Pierce Velocity 2007

• Recall 138658 [USA]: If the aerial device moves in an unexpected direction, the ladder may contact an object, such as a building or an electrical wire, increasing the risk of injury.
  Pierce manufacturing (pierce) is recalling certain 2004-2018 arrow xt, dash, enforcer, impel, quantum and velocity aerial vehicles. The aerial device may unexpectedly rotate to the right when the ladder is being extended.
  pierce will notify owners, and dealers will reprogram the aerial control module, free of charge. The recall began february 28, 2019. Owners may contact pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74b295.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 129118 [USA]: If the bracket falls, it could strike a person below.
  Pierce manufacturing (pierce) is recalling certain 2007-2017 pierce velocity, impel, arrow-xt, quantum, and enforcer emergency response vehicles equipped with 75ft aerial devices with a 21 inch or 28 inch limited retraction bracket. The bracket on the aerial device may detach from the aerial and fall to the ground.
  pierce will notify owners, and dealers will install additional hardware to mount the limited retraction bracket, free of charge. The recall began on august 22, 2018. Owners may contact pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74b290.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 121560 [USA]: Axle shafts that are not properly heat treated may break and potentially disable the vehicle, increasing the risk of a crash.
  Pierce manufacturing (pierce) is recalling certain 1999-2013 arrow xt, dash, enforcer, quantum and velocity fire trucks equipped with the electric all-steer rear steering option. The affected vehicles have rear steer axle shafts that were not properly heat treated.
  pierce will notify owners, and dealers will replace the rear steer axle shafts, free of charge. An interim notice was mailed on july 24, 2017. The recall began june 3, 2020. Owners may contact pierce customer service at 1-888-974-3723.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 96282 [USA]: In the event of a crash, the weak springs may allow the door to open and possibly fail to contain emergency personnel or equipment, increasing the risk of injury.
  Pierce manufacturing inc. (pierce) is recalling certain model year 2007-2013 velocity, impel, and dash cf emergency vehicles manufactured june 6, 2007, through may 31, 2013. The springs in the outer door handles are not of sufficient stiffness to prevent inadvertent door opening in certain impacts. Thus, these vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 206, "door locks and door retention components."
  pierce will notify owners, and dealers will replace the door handle spring with a stiffer one, free of charge. Owners may contact pierce at 1-920-832-3000. The recall began on june 28, 2013. Pierce's recall number is 74b242.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 93320 [USA]: If the door inadvertently opens while the vehicle is in motion, the occupants may fall out and suffer personal injury.
  Pierce is recalling certain model year 2007-2010 velocity and impel fire trucks manufactured from june 6, 2007, through october 30, 2010. The springs inside the inner door handles may allow the door to open inadvertently.
  pierce will notify owners, and dealers will replace the inner door handles, free of charge. The recall began during may 2013. Owners may contact pierce at 1-920-832-3000.
  pierce's campaign recall number is 74b237.Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 94509 [USA]: If the driver is slow to react during this esc intervention, the vehicle may deviate from the intended line of travel, increasing the risk of a crash.
  Pierce manufacturing (pierce) is recalling certain model year 2007-2011 arrow xtand velocity, model year 2008-2011 custom contender, impel, quantum and model year 2009-2011 saber emergency trucks, equipped with meritor wabco electronic stability control (esc) modules, manufactured from december 19, 2007, through october 7, 2011. Under certain road and driving conditions, vehicle body roll and road inclination characteristics may adversely affect the slip angle calculation of the electronic stability control (esc) system. This might cause the esc to perceive an over steering situation and therefore apply the outer wheel brake on the front axle until the vehicle is perceived to be stable.
  pierce is working with meritor wabco and will replace the control module free of charge. The safety recall began on december 16, 2011. Owners may contact meritor wabco at 1-248-435-8001 or pierce at 1-920-832-3000.
  the nhtsa number assigned to the meritor wabco's recall is 11e-039.Pierce's safety recall number is 74b226.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 68204 [USA]: Detachment of the steering gear will result in a loss of steering control that could cause a crash.
  Pierce is recalling certain model year 1998 through 2008 arrow xt, lance, velocity, enforcer, impel, and dash custom fire apparatus vehicles manufactured from may 30, 1998 through november 25, 2008. The steering gear bracket may fracture and break. If this occurs the steering gear may detach from the vehicle.
  pierce will notify owners and dealers will install a new steering gear mounting bracket free of charge. The safety recall began on october 12, 2010. Owners are being instructed to inspect the steering gear bracket prior to each trip. The remedy to repair this defect is expected to begin no earlier the january 31, 2011. Owners may contact pierce at 1-888-974-3723.
  pierce safety recall no. 74b207.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 80743 [USA]: If this interference occurs, braking performance may be reduced without warning and a crash may occur.
  Pierce is recalling certain model year 2006 through 2010 arrow xt, dash, enforcer, impel, quantum, and velocity fire trucks manufactured from october 11, 2006 through june 16, 2010 and equipped with meritor wabco ex225 rear disc brakes and onspot automatic tire chains. The meritor wabco ex225 rear disc brake caliper may interfere with the onspot automatic tire chain brackets. This interference may restrict the caliper from full movement.
