Saab 900 1996

• Recall 14050 [USA]: If the headlamp assemblies are replaced, customers may not be able to properly aim the headlights.
  Vehicle description: passenger vehicles. The instructions for properly aiming the headlighting system were omitted. This does not meet the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."
  owners will be sent aiming instructions, and directions for affixing these inserts to the owner guides. If an owner so desires, a dealer can affix the inserts in their owner guide for them.
  owner notification began june 15, 1998.Owners who do not receive the free instructions and labels within a reasonable time should contact saab at 1-800-955-9007.Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

• Recall 12899 [USA]: This binding can result in the throttle plate not returning to the closed position when the throttle pedal is released and a subsequent loss of throttle control.
  Corrosion around the zinc-coated throttle control lever bushing can cause the throttle lever to bind.
  dealers will replace the zinc-coated throttle control lever bushing with a nickel-coated bushing and bolt.
  owner notification:owner notification is expected to begin may 1, 1997. Note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saab at 1-800-955-9007.Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.

• Recall 28169 [USA]: Consequence of non-compliance: the belt may not latch properly increasing the risk of injury to an occupant should a vehicle crash occur.
  During static testing of belt anchorage points, the outboard attachment plate being used in the testing deformed and detached from the seat anchorage. This does not comply with fmvss no. 209, "seat belt assemblies" and no. 210, "seat belt assembly anchorages."
  dealers will inspect the safety belt assemblies for the date of manufacture. Any assembly with date year 96 week 10 day 2 will be replaced.
  system: interior; seat and shoulder belts and belt anchor; fmvss no. 209 and 210. Vehicle description: passenger vehicles.Note: owner notification is expected to begin may 15, 1996. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact saab at 1-800-955-9007. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.

• Recall R/1997/024 [UK]: Possibility of the throttle binding
  Binding of the throttle lever may occur due to the possibility of white corrosion.
  the affected vehicles are being recalled for replacement of the zinc coated bushing in the throttle lever with a nickel coated version.

• Recall 1998163 [Canada]: Lights and instruments
  These vehicles do not comply with c.M.V.S.S. 108 - lighting system and retroreflective devices. The section titled "headlamp aiming" was omitted from the owner's manual. Correction: dealers will insert a page supplement in the owner's manual containing the instructions on headlamp aiming.

• Recall 1997099 [Canada]: Engine
  Note: vehicles with 4-cylinder engines. The zinc-coated throttle control lever bushings in the throttle housing may corrode, causing the throttle lever to bind. This could result in the throttle plate not returning to the closed position when the accelerator pedal is released and a subsequent loss of throttle control. Correction: zinc-coated throttle lever bushing in the throttle housing will be replaced with a nickel-coated bushing and bolt.

• Recall 1996070 [Canada]: Seats and restraints
  Note: 5 door vehicles. These vehicles do not comply with c.M.V.S.S. 210 - seat belt assembly anchorages. Vehicles were assembled with a non heat treated outboard attachment plate on the safety belt which could in certain circumstances deform and detach from the seat anchorage. Correction: front seat belts will be inspected and replaced if necessary.

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Defective water pump pulley investigation as of 20000925

  A
  

  Show Content

• New wheel bolts investigation as of 19981009

  Saab issued a tsb informing dealers about a new wheel mounting bolt.If the issue is loosening of the lug nut, this could lead to bolt fatigue and the potential for a wheel separation.
  

  Show Content

Common OBD Error codes specific to this vehicle.

