Lincoln Navigator-4x4 2000

• Recall 83423 [USA]: Decreased lighting visibility may result in a vehicle crash.
  Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
  sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.
  this recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.In order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.The list can be found under "document search" located at the bottom of your screen.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 38104 [USA]: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
  Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
  tradesonic will notify owners and replace the lamps free of charge. The recall is expected to begin during july 2006. Owners may contact tradesonic at 626-934-8884.
  this recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.For more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 47842 [USA]: Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
  Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. Due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
  ufi will notify owners and replace the filters free of charge. The recall began on august 4, 2006. Owners may contact ufi filters usa at 800-230-5876.
  this recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 61623 [USA]: A fire at the switch could occur.
  On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
  by letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. Owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in february 2006. Owners who did not have their speed control deactivated are being notified to have their system remedied beginning in february 2006. Owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. Owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017 and 06v286)
  ford recall no. 05s28.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 36690 [USA]: This condition could lead to a fire. fires have occurred while the vehicles were parked with the ignition 'off.'
  On certain sport utility vehicles and pickup trucks, the speed control deactivation switch may overheat, smoke, or burn.
  as an interim repair, owners will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. As soon as replacement parts are available (early april 2005), owners will be instructed to return to the dealers for installation of a new switch free of charge. Owners may contact ford at 1-800-392-3673. (note: also see recalls 05v388 and 06v286)
  ford recall no. 05s28.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 2494 [USA]: Loss of visibility while driving increases the risk of a crash.
  Vehicle description: passenger cars, sport utility vehicles, and light and medium duty pickup trucks. A switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, or ignition of the plastic cover material. Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. These vehicles were built at the following assembly plants: atlanta plant from 2/11/00 through 7/31/00; chicago plant from 2/14/00 through 8/4/00; kansas city plant from 2/26/00 to 9/4/00; kentucky truck plant from 2/18/00 to 8/31/00; michigan truck plant from 2/23/00 through 8/3/00; norfolk plant from 2/21/00 through 7/27/00; wayne stamping and assembly plant from 2/25/00 through 8/15/00; and wixom plant from 2/15/00 through 8/8/00.
  dealers will inspect the date code on the wiper motor. Motors built with the suspect time frame will have the wiper motor gear case cover replaced. Owner notification began august 20, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 7509 [USA]: The trailer hitch could then separate from the vehicle.
  Vehicle description: multi-purpose vehicles. The trailer hitch assembly to the frame attaching bolts could lose the clamp load.
  dealers will replace the trailer hitch mounting bolts and nut plates.
  owner notification began may 15, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 2005028 [Canada]: Electrical
  On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: initially as an interim repair, owners will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. As soon as replacement parts are available, owners will be instructed to return to the dealers for installation of a new switch or fused wiring harness.

  Show Content

• Recall 2004164 [Canada]: Steering
  On certain vehicles, ford has issued a scheduled maintenance guide update which specifies that every 20 000 kms, the steering linkage, which includes tie-rod ends, should be inspected. The vehicle owner is asked to place the tie-rod end inspection procedure supplied with this maintenance guide update in the vehicle's glove box for reference and safekeeping. The vehicle owner is to provide the inspection procedure to their repair facility to help properly identify worn tie-rod ends. Performing the vehicle scheduled maintenance, including maintenance inspections, is the responsibility of the vehicle owner. Failure to replace worn tie-rod ends may eventually result in a tie-rod end separation that could adversely affect steering control. If the inspection reveals that a tie-rod end is worn and must be replaced, the repair will be at the owner's expense unless the vehicle is still covered by the basic vehicle warranty, or has an extended service plan coverage that includes these components.

  Show Content

• Recall 2001204 [Canada]: Other
  Certain passenger cars, sport utility vehicles, and light and medium duty pickup trucks. A switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, smoke or, potentially, ignition of the plastic cover material. Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. Loss of visibility while driving increases the risk of a crash. Correction: dealers will inspect the date code on the wiper motor. Motors built with the suspect time frame will have the wiper motor gear case cover replaced.

