Prevost Xlii-45 2002
Vehicle Details: Recalls, Investigations, Service Bulletins
Below you will find all available information on the 2002 PREVOST Xlii-45.
| Manufacturer | Known WMI(s) | Fuel Type |
|---|---|---|
| PREVOST |
Use the box here to look up VINs from PREVOST as well as other manufacturers
Sub-models: - Xlii-45 Coaches - Xlii-45 Entertainer -
-
Are there recalls for the 2002 PREVOST Xlii-45?
- There are 4 recall(s) for the 2002 PREVOST Xlii-45, additional information is below.
Recall 138432 [USA]: A complete loss of steering would increase the risk of a crash.
Recall 55849 [USA]: Loss of steering control can cause a vehicle crash without prior notice.
Recall 64331 [USA]: in such a case, a loss of steering would occur.
Recall 3593 [USA]: If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash.
To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.
Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.
- IS-23019 - SUSPENSION: Sway bar collars improvement
- IS-21072B - ELECTRICAL SYSTEM: Steering gateway. Revision b - pin 2 and 10 were inverted on connector a139
- MI22-12B - SERVICE BRAKES, AIR: Air tanks draining sequence. Revision: b - general update
- MI22-12A - SERVICE BRAKES, AIR: Air tanks draining sequence. Revision: a - erroneous secondary & accessory tanks location.
- MI22-12 - SERVICE BRAKES, AIR: Air tanks draining sequence
- IS20-925A - VISIBILITY: Central hvac merv filters installation
- MI20-08C - STRUCTURE: Storage and startup guidelines: periodically, circumstances arise requiring operators to temporarily park a coach in storage. Whether it is a few weeks or several months, sporadic out of service times or a full stop, prevost recommends foll
- IS-18091A - STEERING: Tie rod 610052 first installation instructions: use these instructions when replacing the drop joint tie rod on s82, s84 / s84u i-beam axles. The new tie rod will be adjusted to the length of the original; however, a steering alignment ne
- MI20-19A - EQUIPMENT: Rev a: mention added concerning ddc series 60 engine sca requirement
- MI20-19 - ENGINE AND ENGINE COOLING: Introducing a new engine coolant into service
- MI02-17A - WHEELS: Revision : a torque value reduced
- IS-03103A - EQUIPMENT: Keyless entry system new hand held transmitter and receiver module revision a: added link to programming instructions
- MI20-08B - EQUIPMENT: Storage and startup guidelines revision: b parts added to suggested material 08-10-2020
- MI20-12 - STEERING: Jerky, noisy or hard to turn steering gearbox. Hydraulic end limiter adjustment. All models ⿿ equipped with rb bosch/zf servocom or servocomtronic steering gearbox
- MI20-08A - EQUIPMENT: Storage and startup guidelines: rev a: 21516229 replaced by 23381562 20523393 replaced by 21454749 800383 removed 611471 replaced by 611360 70376808 replaced by 21036050 21396642 replaced by 20967831
- MI20-09 - EQUIPMENT:OTHER:LABELS: Prevost vehicle disinfection procedure
- MI20-08 - UNKNOWN OR OTHER: Storage and startup guidelines - all prevost vehicles & volvo 9700
- MI15-24 - ELECTRICAL SYSTEM: Added: power cables for l.H. Side alternator & fan drive breaker box
- IS-19923A - EQUIPMENT:ELECTRICAL: Revision : addition of wiring schematics at the end of this document
- IS-04106B - ENGINE AND ENGINE COOLING: This instruction sheet explains how to replace clutch and radiator fan transfer mechanism mounting base
- IS-19923 - ELECTRICAL SYSTEM: This instruction sheet explains how to replace hvac module on certain vehicles;
- IS-17910A - EQUIPMENT: Message center display (mcd) replacement
- SCI11-23 - STRUCTURE:BODY: Prevost: stainless steel side panel unstick repair solution. *kb
- SCI09-28 - SEAT BELTS: Prevost: installing three-point passenger seat restraint system. The purpose of the following procedure is to facilitate the job and to help identify the difficult areas. Also included models he-41 and he-45 coaches model years 1998-2008; m
- MI07-04 - SUSPENSION:FRONT:WHEEL BEARING: Prevost: oil lubricated wheel hub bearings. For maximum performances and safety, ensuring that the wheel hubs are inspected daily and lubricated in regular intervals is of the utmost importance. *js
- 0410 - STEERING: Inspection & replacement of power steering pressure hose. Prevost. *tt
- 0303 - PARKING BRAKE: Replacement of parking brake pressure switch. This includes 2003 models as well. *tt
Power steering hose leakage investigation # PE05012
This investigation was opened as the result of odisreview of prevost service bulletin, wb04-10,issued in december 2004 and titled "inspection and replacement of power steering pressure hose.The bulletin addressed the possibility that power steering assist could be lost due to a power steering pressure hose failure.The bulletin instructed the dealer to inspect, replace, and repositioned the hoses throughout the vehicle.As a result of odis investigation, prevost has agreed to conducta safety recall to inspect the power steering hoses for signs of abrading and to replace certain power steering hoses on the subject vehicles.A copy of the safety recall is attached.This action resolves the issues raised by this investigation. Accordingly, this investigation is closed.