• P0300 [1] Random/Multiple Cylinder Misfire Detected
• P0301 [1] Cylinder 1 Misfire Detected
• P0302 [1] Cylinder 2 Misfire Detected
• P0303 [1] Cylinder 3 Misfire Detected
• P0304 [1] Cylinder 4 Misfire Detected

Driving smoothly at 50 mph in 1996 saab 900 se turbo, 99k miles. Engine rpm suddenly but smoothly drops to zero and stopped in a very unsafe place on the highway. Car would not re-start. Absolutely no faults of any kind occurred during the months leading up to this incident. This car's direct ignition cassette was replaced once already in jan. 2000 by the previous owner. *jb

While driving ball bearrings exploded in the lower engine. Consumer heard a loud boom. The vehicle was full of clean oil. Consumer contacted the maufacturer and the dealer. Vehicle is currently at dealer. *ak

Prior to di failure, starting impairment and misfires detected with cel. Upon failure, car would not run and steering was lost. To correct failure, new di was fitted after it was broken. Symptoms should have been reason enough to change it early. *nm

When the rear passenger door was opened front passenger side air bag deployed, and smoke entered the passenger's cabin. *ak

On april 27, 2003, my saab 900 se had an electrical failure while driving within a minute had completely destroyed the car. The "check battery" light came on along with the hazard light. My wife was driving the car in heavy traffic and just escaped the vehicle when it was engulfed in flames. The police had to call me to get the license plate number and vin, as they had melted. The car had 72,000 miles and had been checked twice in the past year. Just months before it had been completely inspected. The car was in show room condition. *jb

Odometer fraud. The advertised mileage was 55,000 but the carfax reported the mileage at 150,000 miles over a year ago. I reported it to the dealer, took back my deposit and gave back the car. They informed me they already had another buyer for the car and are still advertising it with 55,000 miles. *jb

The timing belt failed. *jb (saab 900 se)

No summary listed for above vehicle. *ak

While driving heard a raddling noise, had it checked out. Main front left spring had fractured. Spring replacement, 44 83-178.Contacted dealer.*ak

Will not shift into first, fifth, or reverse. Key cannot be removed since it will not shift into reverse. Saab has refused to pay for repair.*ak

Plastic fuel tank is leaking, dealer and the manufacturer were notified. Feel free to provide any further information.*ak

S model, consumer smelled fuel, dealer determined the plastic fuel tank was leaking. Part was replaced, new fuel tank has leaked twice.*jb

Intermittently gearbox light will light, causing vehicle to lose 1st and second gear. This is a safety issue as vehicle may not get up to hightway speeds at ramps, almost causing a rear end collision. This is a know issue w/ saab. I contacted them regarding this problem. They stated there are no safety issues open on this vehicle. Over 25 posts for this same problem on saabnet.Com. Dealer has tried to repair vehicle twice without success. I have spent over $800.00 trying to repair this safety problem . Please help. *ak

While traveling 60mph transmission became locked in gear. Was not able to shift into another gear. Had remained in 4th gear until able to shift. Took vehicle to service station, and mechanic could not locate any problems. Taking vehicle to dealership.*ak

Timing chain has to be replaced after 75,000 miles. Vehicle was making a loud warning noise. Saab dealer found problem after doing a routine service check. Although the problem has been found, dealer has never done repairs. *ak

Saab cars usa refuses to pay for a manufacturer defect. I have had the clutch plate examined by specialists and they all think this is an obvious manufacturer defect. Most experts have never seen a clutch plate split in half like this. The debris from the clutch disintegrating blew into the transmission housing causing a hole. The extended warranty company refuses to pay for the transmission because it was caused by the clutch exploding. I sent photos to saab and three separate letters requesting they fix this problem to no avail. I have all the documentation to support these facts.*ak

This car has been nothing but a nightmare. It has required three tows from june 2001 to february 2002. The most expensive failure occurred the day after i had taken the car to a local dealer for a routine oil change (international motors, falls church, va), and the transmission and clutch failed because there was a transmission fluid leak that was not caught by their mechanics. I have contacted saab corporate by letter in december 2001 about my multiple problems with this car. Their response by telephone was that there was nothing that they could do. *ak

Safety alert comes on and needs dealer service if battery disconnected. Cannot tell if airbag works - requires dealer service to correct each time. *ak

While driving about 55 mph, the electric seat on the driver's side started moving to the rear. This happened five times before driver arrived at home, and was causing the driver's feet to be pulled away from the pedals. *ml

