Mci J4500 2011

• Recall 199827 [USA]: In the event that a mobility device pushes into the outer barrier, the barrier may fail, increasing the risk of injury for the lift occupant.
  Motor coach industries (mci) is recalling certain 2005-2009 e4500 and 2005-2012 j4500 motorcoaches equipped with ricon baylift wheelchair lifts. When the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 403, "platform lift systems," and number 404, "platform lift installations."
  ricon will reinforce the outer barrier with additional supports, free of charge. Owner notification letters were mailed on october 18, 2021. Owners may contact the ricon's customer service at (800) 322-2884, or email ricon?S recall coordinator, at [email protected] or by locating the nearest ricon servicing dealer using the locator on the ricon website ? Www.Riconcorp.Com. Owners may also contact mci's customer service at 1-800-241-2947. Mci's number for this recall is r21-024.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.

  Show Content

• Recall 138531 [USA]: Loss of steering control may increase the risk of a crash.
  Motor coach industries (mci) is recalling certain 2001-2015 j4500 and 1997-2013 102el3/e4500 coaches equipped with a hydraulic rear axle (tag axle) steering system. The axle's alignment and low hydraulic pressure in the steering system may cause the steering system to lock, causing a loss of steering control at highway speeds.
  mci will inspect and repair axle alignment, as necessary, free of charge. Mci issued owners an interim notification on march 26, 2019. Owner notification letters were mailed on may 14, 2021. Owners may contact mci customer service at 1-800-241-2947. Mci's number for this recall is sb 469.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 111289 [USA]: If the seatbelt anchorage assembly separates from the j-bracket, the bus driver may not be properly restrained in the event of a crash increasing their risk of injury.
  Motor coach industries (mci) is recalling certain model year 2011-2013 and 2015 j4500 coaches manufactured november 18, 2011, to july 10, 2015, 2011-2012 and 2014-2015 d4000 coaches manufactured manufactured september 24, 2010, to september 5, 2015, 2011-2013 and 2015-2016 d4005 coaches manufactured january 17, 2011, to november 23, 2015, 2012-2014 and 2016 d4000istv coaches manufactured july 18, 2012, to december 2, 2015, 2010-2016 d4500 coaches manufactured april 15, 2010, to december 18, 2015 and 2011-2016 d4505 coaches manufactured december 15, 2010, to december 4, 2015. The affected buses are equipped with certain recaro ergo-m commercial bus driver seats that have j-brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the j-bracket.
  mci will notify owners and dealers will inspect the seats and determined if welds are missing. Any j-bracket that is missing welds will be removed and replaced, free of charge. The recall began on february 15, 2016. Owners may contact mci at 1-800-241-2947. Mci's number for this recall is sb 431.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 103020 [USA]: In the event of a crash, the seat may detach from its floor mounting, increasing the risk of injury to the occupant.
  Motor coach industries (mci) is recalling certain model year 2009-2014 e4500 and j4500 motorcoaches manufactured october 2008 through october 2013, and equipped with passenger seats with 3-point seat belts. The seat track for the second row passenger seats may be missing a weld at the end of the seat track where it enters the frame structure.
  mci will notify owners, and dealers will modify the seat anchorage, free of charge. The recall began on may 9, 2014. Owners may contact mci at 1-800-241-2947. Mci's number for this recall is 408.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 100276 [USA]: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
  Motor coach industries (mci) is recalling certain model year 2000-2012 d, e, g and j series coaches manufactured january 2000 through june 2011 and equipped with sure power battery equalizers containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
  mci will notify owners, and sure power will replace the equalizers, free of charge. Owners may contact mci at 1-847-285-2000. This campaign is mci service bulletin 401.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 92961 [USA]: A transom window may detach without warning, increasing the risk of personal injury or property damage.
  Motor coach industries, inc (mci) is recalling certain model year 2009-2012 j motor coaches. Due to inadequate bonding, the transom windows (the rear-most windows on each side), may detach from the coach.
  mci will notify owners, and dealers will install mechanical retention clips on the transom windows, free of charge. The safety recall began on june 5, 2012. Owners may contact mci at 1-800-241-2947.
  mci?S recall campaign number is 369.Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 94300 [USA]: If the driver is slow to react during this esc intervention, the vehicle may deviate from the intended line of travel, increasing the risk of a crash.
  Motor coach industries (mci) is recalling certain model year 2003, and 2007-2012 e and j models along with model year 2007-2012 d4000, d4005, d4500, d4505, d4000istv motor coaches equipped with meritor wabco electronic stability control (esc) modules, manufactured from october 2002, through october 2011. Under certain road and driving conditions, vehicle body roll and road inclination characteristics may adversely affect the slip angle calculation of the electronic stability control (esc) system. This might cause the esc to perceive an over steering situation and therefore apply the outer wheel brake on the front axle until the vehicle is perceived to be stable.