  Show Content

• Recall 2000079 [Canada]: Structure
  On certain vehicles, the trailer hitch assembly attachment bolts may lose clamp load. If the operator does not notice the condition due to rattle or other looseness of the trailer hitch assembly, there is a potential for the trailer hitch to separate from the vehicle. Correction: trailer hitch mounting bolts and nut plates will be replaced with higher strength mounting bolts and nut plates installed at a higher torque and including an adhesive patch.

  Show Content

• Recall 2000281 [Canada]: Lights and instruments
  On certain vehicles, the daytime running lamp circuit contains a resistor that is corroding. If this occurs, the resistive element can open, resulting in a loss of daytime running lamp (drl) function. If drl function is lost, there may be reduced vehicle conspicuity, which could increase the risk of a vehicle crash. Correction: dealers will install a sealed daytime running lamp resistor.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Spark plug ejection from cylinder head investigation # DP05005

  On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.Odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.As of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.In addition, odi is aware of only two incidents where the vehicle stalled without restart.Information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.In the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.In one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.In another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.None of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.As the petitioner noted, and odi¿s analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles.However, odi¿s analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences.None of these showed any evidence of a serious safety consequence.Given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low.In view of the foregoing, it is unlikely that nhtsa would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition.Therefore, in view of the need to allocate and prioritize nhtsa¿s limited resources to best accomplish the agency¿s safety mission, the petition is denied.
  

  Show Content

• Speed control deactivation switch fire investigation # PE04078

  In its letter dated january 27, 2005 to odi, ford indicated that it would conduct a safety recall (nhtsa recall # 05v-017) to remedy an overheating speed control deactivation switch in approximately 738,490 subject vehicles.The vehicles affected by the recall are certain 2000 model year (my) ford f150, ford expedition and lincoln navigator equipped with speed control and certain 2001 model year f150 supercrew vehicles built through august 7, 2000.Since opening pe04-078, odi has identified other reports of "key off" engine compartment fires in ford vehicles with similar speed control deactivation switches that were not the subject of this preliminary evaluation or fords recall 05v-017.Fords response to the odi information request letter dated december 3, 2004, provided an additional 107 allegations of "key off" engine compartment fires that were also in vehicles not subject to this investigation or included in the ford recall 05v-017.An engineering analysis (ea) is warranted to determine if a safety defect trend exists relating to "key off" engine compartment fires in vehicles outside the scope of this preliminary evaluation.Odi will expand the scope of its investigation at the ea phase to include the 1995 through 2002 model years of the ford f150, ford expedition and lincoln navigator vehicles.
  

  Show Content

On october 4, 2017 at approximately 3:45 pm, i departed from the sacramento children's home through an adjacent alley traveling through the south bound entrance. As i made the left turn into the alley as i gradually got up to speed my vehicle suddenly began to accelerate. I was startled by the sudden increase of speed and immediate made an attempt to put the vehicle in neutral and shut the vehicle down and apply the brakes. Before i could make the corrections the vehicle had veered off to the left hand side of the alley and struck an oak tree. To my guess the vehicle was traveling at a rate of speed of about 25-30 mph. On impact i slammed into my motorola speaker that was attached to my sun visor and split my head open which required 8 staples to close.

Tl* the contact owns a 2000 lincoln navigator. While driving 65 mph speed and take your foot of the gas pedal and car continues to go 65 mph all of sudden no power steering or power brakes. In addition, the contact stated that the electrical system failed to operate intermittently. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 115,000. The consumer stated the vehicle continued to go 65 mph, even when he removed his foot from the accelerator. The rpm meter and the motor speed dropped down to 500 rpm and the engine shut off. There was no power steering and no power brakes, but the vehicle continued going 65 mph. Also, the radio and air conditioner burned out. The dealer stated the burn happened inside the wire harness. Updated 03/08/17.*jb...Updated 03/08/17 *bf updated 09/18/2017*js the consumer stated the radio, ac-fans, turn signals, electric windows, brake lights, turn signals, hazard lights, tail gate, window wiper, actuator, over head stop light, door lock, the tail gate would not open, air springs/air compressor, heater controls, and the wire fuse caused a fire. *js *tr

Vehicles wipers will not cut off. Wiper motor smokes bad from under hood.

