Ford F-350 Sd 2001

• Recall 67349 [USA]: A vehicle fire could occur with or without the engine running.
  Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.
  ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009. Owners may contact ford at 1-888-222-2751.
  ford's recall campaign number is 09s09.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 75547 [USA]: Wheel separation can result in a vehicle crash.
  Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. The inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
  federal-mogul will notify customers and will replace the hub assembly free of charge. The recall began on february 7, 2008. Owners can contact federal-mogul toll-free at 877-489-6659.
  this recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 69893 [USA]: In the event of an engine stall, a crash could result without warning.
  On certain heavy duty trucks equipped with 7.3l diesel engines, the camshaft position sensor located on the engine of the vehicle may function intermittently, possibly resulting in an engine stall.
  dealers will inspect the sensor and replace it with an improved camshaft position sensor free of charge. The recall began on december 29, 2007. Owners may contact ford at 1-866-436-7332.
  ford recall no. 07s57.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 72450 [USA]: If the trailer lights are not working properly, a vehicle crash can occur.
  Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. Due to incorrect wiring of the harness, the trailer lights may not operate properly.
  all of the defective tow packages are still at the distributor level and have not been sold to any consumers.
  this recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 50658 [USA]: Overheating could result in smoke or burn and an underhood fire.
  On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
  dealers will install a fused wiring harness into the speed control system free of charge. The recall began on august 7, 2006. Owners may contact ford at 1-866-436-7332. (note: also see recalls 05v017 and 05v388)
  ford recall no. 05s28.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 2480 [USA]: Loss of visibility while driving increases the risk of a crash.
  Vehicle description: passenger cars, sport utility vehicles, and light and medium duty pickup trucks. A switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, or ignition of the plastic cover material. Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. These vehicles were built at the following assembly plants: atlanta plant from 2/11/00 through 7/31/00; chicago plant from 2/14/00 through 8/4/00; kansas city plant from 2/26/00 to 9/4/00; kentucky truck plant from 2/18/00 to 8/31/00; michigan truck plant from 2/23/00 through 8/3/00; norfolk plant from 2/21/00 through 7/27/00; wayne stamping and assembly plant from 2/25/00 through 8/15/00; and wixom plant from 2/15/00 through 8/8/00.
  dealers will inspect the date code on the wiper motor. Motors built with the suspect time frame will have the wiper motor gear case cover replaced. Owner notification began august 20, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 6849 [USA]: In the event of a crash, the restraint system may not provide adequate occupant protection, increasing the risk of personal injury to the seat occupant.
  Vehicle description: passenger and sport utility vehicles, pickup trucks, and minivans. Equipped with seat belts supplied by trw. It is possible that the driver's and/or front passenger's outboard seat belt buckle may not fully latch. Ford crown victoria built at st. Thomas assembly plant from 4/17/00 - 5/29/01 mercury grand marquis built at st. Thomas assembly plant from 4/17/00 - 5/29/01. Lincoln town cars built at wixom assembly plant from 3/27/00 - 5/30/01. Lincoln navigators built at michigan truck plant from 4/11/00 - 5/31/01. Ford windstars built at oakville assembly plant from 3/23/00 - 5/30/01. Ford rangers built at twin cities plant from 3/28/00 - 5/30/01, and also at the edison plant from 3/13/00 - 5/25/01. Ford f-150 truck built at norfolk plant from 4/18/00 - 5/25/00; at ontario plant from 5/10/00 - 5/28/01; at kansas city plant from 9/11/99 - 5/25/01; and at cuautitlan plant from 5/16/00 - 6/9/01. Ford super duty f-250, f-350, f-450, and f-550 trucks built at kentucky plant from 4/17/00 - 5/27/01; and at cuautitlan plant from 5/16/00 - 6/19/01. Ford excursions built at kentucky plant from 4/17/00 - 10/2/00. Ford expeditions built at michigan truck plant from 4/11/00 - 5/31/01.
  dealers will inspect the front outboard seat belt buckles and if the buckle fails the inspection process, it will be replaced. Owner notification began july 25, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 4156 [USA]: Without proper grounding, an electrostatic discharge could result during fuel fill up, potentially leading to a fire.
  Vehicle description: f-super duty crew cab pickup trucks (f-350 short wheelbase trucks equipped with a 6 3/4' pickup box and dual rear wheels) were built after a change was implemented to delete a clamp, and later a bracket that provided a ground for the fuel filler pipe. The pickup box may not have been properly grounded.
  dealers will install a fuel filler pipe ground. Owner notification began march 26, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 3885 [USA]: In the event of a vehicle crash, the driver air bag may not deploy as intended, potentially resulting in reduced occupant protection, or a burn injury.
  Vehicle description: passenger and sport utility vehicles. The inflator canister in the driver air bag module may have an inadequate weld near the igniter.
  dealers will install a driver air bag module. Owner notification began march 19, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
  also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 2009292 [Canada]: Other
  On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: dealers will install a new switch or fused wiring harness. Note: this is an expansion of recall 2005028 (05s28) for vehicles not previously included in the campaign.