  mci will notify owners and replace the control module free of charge. The safety recall began on january 4, 2012. Owners may contact mci customer service at 1-800-241-2947.
  mci safety recall number is 371.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 70924 [USA]: If the inlet or outlet sections disconnect, hot exhaust gases can vent prior to exiting the tailpipe, creating the risk of combustion and a fire. if both clamps fail, there is a risk in some applications that the doc/dpf housing may detach completely, creating a road hazard.
  Motor coach industries, inc. (mci) is recalling certain model year 2011 e4500 and j4500 motor coaches manufactured from december 2010 through january 2011, equipped with a cummins isx 11.9 diesel engine. The v-band clamp assembly, part numbers q187684, q187685, and q187686, used to connect the inlet and outlet cone sections to the diesel oxidation catalyst (doc)/diesel particulate filter (dpf) include a t-bolt which can fracture and fail when subjected to stress or load. A fracture or failure of the t-bolt may cause the clamp to loosen and the inlet or outlet sections attached to the doc/dpf housing to disconnect.
  mci will notify owners, and repairs will be performed by authorized cummins dealers free of charge. The safety recall began on september 19, 2011. Owners may contact mci at 1-800-241-2947 or cummins at 1-812-377-5000 for more information.
  mci's recall campaign number is 364.Cummins' recall campaign number is C1154. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 64951 [USA]: The driver's visibility may be reduced, which in turn could result in a crash or otherwise cause personal injury or property damage.
  Mci is recalling certain model year 2011 mci e4500, and j4500, motor coaches manufactured from september 2010 through july 2011, equipped with a doga windshield wiper motor. An underrated fuse may have been installed at the factory, which could blow, resulting in the windshield wipers not operating.
  dealers will inspect the fuse and replace any underrated fuses that may have been installed. This service will be performed free of charge. The safety recall began on august 3, 2011. Owners may contact mci customer service at 1-800-241-2947.
  mci's safety recall number is 362.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 66287 [USA]: Reduced joint strength of the spindle of the axle could result in a vehicle crash.
  Mci is recalling certain model year 2011 mci j4500 motor coaches manufactured from december 1, 2010 through february 28, 2011, and equipped with arvinmeritor mc16 and mc16 type tag axle assemblies. The bolts used to connect the axle housing to the spindle of the axle may not have been properly heat treated, resulting in potentially compromised hardness and strength that, in turn, could lead to reduced joint integrity.
  arvinmeritor is working with mci to identify and notify owners and repairs will be performed free of charge. The safety recall began on april 14, 2011. Owners may contact arvinmeritor at 1-248-435-1725 or mci customer service at 1-800-241-2947.
  mci safety recall no. 358.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 68426 [USA]: The driver's field of view may be reduced, which in turn could result in a crash or otherwise cause personal injury or property damage.
  Mci is recalling certain model year 2011 mci j4500, e4500, and j4500c motor coaches manufactured from may 1, 2010 through january 31, 2011, and equipped with doga windshield wipers. Certain wires may have been incorrectly installed by mci at the factory which could result in the windshield wipers failing to operate.
  dealers will inspect the windshield wipers and connect any wires that were improperly installed. This service will be performed free of charge. The safety recall began on march 14, 2011. Owners may contact mci customer service at 1-800-241-2947.
  mci safety recall no. 356.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 69011 [USA]: If the windshield wipers stop functioning, the driver's clear field of view may be reduced increasing the risk of a crash.
  Mci is recalling certain model year 1999-2001, 2007-2011 e4500 and model year 2001-2011 j4500 coaches equipped with doga windshield motors. The windshield wiper motor may fail to operate properly while the wiper system is functioning. If this occurs, the windshield wipers may operate intermittently, operate at a single speed only, or completely stop operating.
  dealers will furnish the parts and labor required to implement the doga-recommended remedies on the affected coaches. This service will be performed free of charge. The safety recall is expected to begin during july 2010. Owners may contact mci customer service at 1-800-241-2947.
  mci recall no. 344.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 2019006 [Canada]: Steering
  Issue: certain buses built with a rear tag-axle steering system may exhibit a steering lock-up at highway speed. Safety risk: this problem could cause a sudden loss of steering control that could create the risk of a crash. Corrective action: a final repair has not yet been determined. The cause of this problem is under investigation. In the interim, the company will notify owners by mail and advise them to immediately verify that the rear tag-axle caster adjustment is within specification.

