2023 Toyota Tacoma 4WDToyota Tacoma 4wd 2023

Complaint Information: Recalls, Service Bulletins, OBD II Codes

NHTSA Mandated Recalls

  • Recall 250977 [USA]: Axle shaft separation can cause a loss of vehicle stability and brake performance, increasing the risk of a crash.
    Toyota motor engineering & manufacturer (toyota) is recalling certain 2022-2023 tacoma vehicles. The axle shaft sub-assembly may separate from the axle housing due to debris causing improperly secured fasteners.
    dealers will inspect the rear axle assembly, tighten the axle retaining nuts as necessary, and repair or replace any damaged components, free of charge. Owner notification letters were mailed april 17, 2024. Owners may contact toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24tb05 and 24ta05.
    owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.

  • Recall 248877 [USA]: A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
    Toyota motor engineering & manufacturing (toyota) is recalling certain 2023 corolla, corolla cross, corolla cross hybrid, highlander, highlander hybrid, tacoma, 2023 lexus rx350, rx350 hybrid, rx500 hybrid, 2023-2024 lexus nx250, nx350, and nx350 hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 208, "occupant crash protection."
    dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed september 8, 2023. Owners may contact toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23ta08. Lexus' number for this recall is 23la02.
    owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.

  • Recall 206402 [USA]: An insufficient weld may prevent the child seat from being anchored properly, allowing the seat to move during a sudden stop or crash, increasing the risk of injury.
    Toyota motor engineering & manufacturing (toyota) is recalling certain 2022-2023 tacoma vehicles. One or more of the individual welds in the upper child seat anchors may be insufficient. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 225, "child restraint anchorage system."
    dealers will inspect the upper child seat anchors and reweld the child seat anchors, as necessary. Owner notification letters are expected to be mailed september 02, 2022. Owners may contact toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 22tb09/ 22ta09.
    owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

