Bmw 540ia 1999

• Recall 9228 [USA]: The cable insulation can be worn away, exposing the wire. the wire could contact the clip or a short circuit could occur.
  Vehicle description: passenger vehicles. The thickness of the main positive electrical cable (generator to starter) insulation is less than specified, making it susceptible to being abraded or cut by the clip that secures the cable to the generator.
  dealers will apply a thickness of insulating tape to the cable in the area of the clip, and install a revised clip.
  owner notification began february 26, 1999.Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact bmw at 1-800-831-0117. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 12050 [USA]: If this problem occurs, the car may no longer operate in reverse, 1st, 2nd, or 3rd gears.
  Vehicle description: passenger vehicles equipped with a 5hp24 automatic transmission. Premature wear of the ring gear can occur, leading to the loss of 1st, 2nd, 3rd, and reverse gears.
  dealers will replace the automatic transmission.
  owner notification began february 26, 1999.Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact bmw at 1-800-831-0117. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

I have a 1999 540i and the reverse has stopped working completely. The forward gears work perfectly but the reverse suddenly stopped working. I have read many similar stories. *tr

Radiator cracked at top hose inlet causing loss of coolant

Tl*- the contact owns a 1999 bmw 540ia with failure mileage of 100,000 miles. The contact stated that while driving at 40 mph he began having problems with the transmission. The contact stated that the gears began to function improperly, and could not be operated in 1st through reverse gears. The contact took the vehicle to the bmw dealer, where they stated that there was nothing that they would do to fix the recall. They refused to repair the vehicle without cost because the recall was issued by nhtsa and not by them. The contact stated that as of 4-13-07 the dealer has had the vehicle for over a month, and wanted to charge him $5,000, even though the failure was due to the recall. The current mileage was 140,000.*ak

I had troubles with my abs module unit that is attached to my bmw 1999 540ia. I have become aware that this is a common problem that disables the abs control of my car and many other same model cars as mine. I had to replace the part myself due to no recall or acceptance from bmw that this is a major problem with a safety feature on my and many other bmw's similar to mine. The failure occured out of the nowhere and the resulting problem is that the unit would go off after car would warm up then eventually over time the unit completely fails and disables the cars anti braking system. The unit was replaced by me after numerous times to get bmwna or anyone from bmw to do anything about the problem with my unit. The new part cost me about $700 and the labor was about $60 to get it installed and programmed from teh bmw dealer around here. I have my old part if that helps but it is of no use. Thx michael d. Karr. *nm

1) check coolant level warning light came on twice in 1 week. Kuni bmw conducted my factory inspection ii service only 2 months before this occured. ) radiator cracked where the upper hose enters the radiator, leaking fluid into the engine bay and ground. 3) replace the radiator. This is a well know defect on this vehicle - why doesn't bmw do something about this?*ak

Radiator failed on my 1999 bmw 540 at 54,700 miles. I believe this to be a safety problem that bmw needs to address. This safety problem: - disables the vehicle no matter where you are from rush hour traffic where the panic could endanger other drivers, to the middle of nowhere in the dead of winter by yourself. - steam from failed radiator blocks vision of the road, or whatever else is in the drivers side front corner of the vehicle. - failure can not be predicted by visual inspection of the radiator.*ak

Crack in radiator - needs replacement. *ak

Headlamp internal adjusting rods (brittle plastic material) fail prematurely causing headlamp bean to deflect and lamp beams to shudder or wiggle. This tends to reduce the field of vision for drivers and to blind oncoming motorists.

No summary. Dt