  dealers will install new automatic tire chain brackets. The new brackets provide additional clearance for the full actuation of the disc brake calipers. This service will be performed free of charge. The safety recall began in july 2010. Owners may contact pierce at 1-920-832-3000.
  pierce safety recall no. 39-0139830. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 86303 [USA]: If this occurs the fire hose may drop to the roadway without warning. potential injury to people and property may occur. the sudden hose deployment may also distract drivers trying to avoid the hose and a crash may occur.
  Pierce is recalling certain model year 2003 through 2009 custom contender, dash, enforcer, impel, lance saber, and velocity fire trucks manufactured from february 20, 2003, through march 27, 2009. These trucks may be equipped with drop-down fire hose trays mounted under the front bumper. The hose tray latch may accidentally open while the vehicle is in motion.
  a new and improved latch design has been developed and a new hose box incorporating the new latch will be installed free of charge. The safety recall began on october 4, 2010. Owner may contact pierce at 1-920-832-3000.
  pierce safety recall no. 39-0139830.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 86029 [USA]: Unexpected emergency vehicle engine shutdown under certain conditions could hamper rescue operations and place the public at risk.
  Pierce is recalling certain model year 2006 through 2010 arrow xt, dash, lance, quantum, and velocity emergency vehicles manufactured from december 20, 2006, through february 1, 2010, equipped with detroit diesel series 60 engines. The engine may shut down unexpectedly when a diesel particulate filter over temperature condition is detected.
  owners will be notified by detroit diesel and detroit diesel will repair the vehicles free of charge by reprogramming the engine control logic to illuminate a malfunction indicator light without requesting engine shutdown. Please see daimler trucks' defect report 10e-005. The safety recall began on may 28, 2010. Owners may contact daimler trucks at 1-800-547-0712 or pierce at 1-920-832-3000.
  pierce's recall campaign number is 39-0139830.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 67799 [USA]: Inadvertent deployment of the side-roll protection system could result in a vehicle crash or injury to an out of position occupant.
  Pierce is recalling certain model year 2007 through 2009 fire trucks equipped with side-roll protection systems. The sensor designed to detect vehicle roll can malfunction resulting in an inadvertent deployment of the protection system.
  pierce will notify owners and the vehicles will be repaired free of charge. The safety recall began on august 31, 2009. Owners may contact pierce toll-free at 1-888-974-3723.
  pierce's recall campaign number 39-0139830.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 84788 [USA]: If metal-to-metal contact were to happen, an electrical arcing between the cab and battery could occur increasing the risk of electrical short circuit and a fire.
  Pierce is recalling 167 my 2007-2008 velocity and impel fire trucks. A battery box is positioned on both sides of the chassis frame directly under the cab. Cab interference may occur with the positive battery post and the aluminum cab floor substructure.
  owners will receive a remedy kit along with instructions and should inspect the positive battery posts to make sure the protective caps have not worn away, if contact with the cab has occurred, replace the battery post protective caps. This remedy will be free of charge. The recall began on april 6, 2009. Owners may contact pierce at 1-888-974-3723.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 84991 [USA]: If the adjuster can not rotate, brake performance may be compromised and a crash may occur.
  Pierce is recalling 15 my 2007-2008 dash, enforcer, impel, quantum and velocity fire trucks equipped with arvinmeritor rear disc brakes and hendrickson firemaax suspension. Interference with the brake caliper adjuster bolt sleeve and the suspension beam may occur. This interference may occur if the right hand and left hand brake components were assembled on the wrong side of the axle. The adjuster bolt is designed to rotate as the brake pads wear. If the sleeve becomes damaged, the sleeve may prevent the adjuster from rotating.
  dealers will adjust the bolt sleeve and the proper components free of charge. All owners have been notified by arvinmeritor.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 83606 [USA]: This may result in a fire hazard.
  Pierce is recalling 76 my 2007-2008 arrow xt and velocity fire trucks equipped with caterpillar c13 diesel engines. The extension pipes attached to the aftertreatment regeneration device (ard) may develop a hole, and heat and flame may escape during a regeneration of the diesel particulate filter.
  pierce is working with caterpillar to repair these vehicles (please see 08e054). Owners may contact caterpillar at 1-800-447-4986 or pierce at 1-920-832-3000.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 74771 [USA]: This condition has the potential to cause the steering gear to stall and restrict the steering turning angle of the vehicle which could result in a vehicle crash.
  On certain fire trucks equipped with trw steering gears, models tas85 and rcs85, these steering gears contain potentially defective sector shafts with an incorrect gear tooth which may interfere with the rack-piston teeth, resulting in a stick or bind condition.
  pierce is working with trw to replace the defective steering gear (please see 07e101). The recall began on january 11, 2008. Owners ontact trw at 765-429-1768 or pierce at 920-832-3249.
  customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 2020240 [Canada]: Structure
  Issue: on certain aerial fire trucks, the ladder could rotate unexpectedly to the right when it is being extended due to an error with the control module. Safety risk: a ladder that moves unexpectedly could create an increased risk of injury. Corrective actions: pierce has repaired all affected fire trucks.