  Show Content

• Recall 2001194 [Canada]: Seats and restraints
  Certain passenger and sport utility vehicles, pickup trucks, and minivans equipped with seat belts supplied by trw. It is possible that the driver's and/or front passenger's outboard seat belt buckle may not fully latch. In the event of a crash, the restraint system may not provide adequate occupant protection, increasing the risk of personal injury to the seat occupant. Correction: dealers will inspect the front outboard seat belt buckles and if the buckle fails the inspection process, it will be replaced.

  Show Content

• Recall 2001204 [Canada]: Other
  Certain passenger cars, sport utility vehicles, and light and medium duty pickup trucks. A switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, smoke or, potentially, ignition of the plastic cover material. Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. Loss of visibility while driving increases the risk of a crash. Correction: dealers will inspect the date code on the wiper motor. Motors built with the suspect time frame will have the wiper motor gear case cover replaced.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Engine stalling investigation # EA06012

  In a december 3, 2007 letter, ford advised nhtsa that it will conduct a safety recall to replace the cam position sensor (cps) in approximately 1.2 million subject vehicles to address reports of engine stalling.A new design cps with improved performance and durability will be installed as a remedy.Owner notifications will begin in december 2007. The subject vehicles are durable, full-sized, medium duty trucks commonly used for commercial purposes, rescue/emergency response, and commercial or recreational towing.Cps failure is comparable to unexpectedly turning the key off since the signal it produces is vital to the electronic engine control system.Cps signal loss terminates fuel injection resulting in an engine stall.Once stalled, the engine may restart right away, or may restart after a delay (typically 5 to 10 minutes), or may not restart at all.In addition to exposing the driver and other motorists to crash risk due to loss of motive power or vehicle disablement, engine stalling also effects the power assisted steering and braking. Through consumer interviews, odi determined that cps failures occurred without any form of warning, at any vehicle speed (50% at highway speeds), and under any driving condition, such as accelerating.Consumers reported that about a third of the vehicles failed to restart, with another third reporting delayed restarting.Half the vehicles that did restart experienced another stall on the same or a subsequent drive cycle (before cps replacement) re-exposing those consumers to the risks associated with a stalling event.In their voq reports, half of the odi complainants described difficulty controlling the vehicle due to lose of power assist systems, especially those who were towing at the time of the incident. The one alleged injury incident occurred in an intersection when a subject vehicle stalled while turning across oncoming lanes of traffic.Although unsubstantiated, the complainant alleged an injury to a child occupant during odis interview.The other crash allegations mostly involved low speed, loss of control incidents often caused by lack of power assist; no injuries are reported in these incidents, and property damage, if any, was minimal.Consumers also reported other incidents with significant safety risks, such as disablement in a lane or on a shoulder of a high-speed roadway or interstate, or extended disablement in remote areas during severe weather conditions. The population above is fords estimate of the 1.4 million subject vehicles produced that are currently registered.The ford complaint and warranty counts noted above are current as of fords last submission dated june 21, 2007; they do not include f-450, f-550, or econoline counts as these products were not formally within scope of the investigation when failure information was requested.Warranty data analysis indicates that about half the claims involved a stall while driving event ( fords assessment) and that poor cps durability was a longstanding concern.Ford reported that the new cps design should meet or exceed their 10 year, 150k mile life expectancy design requirement.
  

