Saab 9-3 2001

• Recall 50224 [USA]: Over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. if an ignition source were present, the fuel may ignite resulting in a vehicle fire.
  On certain passenger vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production.
  dealers will develop a securing bracket that will secure the fuel lines to the fuel pump even if the plastic retaining tabs should break. The recall began on may 12, 2006. Owners may contact saab at 1-800-955-9007.
  saab recall no. 06033.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 61993 [USA]: Overheating of the igbt occurs most often at engine start-up, but it may also occur while the engine is running. engine stalling may occur, which could result in a crash.
  Certain passenger vehicles equipped with b205/b235 4-cylinder gasoline engines and b308 6-cylinder gasoline engines may experience overheating and burnout of the isolated gated bipolar transistor (igbt) within the ignition discharge module (idm) due to increased susceptibility to electrical loads.
  dealers will inspect to see what version idm is in the vehicle and replace the idm if it is a version built prior to the introduction of qp3. An interim letter will be mailed to owners in october 2005, informing them of the condition. Parts are now available and owners will be notified to bring their vehicles in to the dealers to have the idm replaced by letter dated march 13, 2006. Owners may contact saab at 1-800-955-9007.
  saab recall no. 05087.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 55887 [USA]: Over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. if an ignition source were present, the fuel may ignite resulting in a vehicle fire.
  On certain passenger vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production.
  dealers will develop a securing bracket that will secure the fuel lines to the fuel pump even if the plastic retaining tabs should break. The recall began on march 14, 2005. Owners should contact saab at 1-800-955-9007.
  saab recall no. 15018 (gm recall no. 04101).Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 3460 [USA]: These vehicles do not comply with the requirements.
  Vehicle description: certain passenger vehicles fail to comply with requirements of fmvss no. 208, "occupant crash protection." the air bag alert labels may not be permanently affixed as required by this standard.
  dealers will clean the sunvisor surface and apply a new air bag alert label on both sunvisors. Owner notification began july 30, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saab at 1-800-955-9007.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall R/2005/021 [UK]: Fuel pump mounted pipe retaining tabs may fail
  The fuel pipe plastic retaining tabs mounted on the fuel pump may fail and possibly result in a fuel leak.
  recall the vehicles that are likely to be affected and install a new securing bracket made of steel to hold the fuel pipes in place.

  Show Content

• Recall 2006095 [Canada]: Fuel supply
  On certain saab 9-3 convertible and 9-3 viggen vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production. Over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. If an ignition source were present, the fuel may ignite resulting in a vehicle fire. Correction: dealers will install a bracket that will secure the fuel lines to the fuel pump even if the plastic retaining tabs should break.

  Show Content

• Recall 2005271 [Canada]: Electrical
  Certain 2000-2002 saab 9-3 and 9-5 model vehicles equipped with 4-cylinder gasoline engines, and 2001-2003 9-5 models equipped with 6-cylinder gasoline engines may experience overheating and burnout of the isolated gated bipolar transistor (igbt) within the ignition discharge module (idm) due to increased susceptibility to electrical loads. Overheating of the igbt occurs most often at engine start-up but may also occur while the engine is running. When the idm fails on a 4-cylinder while it is running, the engine may stall without warning, with no ability to be restarted. When the idm fails on a 6-cylinder engine while it is running, the driver will initially experience reduced power and rough operation because the engine will only be running on three cylinders. The check engine light will flash. If the driver continues, unburnt fuel in the exhaust can cause thermal damage to the catalytic converter. The engine may stall and not restart. Correction: dealers will inspect and, if required, replace the idm.