  Show Content

• Recall 2012111 [Canada]: Visual system
  On certain coaches, the transom windows (the rear-most side glass panels) may have been inadequately bonded during the vehicle assembly process and, as a result, could detach from the vehicle. A window separating from the vehicle could strike another vehicle, a stationary object, or a bystander, causing property damage and/or personal injury. Correction: authorized service facilities will install mechanical retention clips to the transom windows.

  Show Content

• Recall 2011377 [Canada]: Other
  On certain vehicles, specific operating conditions (such as tight, successive, highly banked curves in opposite directions), could trigger unintended electronic stability control (esc) system intervention. As a result, the esc may unnecessarily apply one of the front brakes in order to correct the perceived oversteer condition. This may cause the vehicle to deviate from the intended path, thereby increasing the risk of a crash causing property damage and/or personal injury. Correction: dealers will replace the esc module.

  Show Content

• Recall 2011275 [Canada]: Visual system
  On certain coaches, an incorrect fuse (15 amp) may have been installed, during vehicle assembly, in the inline fuse holder for the windshield wiper motor. This could allow the wiper motor fuse to open under a heavy load created by other accessories connected to the electrical stud block. Loss of windshield wiping capability, should it occur during a rainy/snowy day, may compromise the driver's ability to see the road and its users, which could result in a crash causing property damage and/or personal injury. Correction: dealers will replace the 15 amp fuse with a 30 amp fuse.

  Show Content

• Recall 2011094 [Canada]: Electrical
  On certain coaches, the wiper motor may have been incorrectly installed during vehicle assembly. The wiper motor may have been connected to a circuit protected by a 7.5a fuse instead of one with a 30a fuse. Under a heavy load such as high winds, heavy rain, snow, or a dry windshield, the wipers may fail. Loss of windshield wiping capability, should it occur during a rainy/snowy day, may compromise the driver's ability to see the road and its users, which could result in a crash causing property damage and/or personal injury. Correction: dealers will inspect and, if necessary, rework the incorrectly installed wiring.

  Show Content

• Recall 2010097 [Canada]: Electrical
  Certain vehicles were equipped with a doga brand windshield wiper motor that may fail to operate properly while the wiper system is functioning. The windshield wipers may operate intermittently, operate at a single speed, or stop completely. A faulty windshield wiper motor may reduce the driver's visibility and increases the risk of a crash causing property damage, personal injury or death. Correction: dealers will replace the wiper motor assembly.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.