  Show Content

• Spark plug ejection from cylinder head investigation # DP05005

  On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.Odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.As of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.In addition, odi is aware of only two incidents where the vehicle stalled without restart.Information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.In the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.In one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.In another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.None of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.As the petitioner noted, and odi¿s analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles.However, odi¿s analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences.None of these showed any evidence of a serious safety consequence.Given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low.In view of the foregoing, it is unlikely that nhtsa would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition.Therefore, in view of the need to allocate and prioritize nhtsa¿s limited resources to best accomplish the agency¿s safety mission, the petition is denied.
  

  Show Content

• Engine compartment fires investigation # EA05005

  Ea05-005 is closed with ford¿s actions in recalls 05v-017, 05v-388, and 06v-286, recalling approximately 6.7 million vehicles equipped with texas instruments speed control deactivation switches (scds).The brake systems in these recalled vehicles generate a vacuum that can potentially cause the scds to fail and, in certain switch installation orientations, catch fire.Ford is also including the entire population of 1998 explorers.Ford has informed odi that testing to determine the cause of failures in the 1998 explorers will continue after this investigation is closed.Odi believes that the vehicles exhibiting the factors causing scds failure described in this report correlate well with the observed failure rates on these vehicles by model and model year.The closing of this investigation does not constitute a finding by nhtsa that a safety-related defect does not exist in the non-recalled vehicles manufactured with scds that are not included in ford¿s recalls.Odi will continue to monitor the non-recalled population for incidence of engine compartment fires.The agency reserves the right to take further action if warranted by the circumstances.See attached closing report for details.
  

  Show Content

• Front seat belt buckle assembly investigation # EA05004

  During the initial recall campaign in 2001, the subject vehicles were inspected by ford dealerships using a test tool that would detect a defective front seat outboard seat belt buckle assembly.Approximately one million vehicles passed the inspection test for one or both front buckles.Subsequent to the recall service action, odi received 15 consumer reports alleging that a "passed inspection" buckle subsequently failed to latch or inadvertently unlatched during use.In addition, ford has identified 543 owner and field reports alleging buckle failure subsequent to passing the inspection test.Ford tested and examined over 100 warranty-returned buckles and found that 44% of the buckles had no problem or a condition not related to the recall inspection (non-latch related buckle damage or foreign contamination).Warranty claims were highest during the 18-month period after the start of the recall (july 2001) and have been declining during the past 24 months.Over the past 12 months, ford has received approximately 12 warranty claims per month out of a vehicle population of about one million.Complaints counts are also decreasing.During the past seven months, odi has received only two complaints. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by nhtsa that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.
  

  Show Content

• Accelerator pedal sensor (etc) investigation # EA04006

  Failure counts from odi¿s analysis are stated above; see the additional problem experience discussion in the summary report.Ford data contained duplicative reports for 4 odi complaints and 1 crash.Three crashes were allegedly due to intermittent operation of the electronic throttle control (etc) pedal, one crash occurred when an etc disabled vehicle was struck by another motorist, one report contained no detail.The injuries were minor.An issue involving fixed etc pedals was investigated also, however failure reports and populations are not shown above; see summary report for detail.Although ford has used etc based throttle control systems for many years, the pap feature was new for my 2002.The subject etc sensor produces two output signals which the engine management system (ems) utilizes to:1) determine fueling requirements; and 2) perform sensor diagnostics.One signal is linearly proportional to throttle pedal position; the second is a digital signal.By design, the detection of a sensor fault results in the engine returning to (or remaining at) the idle state.Ford identified a defect in the pap etc sensor which prematurely affected an output signal; the migration of internal sensor lubricant caused a loss of proportional signal.The failure mechanism is progressive and as the sensor deteriorates, the ems will detect a fault, store a fault code, illuminate a warning lamp, and the engine may remain at/return to idle.In the early stages, normal operation can be regained by pedal re-application.The failure progresses until the engine remains at idle.The engine does not stall, power assisted steering and braking systems are unaffected. Ford corrected the etc sensor defect and conducted field service action (fsa) 03b03 to replace etc pedals, addressing 50% of vehicles.At agency request to improve completion rate, ford extended fsa 03b03 for 6 months.Based on odis analysis of available data, fords action has appropriately resolved the etc sensor proplem in the subject vehicles.The closing of the investigation does not constitute a finding by nhtsa that a safety-related defect does not exist, and should not be considered as having any precedential value or effect binding the agency in future defect investigations. See the attached summary report for additional information.
  

