Bmw 325xi 2004

• Recall 160266 [USA]: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
  Bmw of north america, llc (bmw) is recalling certain 2000-2005 323it, 325it, 325xit, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323ci, 325ci, 328ci, 330ci, m3 coupe, 323cic, 325cic, 330cic, and m3 convertible vehicles equipped with non-desiccated frontal takata psan inflators and pspi passenger frontal air bag inflators containing phase stabilized ammonium nitrate (psan) propellant that were used as interim remedy parts for previous takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
  bmw will notify owners, and dealers will replace the passenger's front air bag, free of charge. The recall began february 13, 2020. Owners may contact bmw customer service at 1-800-525-7417.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 105863 [USA]: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
  Bmw of north america, llc (bmw) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi sedans, and 325xi and 325i sportswagons, 2002-2006 330ci, 325ci, and m3 convertibles and 325i, 330i, and m3 coupes, 2002-2003 m5, 540i, 525i sedan, and 530i sedans, and 540i and 525i sportswagons, and 2003 x5 3.0i and 4.4i sports activity vehicles. Please note that the 5-series and x5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
  owners are advised not to drive their vehicles until the vehicle has been remedied. Bmw will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall began aug 2016. Owners may contact bmw customer service at 1-800-525-7417. Note: this recall supersedes recall 14v-348 in its entirety. Additionally, vehicles that have had their driver side frontal air bag replaced previously as part of a recall remedy need to have their air bag replaced under this recall as well. Note: on december 17, 2015 bmw removed the model year 2004 x5 3.0i and 4.4i sports activity vehicle from this recall. Those vehicles were mistakenly identified as including the air bags that are subject to this recall.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 104880 [USA]: In the event of a crash necessitating deployment of the passenger's frontal air bag, excessive internal pressure could cause rupturing of the inflator resulting in metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
  Bmw of north america, llc (bmw) is recalling certain model year 2000 323i sedans, coupes, convertibles, and sports wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and sport wagons; 2001-2005 325xi sedans and sports wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 m3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.
  bmw will notify owners, and dealers will replace the passenger side frontal air bag, free of charge. An interim notice was mailed to owners in september 2014. A second notice was mailed when an adequate supply of parts became available, on december 1, 2014. Owners may contact bmw customer service at 1-800-525-7417 or email bmw at [email protected].
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.This is an expansion of nhtsa recall 13v-172.

  Show Content

• Recall 71016 [USA]: Intermittent light operation reduces the ability to warn other motorists of the driver's intentions. this could cause a vehicle crash without warning.
  Bmw is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi vehicles manufactured from september 1, 2001, through march 1, 2005. Over time, resistance in the electrical contacts may cause one or more rear lamp functions (tail light, brake light, and/or turn-signal), within the vehicle's body panel, to stop working.
  bmw will notify owners, and dealers will repair the vehicles free of charge. The safety recall began on february 15, 2012. Owners may contact bmw customer relations and services at 1-800-525-7417.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Air bag inflator rupture investigation # EA15001

  The office of defects investigation (odi) opened pe14-016 in june 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in florida or puerto rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by takata, a tier-one supplier of automotive air bag systems.During the course of pe14-016, odi determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at odis insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included florida, puerto rico, hawaii, and the u.S. Virgin islands, areas with high absolute humidity and climatic conditions believed to be a significant factor in the inflator ruptures.As part of the recall actions, inflators removed from remedied vehicles are to be returned to takata for testing.Takatas initial test results on passenger inflators from remedied vehicles indicated a much higher than anticipated rupture frequency for inflators returned from florida.Accordingly odi requested all 10 manufacturers expand the regional recalls for passenger inflators to include other geographic areas where high absolute humidity conditions exist, including the gulf states and other coastal areas.Takatas testing of the passenger inflators to date continues to indicate this geographic area as having the highest risk, with no ruptures occurring from inflators returned from outside the expanded recall regions.During pe14-016 four additional passenger inflator field events occurred, all in vehicles from the same expanded geographic region.Also during pe14-016 four additional driver inflator field events occurred including two in vehicles from regions not known for high absolute humidity, specifically california and north carolina.Accordingly, odi requested all five of the affected vehicle manufacturers currently using the subject takata driver inflators expand to nationwide recalls.Significantly, neither of the affected vehicle manufacturers or takata provided any explanation to account for these two driver air bag inflator ruptures outside the area of high absolute humidity.Takata testing of returned driver inflators indicates a lower rupture frequency as compared to passenger inflator testing.All test ruptures reported by takata to date have occurred on inflators returned from high absolute humidity areas.The investigation now includes all manufacturers and vehicles known to be affected at this time.Odis investigation will focus on, among other things, root cause analysis, other potential defect consequences, identification of affected vehicles scope, and adequacy of the remedy.The five odi reports cited above can be reviewed online at http://www-odi.Nhtsa.Dot.Gov/owners/searchnhtsaid under the following identification numbers: 10537899, 10568848, 10585224, 10605877, 10651492
  

  Show Content

• Rear lamp illumination investigation # EA09019

  In a letter submitted to the office of defects investigation (odi) dated august25, 2011, bmwindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.Bmw will complete dealer notification in september 2011 and will begin owner notification in october 2011.All 3 series sedans (except for the m3 sedan which utilized a different rear lamp assembly) that were built between september 1, 2001 and march 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by bmw is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
  

  Show Content

• Rear lamp illumination investigation # PE09036

  Odi has received complaints from consumers stating that their tail light assembly is not properly illuminating.The tail light assembly consists of a turn signal lamp, a tail lamp and a brake lamp.The complainants have indicated that the issue is with an 8 pin connector and associated ground wiring.These components are allegedly overheating and melting due to excessive electrical current that runs through the system.Bmw issued a technical service bulletin (tsb) sib-630306 on february 2007 to address the condition by adding supplementary ground wiring to the tail lamp assembly.Odi is upgrading to an ea to further investigate the issue.
  

