A0120812060491_1

01 MIL on, DTCs P030100, P030200, and/or P030300 are stored in the ECM
01 20 81 2060491/1 August 26, 2020.
Model(s)
Year
VIN Range
Vehicle-Specific Equipment
A8
2019
All
3.0 TFSI
Condition
Customer states:
 MIL on.
 The idle speed is erratic.
Workshop findings:
 For a single cylinder misfire DTC this bulletin does not apply, continue diagnosis outside of this TSB.
At least two of the following DTCs are stored in the engine control module (ECM), J623 (address word 0001) and
occur at the same time:
 DTC P030100 (cylinder 1 misfire).
And/or
 DTC P030200 (cylinder 2 misfire).
And/or
 DTC P030300 (cylinder 3 misfire).
Technical Background
With a fully loaded activated charcoal filter reservoir and high outside temperatures the discharge point of the fuel
vapor on bank 1 can cause multiple cylinders misfiring. This occurs only on bank 1 because of a too rich mixture.
Production Solution
New software in the ECM, J623 (address word 0001) addressed the condition.
Page 1 of 3
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.
Service
This TSB replaces Pending Service Solution (PSS) TSB 2054113: PSS 01 Bank 1 engine misfires - A8.
SVM Update Instructions
1. Follow all instructions in TSB 2011732: 00 Software Version Management (SVM), operating instructions.
2. Update the ECM, J623 (address word 0001) using the SVM action code as listed in the table below, if
necessary:
Model
Old Software
Part Number
Old
Software
Version
New Software
Part Number
New Software
Version
(or higher)
(or higher)
SVM Code
Input
0002
A8
4N0907559B
0003
0004
4N0907559B
0007
01A255
0005
Warranty
Claim Type:
 110 up to 48 Months/50,000 Miles.
 1E1 up to 8 Years/80,000 Miles.
 G10 for CPO Covered Vehicles – Verify Owner.
 If the vehicle is outside any warranty, this Technical Service Bulletin is informational
only.
Service Number:
2470
Damage Code:
0039
Labor Operations:
Software Update (Includes checking for DTCs)
0151 0000
Time stated on
the diagnostic
protocol (Max
60 TU)
Diagnostic Time:
GFF
No allowance
0 TU
Road test prior to the service procedure
No allowance
0 TU
Road test after the service procedure
0121 0004
10 TU
Claim Comment:
As per TSB #2060491/1
Page 2 of 3
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.
All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures
Manual. Claims are subject to review or audit by Audi Warranty.
Additional Information
The following Technical Service Bulletin(s) will be necessary to complete this procedure:
 TSB 2011732, 00 Software Version Management (SVM), operating instructions.
All part and service references provided in this TSB (2060491) are subject to change and/or removal. Always
check with your Parts Department and/or ETKA for the latest information and parts bulletins. Please check the
Repair Manual for fasteners, bolts, nuts, and screws that require replacement during the repair.
©2020 Audi of America, Inc. All rights reserved. The information contained in this document is based on the
latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes
at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or
transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites without the prior expressed written permission of the
publisher.
Page 3 of 3
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.