Ford Expedition-4x4 2003

• Recall 83220 [USA]: Decreased lighting visibility may result in a vehicle crash.
  Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
  sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.
  this recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.In order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.The list can be found under "document search" located at the bottom of your screen.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 38066 [USA]: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
  Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
  tradesonic will notify owners and replace the lamps free of charge. The recall is expected to begin during july 2006. Owners may contact tradesonic at 626-934-8884.
  this recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.For more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 60824 [USA]: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
  Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
  pro-a motors will notify owners and offer to repurchase the lamps. The recall began on april 3, 2006. Owners may contact pro-a motors at 323-838-2988.
  this recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.For more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 61821 [USA]: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
  Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. Some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
  anzo will notify owners and replace the headlamps free of charge. The recall began may 9, 2006. Owners may contact anzo usa at 909-468-3688.
  this recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 64413 [USA]: This overheating condition can cause the running board to melt or cause a fire.
  Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
  dealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
  customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Spark plug ejection from cylinder head investigation # DP05005

  On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.Odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.As of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.In addition, odi is aware of only two incidents where the vehicle stalled without restart.Information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.In the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.In one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.In another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.None of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.As the petitioner noted, and odi¿s analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles.However, odi¿s analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences.None of these showed any evidence of a serious safety consequence.Given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low.In view of the foregoing, it is unlikely that nhtsa would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition.Therefore, in view of the need to allocate and prioritize nhtsa¿s limited resources to best accomplish the agency¿s safety mission, the petition is denied.
  

  Show Content

This suv stalled on the highway while driving in traffic. It was caused by a fault in the fuel pump or fuel pump relay. Please recall this vehicle.

This suv stalled on the highway while driving in traffic. It was caused by a fault in the fuel pump or fuel pump relay. Please recall this vehicle.

Loss of headlights when using auto control, since this is an 03' i believe headlight control unit is bad as this same unit was recalled on my 03' crown victoria

Loss of headlights when using auto control, since this is an 03' i believe headlight control unit is bad as this same unit was recalled on my 03' crown victoria

Fuel tank vapor recovery unit developed a crack due to manufacturing defects in plastic weld, permitting gasoline vapor and gasoline fuel to escape from the fuel tank in an uncontrolled and unsafe way. The problem manifested as a fuel vapor leak when the vehicle was parked on a 0-degree surface (level surface) and as a continuous fuel drip when the vehicle was parked on a 10-degree downslope, with the front of the vehicle pointed down-hill.

Fuel tank vapor recovery unit developed a crack due to manufacturing defects in plastic weld, permitting gasoline vapor and gasoline fuel to escape from the fuel tank in an uncontrolled and unsafe way. The problem manifested as a fuel vapor leak when the vehicle was parked on a 0-degree surface (level surface) and as a continuous fuel drip when the vehicle was parked on a 10-degree downslope, with the front of the vehicle pointed down-hill.

My fuse and relay panel has a defect and now my truck won't start. *tr

My fuse and relay panel has a defect and now my truck won't start. *tr

Was driving car had at least 80 miles when car cut off at light in would not come back on so i had replaced fuel pump only to find out my fuse box isn't reading my fuel relays from the burning relays replaced. *tr

Common OBD-II Error Codes

• C1983 [2] C1983
• C1991 [3] C1991
• P0300 [1] Random/Multiple Cylinder Misfire Detected
• P0308 [1] Cylinder 8 Misfire Detected
• P0316 [1] Misfire Detected On Startup (First 1000 Revolutions)
• P0620 [2] Generator Control Circuit Malfunction
• P0320 [3] Ignition/Distributor Engine Speed Input Circuit Malfunction
• C1724 [1] Air Suspension Height Sensor Power Circuit Failure
• C1873 [1] Air Suspension RF Air Spring Solenoid Output Circuit Failure
• C1889 [1] Air Suspension LF Height Sensor Circuit Failure
• C1998 [3] C1998
• C1277 [2] STEERING Wheel Angle 1and 2 Circuit Failure
• C1278 [2] STEERING Wheel Angle 1and 2 Signal Faulted
• C1790 [1] Air Suspension LR Air Spring/Shock Solenoid Output Circuit Failure
• C1990 [1] C1990
• P0442 [1] Evaporative Emission Control System Leak Detected (small leak)
• P0455 [1] Evaporative Emission Control System Leak Detected (gross leak)
• P0456 [1] Evaporative Emissions System Small Leak Detected
• P0457 [1] Evaporative Emission Control System Leak Detected
• P1442 [1] A/C Evaporator Air Temperature Circuit Range/Performance
• P0231 [2] Fuel Pump Secondary Circuit Low
• P0232 [1] Fuel Pump Secondary Circuit High
• C2777 [1] C2777
• C2778 [1] C2778
• C1440 [1] Pressure Transducer Main / Primary signal Faulted
• P0304 [1] Cylinder 4 Misfire Detected
• B1676 [1] Battery Pack Voltage Out Of Range
• P2503 [1] Charging System Voltage Low