The complaint here is that a provided safety device, the seat belts, have inadequate webbing length to accomodate larger occupants. I have contacted saab's customer service center and was advised that while seat belt extenders were available for this model, the cost would be $250 each. We consider that cost-prohibitive to enable use of a manditory safety device. We have purchased other new and used vehicles for more than the last decade such as from gm and seat belt extenders were readily available at zero cost. I can entertain purchasing these extenders for a reasonable amount, such as $50/each, but $250/each is outrageous and quite frankly shouldn't be necessary as the belt webbing is quite short to begin with. Saab's position as of this afternoon is they will offer $100 off on a pair of these belts. Still, $400 out of pocket to enable a manditory-to-use-by-state-and-federal-law safety feature in a car is absurd. Saab's statement was we suggest you try out the car before you buy, and that something like this should tell us not to buy. That misses the whole point of why these safety belts were required in the first place. I am now going through a local reference obtained from the national mobility equipment center (thanks nhtsa for suggesting it!) and they are looking at alternate solutions which are expected to be less in cost. But the point here is why are vehicle manufacturers allowed to deny customers the effective use of manditory safety items because of exorbitant extra pricing, such as seat belt extenders at $250/each when the problem could be avoided simply be lengthing the seat belt webbing in the first place, at a likely cost of less than $10? I think that as a safety issue if nothing else, vehicle manufacturers must provide, at reasonble cost, whatever is necessary to enable use of manditory lawfully-required safety features if the "standard" is not comprehensive to cover customers. *ak

Vehicle does not start first thing in morning. Would jerk after starting, for 1/2 hour. The engine check light comes on after the jerking motion. Stayed on until vehicle put in the garage, then went off. Came back on 2 days later. *ak

Exhaust check valve lifters malfunctioned.

Battery went dead. Nlm

Consumer replaced headlight cover four times. The headlight cover is made of glass, and has broken each time in the last 1 1/2 years. *ak

During front end collision there was no deployment of air the bags.

Loose connection caused drivers side headlight to fail. Nlm

Antenna gears were damaged and motor failed causing it not to retract properly. Nlm

Cellular phone kept blowing fuses. Nlm

After a 30 minutes of driving vehicle was parked in a parking lot. Smoke was noticed coming from underneath the hood area before a fire started. Fire department was on site to put out fire. Saab has been contacted.*ak vehicle traveling, check the engine light appeared and stayed on the cause was determined to be a sensor. The vehicle slips while in gear and before going into gear due to loss of fluid by lthe leaking transmission. *yh

Sun visor snapped off. Nlm

Vehicle idling in parked position, occupants smelled funny odor, smell got wqrse, subsequently fire started coming from underhood, vehicle available for inspection. *ak

Trunk latch release failed several times.

Dirty cabin air filter caused a musty smell to come from the air conditioner unit. Nlm

Thermostat failed.

A sudden acceleration was experienced, upon placing transmission into drive position, complete braking and steering was lost as a result. *ak

Passenger seat adjuster failed.

Fuel filter failed, causing a fuel leak. *ak

Car drifts to the right while driving.

Remote alarm system failed. Nlm

In a (18) month period all wheels have been replaced on vehicle due to collapsing. *ak

Electrical failure.

Electrical system failure, causing check engine/transmission indicator lights to fail. Qcaw

Left sideview mirror cannot be adjusted properly to enable driver to see blind spots to left rear of vehicle; nearly caused accident while pulling out of lane.

Battery failed.

Three failures of the cd player.

Air bag warning light comes on every 6 months. The dealer continues to replace the clock spring and within the next 6 months the warning light is back on again. *ak

Reoccuring gear shifting problems causing shifter bushings and motor mount housing to be worn.

No summary listed for above vehicle. *ak

Vehicle experienced clutch problem and a transmission failure, consumer wants reimbursement. (attorney for client) *slc

No summary listed for above vehicle. *ak

When driving and you can't see in the rear , please describe . *ak

While shifting from reverse to drive the vehicle suddenly accelerated forward and spinned around in a 360 degree circle.