  Show Content

• Rapid tire deflation investigation # EA02018

  This investigation was opened on certain ford pickup trucks and vans to evaluate the effects of a valve stem ejection (with rapid air loss) and a slow leaking valve stem on vehicle handing.During the investigation, odi evaluated over 1,100 complaints and warranty claims, conducted vehicle dynamic testing on a subject vehicle with the failure mode replicated, interviewed owners, and examined complaint vehicles in the field.The results of the test program indicates the effect of a valve stem ejection on these vehicles is easily controlled. Further, with a population of almost 900,000 vehicles, having two to four years of exposure, odi is aware of only 3 minor crashes and is unaware of any injuries.The small number of crashes relative to the large population of vehicles is consistent with the testing which was performed. Therefore, this investigation is closed.See the attached report for full technical details.
  

  Show Content

• Sector shaft fractures investigation # EA01009

  This ea was opened based on a response received from ford motor company to an information request (ir) submitted during sq00-018.Ford stated in an internal service message that it had changed the steering gear sector shafts and pitman arms installed 1999 model year f-series super duty vehicles on march 22, 1999.Ford stated that these design changes were implemented to make improvements in vehicle steering and handling, and that virtually all of the reported fractured sector shafts were the result of extraordinary, possibly multiple, impacts.An engineering analysis closing report is attached.
  

  Show Content

Front seat belt unbuckles itself. Happens mostly in motion. Truck does not show recalls open.

Front seat belt unbuckles itself. Happens mostly in motion. Truck does not show recalls open.

Tl* the contact owned a 2001 ford f-350. While the vehicle was parked in a parking lot without warning the vehicle caught fired. The contact stated that a coworker informed him that the flames were coming from underneath his vehicle. The contact attempted to extinguish the fire but was unable. The fire department was contacted and extinguished the flames. A police report was filed. No injuries were sustained. State farm was contacted towed the vehicle to a tow lot and deemed the vehicle a total loss. The contact mentioned that the brake fluid light was illuminated and brake fluid was added to the vehicle. The contact mentioned that prior to the fire he noticed that fluid was leaking underneath the vehicle. The contact referenced nhtsa campaign number: 09v399000 (vehicle speed control) as a cause of the failure as vin was included and recall was not serviced. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

Tl* the contact owned a 2001 ford f-350. While the vehicle was parked in a parking lot without warning the vehicle caught fired. The contact stated that a coworker informed him that the flames were coming from underneath his vehicle. The contact attempted to extinguish the fire but was unable. The fire department was contacted and extinguished the flames. A police report was filed. No injuries were sustained. State farm was contacted towed the vehicle to a tow lot and deemed the vehicle a total loss. The contact mentioned that the brake fluid light was illuminated and brake fluid was added to the vehicle. The contact mentioned that prior to the fire he noticed that fluid was leaking underneath the vehicle. The contact referenced nhtsa campaign number: 09v399000 (vehicle speed control) as a cause of the failure as vin was included and recall was not serviced. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

Windows ,wipers and radio come on about a minute latter after starting the truck.

Windows ,wipers and radio come on about a minute latter after starting the truck.

Seat belt does not retract and is faulty set feels loose from cab.

Seat belt does not retract and is faulty set feels loose from cab.

Tl* the contact owns a 2001 ford f-350 super duty. While reversing the vehicle, the contact heard an abnormal noise coming from the rear of the vehicle. The contact inspected the vehicle and found that the fuel tank strap was fractured. O'brien ford (located at 720 mt eden rd, shelbyville, ky 40065) and the manufacturer were notified of the failure. The vehicle was not repaired. The approximate failure mileage was 48,598. The vin was not available. *tt consumer stated truck was taken to the repair shop.*jb

Common OBD-II Error Codes

• B1035 [1] B1035
• P0123 [1] Throttle Position Sensor/Switch A Circuit High Input
• P0603 [1] Internal Control Module Keep Alive Memory (KAM) Error
• P0605 [1] Internal Control Module Read Only Memory (ROM) Error
• B1871 [1] Passenger Air Bag Disable Module Fault
• B1935 [1] Air Bag Passenger Inflator Circuit Resistance Low on Squib