A351623 2032211-
Service Bulletin Details
Public Details for: A351623 2032211-
This technical service bulletin provides instructions for diagnosing an issue with the g676 sensor module and replacing it.
- 2016 - 2015 - 2014 - 2013 - 2012 - 2011 - 2010 -
Models from 2016
2016 AUDI S6 |
2016 AUDI S7 |
Models from 2014
2014 AUDI RS5 |
2014 AUDI S4 |
2014 AUDI S5 |
2014 AUDI S5 CABRIOLET |
2014 AUDI S6 |
2014 AUDI S7 |
Models from 2013
2013 AUDI RS5 |
2013 AUDI S4 |
2013 AUDI S5 |
2013 AUDI S5 CABRIOLET |
2013 AUDI S6 |
2013 AUDI S7 |
Models from 2012
2012 AUDI S4 |
2012 AUDI S5 CABRIOLET |
Models from 2011
2011 AUDI S4 |
2011 AUDI S5 CABRIOLET |
Models from 2010
2010 AUDI S4 |
2010 AUDI S5 CABRIOLET |
35 Gearbox warning light on (DTCs P179E00, P179F00, P0700, P060A) 35 16 23 2032211/5 October 14, 2016. Supersedes Technical Service Bulletin Group 35 number 16-22 dated April 18, 2016 for reasons listed below. Model(s) Year VIN Range Vehicle-Specific Equipment S4 2010 - 2015 All S-Tronic 7 speed transmission S5 Cabriolet 2010 - 2015 All S-Tronic 7 speed transmission RS 5 2013 - 2014 All S-Tronic 7 speed transmission S5 2013 - 2015 All S-Tronic 7 speed transmission S6, S7 2013 - 2016 All S-Tronic 7 speed transmission Condition REVISION HISTORY Revision Date Purpose 5 - Revised Warranty (Updated Damage Code) 4 04/18/2016 Revised header data (Added model year 2015 S4 and S5 and model year 2016 S6 and S7) 3 01/11/2016 Revised Condition (Additional DFCC codes) The driver information system displays the message “Gearbox malfunction: you can continue driving”. One of the following scenarios is present: Scenario 1: The following entries are logged individually or in combination, with P179E logged first (using DTC environmental data). In this scenario, if DTC P179E is not logged first, this TSB does not apply: DTC P179E (Drive position sensor electrical error) DTC P0700 with DFCC 20196 (Transmission control system malfunction) DTC P1758 with DFCC 8464 (Terminal 15 voltage supply open circuit) DTC P060A with DFCC 8126, 8345 (Internal control module monitoring processor performance) Page 1 of 6 © 2016 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Scenario 2: The following entries are logged individually or in combination. The order in which the DTCs are logged is not relevant: DTC P179E with DFCC 8050, 8051, 8052, 8053, 17595, 17596, 17597, 17598, 17602 (Drive position sensor electrical error) DTC P179F with DFCC 8054, 8055, 8056, 8057, 17599, 17600, 17601 (Drive position sensor malfunction) DTC P0716 with DFCC 8096, 8101, 18153, 20738 (Input turbine/speed sensor “A” circ. range/performance) DTC P171F with DFCC 8097, 8102, 18154 (Transmission input speed (RPM) sensor 2 implausible signal) DTC P0715 with DFCC 8094, 8103, 18161 (Input turbine/speed sensor “A” circuit.) DTC P2765 with DFCC 8095, 8104 (Input turbine/speed sensor “B” circuit) DTC P0501 with DFCC 8098 (Vehicle speed sensor “A” range/performance) DTC P2159 with DFCC 8099 (Vehicle speed sensor “B” range/performance) Tip: Fault codes and DFCC codes must match exactly for this TSB to apply. The DFCC is the 4-6 digit code that is typically listed before the fault code (Figure 1). Figure 1. DFCC 4-6 digit code listed before the fault code, underlined in red. Technical Background Incorrect driving mode sensor module. Page 2 of 6 © 2016 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Production Solution Not applicable. Service If the Condition matches exactly, replace the G676 sensor module with circuit board by following instructions in Elsa >> Repair manual >>Transmission >>S Tronic Transmission Internal Components >>35 Gears, Shafts >>Removal and Installation >> Sensor Module with Transmission Input Speed Sensor -G612-,-G632-, -G676- and Circuit Board 3. When replacing the sensor module, its wiring loom must also be replaced. Note: These instructions require transmission case disassembly. Audi Academy course #950224 is required before repair service can be attempted. Complete the course and the assessment #950224B before attempting repair or warranty claim may be denied. The course can be found on the Audi Academy CRC site. Tip: Use caution when lifting or lowering intermediate housing to avoid damage to components (Figure 2). Page 3 of 6 © 2016 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Figure 2. Caution points: drip tray and sensor module connector. Warranty Claim Type: 110 up to 48 Months/50,000 Miles. G10 for CPO Covered Vehicles – Verify Owner. If vehicle is outside any warranty, this Technical Service Bulletin is informational only. Service Number: 3512 Damage Code: 0040 Labor Operations: Remove and install gearbox 3435 19XX See Elsa Replaced sensor module G676 3512 1950 570 TU GFF to perform basic setting and adaptation after replacing sensor 0150 0000 Time stated on diagnostic protocol Diagnostic Time: (Max 100 TU) Road test prior to service procedure No allowance 0 TU Road test after service procedure 0121 0004 10 TU Technical diagnosis at dealer’s discretion (Refer to Section 2.2.1.2 and Audi Warranty Online for DADP allowance details) Claim Comment: As per TSB 2032211/5 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. Page 4 of 6 © 2016 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. Required Parts and Tools Part Number Part Description Quantity 0B5321371E Gasket for transmission pan 1 N10405702 Bolts for mechatronics unit 6 G052513A2 Front final drive oil (MTF) 5.0 Liters G052529A2 Dual clutch gearbox oil (ATF) 7.5 Liters 0B5927321L Module 1 0B5321391A Harness 1 AMV18800102 Sealing paste 1 0B5301515H Pump with seals 1 WHT001955 Bolt 1 WHT002459 Bolt 28 WHT001958B Bolt 2 0B5301227C Seal kit 1 0B5323525B O-ring 1 0B5311113F Seal 1 0B5315105TC Oil pipe with seals 1 0B5315105TA Oil pipe with seals 1 0B5325571 Sleeve with seals 1 0B5311944B Seal 4 0B5321473 Oil pipe 1 WHT005379 Seal 1 WHT003379 Seal 1 Page 5 of 6 © 2016 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher. 0B5301311E Oil drip tray (Replace if broken) 1 Additional Information All parts and service references provided in this TSB (2032211) are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information. ©2016 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites without the prior expressed written permission of the publisher. Page 6 of 6 © 2016 Audi of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.