  Show Content

• Recall 2020239 [Canada]: Structure
  Issue: on certain aerial fire trucks, the bracket that limits the travel of the ladder could loosen over time and separate from the ladder. As a result, the bracket could fall to the ground. Safety risk: a bracket that falls from a ladder could create a risk of injury. Corrective actions: pierce has repaired all affected fire trucks.

  Show Content

• Recall 2013167 [Canada]: Other
  Certain fire trucks fail to conform to canada motor vehicle safety standard 206 – door lock and door retention components. Specifically, the outer door handle spring is not sufficiently stiff, which may allow the door to open during a vehicle crash. As a result, an unbelted occupant could fall from the vehicle and sustain personal injury. Correction: dealers will replace the outer door handle actuator spring with an updated version.

  Show Content

• Recall 2013062 [Canada]: Other
  On certain fire trucks, the inner door handles may have been manufactured incorrectly, which could allow the door to open unexpectedly during vehicle operation. Should a door open while the vehicle is underway, an unbelted occupant could fall from the vehicle and sustain personal injury. Correction: dealers will replace the inner door handle and door linkage rod on all cabin doors.

  Show Content

• Recall 2010182 [Canada]: Engine
  Certain fire trucks equipped with a detroit diesel epa 07 series 60 engine may contain software which could cause the engine to shutdown unexpectedly when a diesel particulate filter over-temperature condition is detected. Unexpected emergency vehicle engine shutdown could hamper rescue operations and increase the risk of property damage, personal injury or death. Correction: dealers will reprogram the engine control logic.

  Show Content

• Recall 2010319 [Canada]: Steering
  On certain vehicles equipped with a non-independent front suspension, the steering gear bracket may fracture and break. If this occurs the steering gear may detach from the vehicle, without warning, and cause a crash. Correction: a new steering gear mounting bracket will be installed.

  Show Content

• Recall 2009238 [Canada]: Electrical
  On certain fire trucks, the aluminium cab floor substructure may contact the positive post of the battery. This could cause an electrical arc between the cab and battery, which could create a shock hazard or a risk of fire, causing cause property damage, personal injury or death. Correction: dealers will install a spacer between the battery tray and the forward wall of the battery box.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.