LTB01148NAS2

6/4/2018
LTB01148NAS2 - Knocking Noise From The Rear Of The Vehicle | TOPIx
LT B 0 1 1 4 8 N A S 2
TECHNICAL BULLETIN
04 JUN 2018
© Jaguar Land Rover North America, LLC
NOTE: The information in Technical Bulletins is intended for use by trained, professional Technicians
with the knowledge, tools, and equipment required to do the job properly and safely. It informs these
Technicians of conditions that may occur on some vehicles, or provides information that could assist in
proper vehicle service. The procedures should not be performed by 'do-it-yourselfers'. If you are not a
Retailer, do not assume that a condition described affects your vehicle. Contact an authorized Land
Rover service facility to determine whether this bulletin applies to a specific vehicle.
I N F O R M AT I O N
This reissue replaces all previous versions. Please destroy all previous versions.
Changes are highlighted in blue
SECTION:
204-02: Rear suspension
S U B J E C T/ C O N C E R N :
Knocking Noise From The Rear Of The Vehicle
AFFECTED VEHICLE RANGE:
MODEL:
MODEL YEAR:
VIN:
https://topix.jaguar.jlrext.com/topix/content/document/view?id=900719
ASSEMBLY PLANT:
APPLICABILITY:
1/8
6/4/2018
LTB01148NAS2 - Knocking Noise From The Rear Of The Vehicle | TOPIx
MODEL:
Discovery (LR)
MODEL YEAR:
2017
VIN:
ASSEMBLY PLANT:
000532-042732
Solihull
APPLICABILITY:
Vehicles Without: Adaptive Damping
MARKETS:
NORTH AMERICA
CONDITION SUMMARY:
SITUATION:
A knocking noise may be evident from the rear of the vehicle.
CAUSE:
This may be caused by a cracked rear shock absorber top mount.
ACTION:
Should a customer express this concern, follow the appropriate Workshop Procedure below.
PA RTS :
PART NUMBER
DESCRIPTION
QUANTITY
LR095866
Mount
2
LR038196
Bolt
2
LR034277
Nut
2
LR034227
Nut
6
LR034276
Gasket
2
LR116654
Nut
2
TOOLS:
Refer to Workshop Manual for any required special tools.
https://topix.jaguar.jlrext.com/topix/content/document/view?id=900719
2/8
6/4/2018
LTB01148NAS2 - Knocking Noise From The Rear Of The Vehicle | TOPIx
WARRANT Y:
NOTES:
Repair procedures are under constant review, and therefore times are subject to change;
those quoted here must be taken as guidance only. Always refer to JLR claims submission
system to obtain the latest repair time.
The JLR Claims Submission System requires the use of causal part numbers. Labor only claims
must show the causal part number with a quantity of zero.
DESCRIPTION
SRO
TIME
(HOURS)
CONDITION
CODE
CAUSAL
PART
Top mount - Rear shock absorber - Without 7
seats - Pair
64.30.51
2.1
04
LR095866
Top mount - Rear shock absorber - With 7 seats Pair
64.30.51.50
1.7
04
LR095866
NOTE:
Normal Warranty procedures apply.
S E R V I C E I N F O R M AT I O N :
CAUTION:
Do not install a part that is not identified with a dot punch mark.
https://topix.jaguar.jlrext.com/topix/content/document/view?id=900719
3/8
6/4/2018
1
LTB01148NAS2 - Knocking Noise From The Rear Of The Vehicle | TOPIx

The new top mount should be identified with a 'dot' punch mark on the top plate.
W O R K S H O P P R O C E D U R E : V E H I C L E S W I T H : 7 S E AT S
1
Remove the rear left shock absorber (see TOPIx Workshop Manual section 204-02: Rear
suspension - Removal and installation - Rear shock absorber - Vehicles with: 7 seats steps 1-11
only).
https://topix.jaguar.jlrext.com/topix/content/document/view?id=900719
4/8
6/4/2018
2
LTB01148NAS2 - Knocking Noise From The Rear Of The Vehicle | TOPIx

Remove the rear left shock absorber top mount.
https://topix.jaguar.jlrext.com/topix/content/document/view?id=900719
5/8
6/4/2018
3
LTB01148NAS2 - Knocking Noise From The Rear Of The Vehicle | TOPIx

Install the new rear left shock absorber top mount.
Torque: 32 Nm
4
Install the rear left shock absorber (see TOPIx Workshop Manual section 204-02: Rear
suspension - Removal and installation - Rear shock absorber - Vehicles with: 7 seats steps 1-13
only).
5
Repeat steps 1-4 rear right shock absorber.
W O R K S H O P P R O C E D U R E : V E H I C L E S W I T H O U T : 7 S E AT S
1
Remove the rear left shock absorber (see TOPIx Workshop Manual section 204-02: Rear
suspension - Removal and installation - Rear shock absorber - Vehicles without: 7 seats - steps
1-18 only).
https://topix.jaguar.jlrext.com/topix/content/document/view?id=900719
6/8
6/4/2018
2
LTB01148NAS2 - Knocking Noise From The Rear Of The Vehicle | TOPIx

Remove the rear left shock absorber top mount.
https://topix.jaguar.jlrext.com/topix/content/document/view?id=900719
7/8
6/4/2018
3
LTB01148NAS2 - Knocking Noise From The Rear Of The Vehicle | TOPIx

Install the new rear left shock absorber top mount.
4
Install the rear left shock absorber (see TOPIx Workshop Manual section 204-02: Rear
suspension - Removal and installation - Rear shock absorber - Vehicles without: 7 seats - steps
3-24 only).
5
Repeat steps 1-4 rear right shock absorber.
https://topix.jaguar.jlrext.com/topix/content/document/view?id=900719
8/8