  • T-PANT-2024-004- - ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION: This is to advise of various price adjustments that will affect toyota genuine motor oil and long life coolant, effective march 1, 2024. These products are ordered through the toyota complete maintenance care (tcmc) website.
  • TSB002620 - FORWARD COLLISION AVOIDANCE: Tsb: all 2020 ? 2023 model year 4runner, 2018 ? 2022 model year sequoia, 2018 ? 2023 model year tacoma, and 2018 ? 2021 model year tundra vehicles are equipped with pre-collision system (pcs) and dynamic radar cruise control (drcc) as part
  • TSB003220 - EQUIPMENT: Tsb: replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) (see figure 1) for most 1979 ? 2023 model year vehicles may be available provided the re
  • TTT073723 - UNKNOWN OR OTHER: Tt: a very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. These resources, in conjunction with the repair manual, are for dealership personnel to assis
  • TSB011219 - POWER TRAIN: Tsb: some 2005 ? 2023 model year tacoma vehicles equipped with a manual transmission may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released.
  • T-SB-0045-23 - BACK OVER PREVENTION: Tsb: some 2019 ? 2023 model year tacoma double cab vehicles may exhibit a whine noise from the rear of the vehicle. This condition may occur while driving around 50 mph (80 kph) at constant speed, slight acceleration, or slight deceleration
  • T-SB-0042-23 - WHEELS: Tsb: some 2023 ? 2024 model year toyota vehicles use hub bolts in place of studs/nuts to fasten the wheels to the vehicle. If non-compatible wheels or hub bolts/nuts are installed, there is increased risk that the wheel(s) could come off re
  • T-SB-0057-18 - EQUIPMENT: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to
  • Accessory - ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS:ACCESORY POWER OUTLET/JACK/PORT/USB/SAE/CIGARETTE LIGHTER: This toyota genuine power port provides additional capability to your phone or tablet, so your devices always have power/charge. Includes two fast charging smart usb connectors with blue led power status light. Applicable to my21, my22, and
  • TTT072023 - EQUIPMENT: Tt: some 2020-2023 manual transmission tacoma vehicles may exhibit an abnormal clutch pedal creak/squeak sound during operation.
  • T-SB-0033-19 Rev - VEHICLE SPEED CONTROL: Tsb: some 2016 ? 2023 model year tacoma vehicles may exhibit a condition where snow or ice builds up between the right or left front door and front fender, preventing the front door from fully opening. Follow the repair procedure in this bu
  • T-TT-0721-23 Rev - ELECTRICAL SYSTEM: Tt: electronic parts catalog (epc) does not include notes requiring ordering the protector heater seals when replacing the air conditioning evaporator core (88511- #####) or radiator heater unit subassembly (87107- #####
  • T-TT-0721-23 - ELECTRICAL SYSTEM: Tt: electronic parts catalog (epc) does not include notes requiring ordering the protector heater seals when replacing the air conditioning evaporator core (87511- #####) or radiator heater unit sub-assembly (87107- #####).
  • T-TT-0720-23 Rev - EQUIPMENT: Tt: some 2020-2023 manual transmission tacoma vehicles may exhibit an abnormal clutch pedal creak/squeak sound during operation.
  • T-SB-0033-19 Rev - VEHICLE SPEED CONTROL: Tsb: some 2016 ? 2023 model year tacoma vehicles may exhibit a condition where snow or ice builds up between the right or left front door and front fender, preventing the front door from fully opening. Follow the repair procedure in this bu
  • T-SB-0115-22 - ENGINE AND ENGINE COOLING: Tsb: some 2019 ? 2022 model year avalon, 2018 ? 2023 model year camry, 2017 ? 2022 model year highlander, 2017 ? 2020 model year sienna, and 2016 ? 2023 model year tacoma vehicles equipped with a 2gr-fks engine may exhibit a knocking noise
  • T-SB-0036-22 Rev - EQUIPMENT: Tsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
  • T-SB-0029-22 Rev - AIR BAGS: Tsb: 2023 model year toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During
  • T-SB-0004-22 Rev - VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM: Tsb: some 2016 ? 2023 model year tacoma vehicles may exhibit what customers describe as a 1 ? 3-second whistle noise from the hvac system when the air conditioning system is on. The whistle noise may occur as the compressor cycles on and of
  • T-SB-0031-22 Obs - COMMUNICATION: Obsolete notice november 28, 2022: this bulletin is now obsolete. Please see t-sb-0105-22
  • T-SB-0032-22 Obs - COMMUNICATION: Obsolete notice november 28, 2022: this bulletin is now obsolete. Please see t-sb-0104-22.
  • T-SB-0105-22 - TRAILER HITCHES: Tsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires
  • T-SB-0104-22 - EQUIPMENT: Tsb: a battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. Because of these factors, battery inspect
  • T-SB-0124-20 Rev - POWER TRAIN: Tsb: some 2016 ? 2023 model year tacoma vehicles equipped with an automatic transmission (6at) may exhibit a vibration under deceleration (coasting or braking) typically between 30 ? 10 mph. This vibration is felt in the seat, floorboard, a
  • T-SB-0032-22 Rev - EQUIPMENT: Tsb: a battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. Because of these factors, battery inspect
  • T-SB-0075-22 - ELECTRICAL SYSTEM: Tsb: pre-delivery service (pds) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing pds: ?Careful inspection for paint chips/scratches and body
  • T-SB-0036-22 Rev - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL: Tsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
  • T-SB-0029-22 Rev - EQUIPMENT: Tsb: 2023 model year toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During
  • T-SB-0031-22 Rev - WHEELS: Tsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires
  • TTT069522 - COMMUNICATION:MANUFACTURER TELEMATICS: Tt: to improve customer support of telematics connected services features, additional resources have been provided in the service lane - knowledge center.
  • T-SB-0032-22 Rev - EQUIPMENT: Tsb: a battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. Because of these factors, battery inspect
  • T-SB-0031-22 Rev - WHEELS: Tsb: during the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires
  • Toyota Safety Re - EQUIPMENT: Toyota safety recall and service campaign - technician certification requirements 4.14.2022
  • T-SB-0036-22 - EQUIPMENT: Tsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond
  • T-SB-0032-22 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Tsb: a battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. Because of these factors, battery inspect
  • T-SB-0029-22 - AIR BAGS: Tsb: 2023 model year toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During

© dot.report 2024

Use of this information constitutes acceptance for use in an AS IS condition. There are NO warranties, implied or otherwise, with regard to this information or its use. Any use of this information is at the user's risk. It is the responsibility of user to evaluate the accuracy, completeness or usefulness of any information, opinion, advice or other content. EACH USER WILL BE SOLELY RESPONSIBLE FOR ANY consequences of his or her direct or indirect use of this web site. ALL WARRANTIES OF ANY KIND ARE EXPRESSLY DISCLAIMED. This site will NOT BE LIABLE FOR ANY DIRECT, INDIRECT or any other kind of loss.