Vehicle was parked and turned off when it suddenly exploded. *tt

Drove car today and it had been sitting parked for 5 hours . Neighbors called my cell to tell me the truck was on fire and the fire department had been called to try to put it out . The fire department had to chainsaw the hood and they were finally able to put it out without the fire destroying the passenger compartment. The truck however had burned for about 15 minutes in the engine compartment . This truck had self started its own fire being left alone in the driveway for 5 hours . *tr

Tl* the contact owns a 2000 lincoln navigator. The contact stated that the engine compartment ignited in flames without warning. The fire department was contacted and no injuries were reported. The vehicle was not taken to the dealer and the manufacturer was not made aware of the failure. The vehicle was destroyed. The cause of the fire was unknown to the contact. The vin was not available. The failure and current mileage was 157,000.

My spare tire fell out from beneath my truck. The cable was split at the end. The small connector that is attached to the cable had separated from the end of the cable which also holds a metal pad in place. The pad allows the spare tire to be raised or lowered. All parts were retrieved, the spare tire, metal pad and connector. The spare tire hoist assembly was still operational, minus the parts that fell out. *tr

Tl*the contact owns a 2000 lincoln navigator. While the vehicle was parked, the front end burst into flames. The contact stated the fire started near the cruise control switch. The fire department came and put out the fire.. The fire department filed a report. The contact stated no injuries occurred. The vehicle was destroyed. The contact reference recall nhtsa campaign id number: 05v017000, vehicle speed control:cruise control, and stated the recall work was never performed on her vehicle. The vehicle was purchased used in 2010. The approximate failure and current mileage were 118,000.

Tl* the contact owns a 2000 lincoln navigator. During brake application at 10 mph, the brake pedal fell to the floor-board. Consequently she crashed into another vehicle. The vehicle was taken to a local repair facility, in which the mechanic attempted to make repairs. However, while in the shop the vehicle caught on fire while idling. The fire department extinguished the flames. The fire report states that fire was caused by brake booster failure. All the plastic components of the braking system and brake lines were destroyed. No repairs were made to the vehicle. The current and failure mileages were under 190,000. The vin was not available.

Common OBD-II Error Codes

• P0302 [1] Cylinder 2 Misfire Detected
• P0303 [1] Cylinder 3 Misfire Detected
• P0304 [1] Cylinder 4 Misfire Detected
• P0305 [1] Cylinder 5 Misfire Detected
• P0306 [1] Cylinder 6 Misfire Detected
• P0307 [1] Cylinder 7 Misfire Detected
• P0308 [1] Cylinder 8 Misfire Detected
• P0316 [1] Misfire Detected On Startup (First 1000 Revolutions)
• B1994 [1] Driver Side
• B1998 [4] Passenger Side
• P0442 [3] Evaporative Emission Control System Leak Detected (small leak)
• P0455 [5] Evaporative Emission Control System Leak Detected (gross leak)
• P0456 [2] Evaporative Emissions System Small Leak Detected
• P0457 [2] Evaporative Emission Control System Leak Detected
• P1442 [2] A/C Evaporator Air Temperature Circuit Range/Performance
• P1635 [3] Internal Vref Malfunction
• P1639 [3] Data Output Link Circuit Failure
• P0171 [1] System too Lean (Bank 1)
• P0174 [1] System too Lean (Bank 2)
• P0500 [1] Vehicle Speed Sensor "A" Malfunction
• P1502 [1] RCNT Solenoid Circuit Malfunction
• U1039 [1] SCP (J1850) Invalid or Missing Data for Primary Id / Vehicle Speed
• C2140 [1] C2140
• B2140 [1] B2140
• P0350 [3] Ignition Coil Primary/Secondary Circuit Malfunction
• P0360 [1] Ignition Coil J Primary/Secondary Circuit Malfunction
• P0358 [2] Ignition Coil H Primary/Secondary Circuit Malfunction