manual section 09-10.
3. Verify repair.
PART(S) INFORMATION
Part Number
Description
Qty.
Notes
KD53-56-860A
Fuel-filler Lid Opener Lever
1
CX-5
1
Mazda2, MazdaS
1
CX-5
DF71-56-880
1
Mazda2
CC29-56-880A
1
MazdaS
CC29-56-860A
KD53-56-880
Fuel-filler Lid Opener Cable
WARRANTY INFORMATION
NOTE:
This warranty information applies only to verified customer complaints on vehicles eligible for warranty repair.
This repair will be covered under Mazda's New Vehicle Warranty.
Additional diagnostic time cannot be claimed for this repair.
Warranty Type
A
Symptom Code
41
Damage Code
9Y
Part Number Main Cause
Qty.
Operation Number:
Labor Hours:
KD53-56-860A (CX-5)
CC29-56-860A (Mazda2/Mazda5)
1
XXL4EARX
XXL4EBRX
1.0 Hrs. (Mazda2)
0.9 Hrs. (CX-5 without separate type
rear seat cushion)
1.1 Hrs. (MazdaS)
0.8 Hrs (CX-5 with separate type
rear seat cushion)
Page 2 of 2