TSB005722

T-SB-0057-22
June 28, 2022
SRS MIL ON - Qi Charger Interference
Service
Category
Section
Vehicle Interior
Supplemental Restraint
Systems
Market USA and Mexico
Applicability
YEAR(S)
MODEL(S)
2022
Tundra, Tundra HV
ADDITIONAL INFORMATION
Introduction
Some 2022 model year Tundra and Tundra Hybrid vehicles equipped with the wireless Qi
cellphone charger may experience an SRS light ON with one or more of the following Diagnostic
Trouble Codes (DTCs):

B002011 – Left Side Airbag Deployment Control Circuit Short to Ground

B002012 – Left Side Airbag Deployment Control Circuit Short to Battery

B002811 – Right Side Airbag Deployment Control Circuit Short to Ground

B002812 – Right Side Airbag Deployment Control Circuit Short to Battery

B007011 – Driver Seat Belt Pretensioner “A” Deployment Control Circuit Short to Ground

B007012 – Driver Seat Belt Pretensioner “A” Deployment Control Circuit Short to Battery

B007212 – Passenger Seat Belt Pretensioner “A” Deployment Control Circuit Short to Battery

B007311 – Second Row Left Seat Belt Pretensioner Deployment Control Circuit Short to Ground

B007312 – Second Row Left Seat Belt Pretensioner Deployment Control Circuit Short to Battery

B007512 – Second Row Right Seat Belt Pretensioner Deployment Control Circuit Short to Battery
While the wireless Qi cellphone charger may create an SRS light ON and may generate DTCs, the
DTCs will not affect the airbag and pretensioner performance. A software update for the SRS ECU
is now available to update the software. Follow the Repair Procedure in this bulletin to address
this condition.
© 2022 Toyota Motor Sales, USA
Page 1 of 5
T-SB-0057-22
June 28, 2022
Page 2 of 5
SRS MIL ON - Qi Charger Interference
Warranty Information
For USA Market
OP CODE
DESCRIPTION
TIME
OFP
T1
T2
EL9070
SRS ECU Reprogramming
0.7
89170-#####*
8B
74
*Warranty claim MUST be submitted with the correct 10-digit OFP. Choose the correct OFP for the vehicle being repaired
by searching for the parts in the Electronic Parts Catalog using the VIN filter.
APPLICABLE WARRANTY (USA)
 This repair is covered under the Toyota Powertrain and Restraint Systems Warranty.
This warranty is in effect for 60 months or 60,000 miles, whichever occurs first, from the
vehicle’s in-service date.
 Warranty application is limited to occurrence of the specified condition described in
this bulletin.
For Mexico Market
OP CODE
DESCRIPTION
TIME
OFP
T1
T2
EL9070
SRS ECU Reprogramming
0.7
89170-#####*
8B
74
*Warranty claim MUST be submitted with the correct 10-digit OFP. Choose the correct OFP for the vehicle being repaired
by searching for the parts in the Electronic Parts Catalog using the VIN filter.
APPLICABLE WARRANTY (MEXICO)
 This repair is covered under the Toyota Basic Warranty. This warranty is in effect for 36 months
or 60,000 kilometers, whichever occurs first, from the vehicle’s in-service date.
 Warranty application is limited to occurrence of the specified condition described in
this bulletin.
© 2022 Toyota Motor Sales, USA
T-SB-0057-22
June 28, 2022
Page 3 of 5
SRS MIL ON - Qi Charger Interference
Required Tools & Equipment
SPECIAL SERVICE TOOLS (SST)
PART NUMBER
QTY
Battery Diagnostic Tool*
DCA-8000P T
1
*Essential SST.
NOTE
Additional SSTs may be ordered by calling 1-800-933-8335 (USA) or 01-800-504-5330 (Mexico).
REQUIRED EQUIPMENT
SUPPLIER
PART NUMBER
Techstream ADVI*
QTY
TSADVUNIT
Techstream 2.0
TS2UNIT
ADE
1
Techstream Lite
TSLITEPDLR01
Techstream Lite (Green Cable)
TSLP2DLR01
*Essential SST.
NOTE
 Only ONE of the Techstream units listed above is required.
 Software version 17.10.012 or later is required.
 Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE)
at 1-800-368-6787 (USA) or 01-55-50103041 (Mexico).
 .
Calibration Information
CALIBRATION ID
MODEL
ENGINE
CAB CONFIGURATION
PREVIOUS
NEW
D-Cab
8917F0C14100/
8917H0C01100
8917F0C14200/
8917H0C01200
C-Max
8917F0C15100/
8917H0C02100
8917F0C15200/
8917H0C02200
C-Max/D-Cab
8917F0C17100/
8917H0C03100
8917F0C17200/
8917H0C03200
Tundra
V35AFTS
Tundra HV
© 2022 Toyota Motor Sales, USA
T-SB-0057-22
June 28, 2022
Page 4 of 5
SRS MIL ON - Qi Charger Interference
Repair Procedure
1. Confirm the condition exists.
A. Using Techstream, check for the following stored DTCs:
 B002011 – Left Side Airbag Deployment Control Circuit Short to Ground
 B002012 – Left Side Airbag Deployment Control Circuit Short to Battery
 B002811 – Right Side Airbag Deployment Control Circuit Short to Ground
 B002812 – Right Side Airbag Deployment Control Circuit Short to Battery
 B007011 – Driver Seat Belt Pretensioner “A” Deployment Control Circuit Short
to Ground
 B007012 – Driver Seat Belt Pretensioner “A” Deployment Control Circuit Short
to Battery
 B007212 – Passenger Seat Belt Pretensioner “A” Deployment Control Circuit Short
to Battery
 B007311 – Second Row Left Seat Belt Pretensioner Deployment Control Circuit Short
to Ground
 B007312 – Second Row Left Seat Belt Pretensioner Deployment Control Circuit Short
to Battery
 B007512 – Second Row Right Seat Belt Pretensioner Deployment Control Circuit
Short to Battery
B. Are ANY of the DTCs listed above present?
 YES — Continue to step 2.
 NO — This bulletin does NOT apply. Continue diagnosis using the applicable
Repair Manual.
2. Is this vehicle equipped with a wireless Qi cellphone charger?

YES — Continue to step 3.

NO — This bulletin does NOT apply. Continue diagnosis using the applicable
Repair Manual.
© 2022 Toyota Motor Sales, USA
T-SB-0057-22
June 28, 2022
Page 5 of 5
SRS MIL ON - Qi Charger Interference
Repair Procedure (continued)
3. Is the calibration ID of the SRS airbag ECU 8917F0C14100, 8917F0C15100,
or 8917F0C17100?

YES — Continue to step 4.

NO — This bulletin does NOT apply. Continue diagnosis using the applicable
Repair Manual.
4. Follow the procedures outlined in T-SB-0107-20, ECU Flash Reprogramming With Security
Signature, and flash the SRS airbag ECU with the NEW calibration file update.
NOTE
 The battery diagnostic tool MUST be used in Power Supply Mode to maintain battery voltage at
13.5V while flash reprogramming the vehicle.
 For details on how to use the battery diagnostic tool, refer to the DCA-8000 Instruction Manual
located at TIS – Diagnostics – Tools & Equipment – Battery Diagnostics.
5. Using Techstream, perform a Health Check to confirm the NEW calibration
updated successfully.
6. Clear DTCs and confirm the condition is no longer present.
© 2022 Toyota Motor Sales, USA