  Show Content

• Recall 2004427 [Canada]: Fuel supply
  On certain saab 9-3 convertible and 9-3 viggen vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production. Over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. If an ignition source were present, the fuel may ignite resulting in a vehicle fire. Correction: dealers will install a bracket that will secure the fuel lines to the fuel pump even if the plastic retaining tabs should break.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Fuel line leakage investigation # RQ05003

  There is no summary currently available
  

  Show Content

• Engine stall/ engine compartment fires investigation # PE05017

  There is no summary currently available
  

  Show Content

I left my home with my daughter in the afternoon to go to the bank and hardware store. I drove to the bank to make a deposit. We had to wait for quite awhile in the drive-through line at the bank, so i turned off my engine a couple of times rather than having the car idle. After making the deposit at the bank, i pulled out of the bank lot and began driving to the hardware store. I had driven for about two minutes and was driving along at approximately 25-30 miles an hour, and suddenly there was a terrible explosion at my left ear and massive pain in my left arm. I thought the car had been shot at and my arm hit. I was terrified we were still being shot at and looked at my daughter whose hands were over her ears. I could tell by that time that i was not bleeding and so was worried that the bullet had hit her. I could hear only faintly out of my left ear. There was smoke and the smell of an explosion. I could see by this time that an airbag had come out of my driver's seat and thought that it had been hit too. My daughter told me she was o.K. And to pull the car over so that we could see what had happened. I was shaking with fear and pain in my arm but finally calmed down enough to park the car and get out to see what had happened. It became clear that the car had not been shot at and that the driver's side seat airbag had simply spontaneously exploded without any warning whatsoever. The driver's seat side seam was completely ripped, multiple pieces of seat foam were lying about, and the air bag in the seat was out and ripped. The seat was still smoking. Luckily i had had my window completely down, or the explosion would have been louder in the car, and my arm and left side could have been more badly injured. I called my longtime saab repairman who told me that what happened to me was extremely rare. He said i would need a new seat and that the computer system would need to be reset for the airbag system to work again. Insurance will examine soon. I may try gm too.

No incident

No incident

Excessive leaking. Was driving on e-way and engine stopped or something occured where it sounded as if the car turned off. The battery was working but, when i pressed on accelerator it didn't propel forward. I carefully steered with hazard lights to side of the road. Ignition cranks but, car won't turn over. Replaced direct ignition coil, crankshaft sensor but, issue seems to be the fuel pump. A recall was issued regarding this: recall 06v126000 affected cars saab 9-3 2001 engine, may 12, 2006 original recall from the nhtsa manufacturer's report date may 12, 2006 nhtsa action number rq05003 potential number of units affected 11,886 nhtsa campaign id number 06v126000 component fuel system, gasoline:delivery:hoses, lines/piping, and fittings summary on certain passenger vehicles, the fuel pump retaining tabs holding the fuel lines were damaged during production. Consequence over time, this could cause the fuel lines to loosen from the pump resulting in fuel leakage. If an ignition source were present, the fuel may ignite resulting in a vehicle fire.

When i changed the battery of the car key, its doors and trunk stopped lock and unlock. The belt of the gas tank was broken also. I replaced also the fuel tank.

Tl* the contact owns a 2001 saab 9-3. The contact stated that the vehicle failed to start while the battery warning indicator was illuminated. In addition, the vehicle would stall. The vehicle was taken to an independent mechanic where it was diagnosed that the ignition discharge module failed and needed to be replaced. The vehicle was not repaired. The vin was not included in nhtsa campaign number: 05v399000 (electrical system). The manufacturer was not notified of the failure. The failure mileage was approximately 186,000.

Had the engine light on for three months then i was driving on the highway yesterday and suddenly the engine wouldn't take gas. I was able to pull over off the highway slowly and it stopped completely after i made the exit. The mechanic told me that i need a new ignition cassette! So dangerous! *tr

When coming to a stop at an intersection, the drivers side seat belt locks repeatedly making it impossible to lean forward to see if the intersection is clear. Even after slowly leaning all of the way back and trying to lean forward again, it locks. The seat belt must be removed to avoid being held back in the seat and unable to see. In addition, when trying to remove the seat belt, the button sticks and must be pressed several times before it releases. *tr

Brought my 2001 saab 9-3 for campaign recall 05v399000 idm to dirito brothers saab of walnut creek, california. Dealer stated not required to change the idm. If my idm fails at a later date, i could be susceptible to injury or death. Need to know if dealer is required to change idm. *tr