  Show Content

• Delayed transmission engagement investigation # DP04001

  Ms. Claire m. Tieder of reston, va, submitted a defect petition to the national highway traffic safety administration (nhtsa) by letter dated january 11, 2004, requesting a defect investigation be conducted into delayed transmission engagement on model year 2004 bmw xi vehicles.Bmws response to nhtsas information request indicated that certain bmw 3-series vehicles equipped with the gm5 transmission may exhibited a forward park to drive engagement delay from2 to 30 seconds.However, the condition can occur only during a vehicle "cold start," after the vehicle has been at rest for more than eight hours.Drivers experiencing the delay have learned to take precautionary and compensatory measures.Bwm will replace affected transmissions exhibiting the delay, after the condition has been verified, with an improved unit.No alleged crashes, injuries, or fatalities have been reported to either bmw or nhtsa relating to this issue.Based on analysis of nhtsas consumer complaints and bmws data, the petition is denied.For details, see federal register, vol. 69, no. 91 (may 11, 2004).
  

  Show Content

The contact’s girlfriend owns a 2004 bmw 325xi. The contact received notification of nhtsa campaign number: 20v018000 (air bags). The contact’s girlfriend took the vehicle to the local dealer for the recall repair. After the vehicle was repaired and the vehicle was retrieved, the air bag warning light was illuminated. The driver took the vehicle back to the local dealer for the warning light. The mechanic inspected the vehicle and informed the contact that the battery cable needed to be replaced. The contact was concerned that the failure was related to the recall repair. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 89,000.

The contact owned a 2004 bmw 325xi. The contact stated while driving 45 mph, the vehicle was struck by another vehicle on the passenger’s side causing the passenger’s side mirror to detach from the vehicle. The contact loss control of the vehicle and crashed into the median. The vehicle rolled and then came to a complete stop. The contact stated that the air bags failed to deploy. Additionally, the dashboard collapsed and the rear-view mirror detached from the windshield. The vehicle was towed from the scene of the crash. The contact received injuries to the chest, ribs, neck, and breast for which medical assistance was sought. A police report was filed. The contact stated that the driver's frontal air bag was previously replaced under nhtsa campaign number: 15v318000 (air bags). The vehicle was destroyed. The manufacturer was not contacted or notified of the failure. The approximate failure mileage was 100,000.

Ok. This car was brought in on 2/12/19 to the bmw dealer in appleton, wi. After that bmw has called me 3 times claiming he wasn't fixed. They were going to call the dealer. Now i have rec'd a letter from the dmv stating it wasn't fixed. I faxed the invoice dates 2/12/19 to bmw today. I give up. The contact is pete kempen 1-877-983-7473. Someone needs to figure out what is wrong.

My vehicle has a recall on the air bags

My daughter got into an accident where the front fender and bumper hit the side section of another car going approx 20 mph on a city street and the air bags never deployed. Luckily no one was hurt.

Takata recall - recall announced may 2015. Bmw na claims replacement parts still not available. Bmw na claims next communication to affected owners will be in january 2017. Is bmw na complying with the timeline for completing this recall?

"takata recall" i received notice of the recall by mail on 8/24/16 stating that i needed the driver and passenger side airbags replaced. I then proceeded to make an appointment on august 29th with global imports bmw located at 500 interstate n pkwy, atlanta, ga 30339. The service representative informed me that the parts were not in stock and would need to be ordered. However the recall notice did state that the parts were in stock and ready to be installed. I waited 2 weeks and never received a follow up phone call on the status of the air bags. I then called global bmw again, and they had no record of me calling, and claimed that they needed to order the airbags. This same exact issue re-occurred on my follow up phone calls on september 12th and 23rd. Then finally on october 3rd i placed another follow up phone call where once again they did not have my information, but did have a driver side airbag in stock. The customer service representative informed me that she would be checking on the status of the passenger air bag and give me a call. I called back the next day to check, and was told that they were not sure when they could obtain a passenger airbag. Over a month of phone calls and still nothing done. I am less than pleased and very concerned for the safety of me and my family while driving our vehicle. It has become obvious that bmw doesn't care about fixing the issue.

Nhtsa does not recognize the recalls on my 2004 bmw 325xi 4dr sedan. There were 2 recalls that are related to air bags. The nhtsa campaign numbers are #15v318000 and #14v428000. I would like to receive official confirmation that these recalls are valid so i can get the manufacturer to fix this. Please see the supporting docs attached. Also, i have been having weird electrical issues happening to the point the car wont shut off at times, headlights go out after a day, turn signal goes out, car dies, stereo wont work etc. I was wondering if other recalls were placed on this car as well?

Tl* takata recall. The contact owns a 2004 bmw 325xi. The contact received notification of nhtsa campaign number: 15v318000 (air bags); however, the part needed to perform the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Vin tool confirms parts not available. .....Updated 08/11/16 *bf updated 08/17/16. *jb