Volvo Vhd 2024
Complaint Information: Recalls, Service Bulletins, OBD II Codes
Recall 231995 [USA]: An overloaded vehicle can increase the risk of a crash.
Volvo trucks north america (volvo trucks) is recalling certain 2024 vn and vhd vehicles equipped with size 295/75 or 385/65 continental tires on the front axle. The gross axle weight rating (gawr) listed on the vehicle certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of 49 cfr part 567, "certification."
dealers will remove and replace the label, free of charge. Owner notification letters were mailed december 13, 2024. Owners may contact volvo trucks customer service at 1-800-528-6586. Volvo truck's number for this recall is rvxx2314.
owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.Recall 231914 [USA]: The attachment points may fail, allowing the bench seat to shift and increasing the risk of injury during a crash.
Volvo trucks north america (volvo trucks) is recalling certain 2019-2024 vn and vhd vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard numbers 207, "seating systems" and 210, "seatbelt assembly anchorage."
dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed february 29, 2024. Owners may contact volvo trucks customer service at 1-800-528-6586. Volvo trucks number for this recall is rvxx2312.
owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.Recall 237130 [USA]: A loss of steering control increases the risk of a crash.
Volvo trucks north america (volvo trucks) is recalling certain 2024 vnl, vhd, and vnr trucks. The fastener that connects two steering components, the pitman arm and draglink, may be loose, which can cause the connection to fail and result in a loss of steering control.
dealers will inspect and tighten the castle nuts and install new cotter pins, free of charge. Owner notification letters are expected to be mailed december 4, 2023. Owners may contact volvo trucks' customer service at 1-800-528-6586. Volvo trucks' number for this recall is rvxx2311.
owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.Recall 247505 [USA]: Inoperative windshield wipers can reduce visibility, increasing the risk of a crash.
Volvo trucks north america (volvo trucks) is recalling certain 2022-2024 vnr, vnl, vhd, and vah trucks. The windshield wiper motor gears may wear prematurely, causing the motor to fail.
dealers will replace the windshield wiper motor assembly, free of charge. Owner notification letters were mailed november 1, 2023. Owners may contact volvo trucks customer service at 1-800-528-6586. Volvo trucks number for this recall is rvxx2309.
owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.Recall 243707 [USA]: Loose steering gear fasteners may result in a loss of vehicle control, increasing the risk of a crash.
Volvo trucks north america (volvo trucks) is recalling certain 2023-2024 vn, vhd, and vah trucks. The steering gear fasteners may not be properly tightened.
dealers will tighten the steering gear fasteners, free of charge. Owner notification letters are expected to be mailed august 18, 2023. Owners may contact volvo trucks' customer service at 1-800-528-6586. Volvo trucks' number for this recall is rvxx2307.
owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.Recall 233856 [USA]: An air bag that does not deploy, increases the risk of an injury.
Volvo trucks north america (volvo truck) is recalling certain 2022-2024 vnl and vhd vehicles equipped with rolltek driver seats. A missing circuit will prevent the side air bag from deploying during a crash.
dealers will connect a jumper harness between the seat and main cab harness, free of charge. Owner notification letters are expected to be mailed august 4, 2023. Owners may contact volvo trucks' customer service at 1-800-528-6586. Volvo trucks' number for this recall is rvxx2305.
owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.Recall 249803 [USA]: A detached hub cover can create a road hazard, increasing the risk of a crash.
Volvo trucks north america (volvo trucks) is recalling certain 2024 vnr, vnl, and vhd vehicles. The hub covers do not properly fit on the hub and can detach from the vehicle.
dealers will remove the hub covers, free of charge. Owner notification letters were mailed march 31, 2023. Owners may contact volvo trucks' customer service at 1-800-528-6586. Volvo trucks' number for this recall is rvxx2302.
owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Nhtsa.Gov.
To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.
Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.
- CBR-2361 202404 - ENGINE AND ENGINE COOLING: Cbr: volvo chassis - debris in 13l cooling systems filled with extended life(vcs2)
- CBR-2360 202404 - SEAT BELTS: Cbr: chassis equipped with vecu5 active datalink/communication faults for multiple modules; abs and srs communication faults.
- CBR-2258 202404 - POWER TRAIN: Cbr: diagnostic trouble code (dtc) P107471 -amt-f
- S3937 202404 - ELECTRICAL SYSTEM: Service campaign: ota premature oil service pop-up
- S3903 202403 - ENGINE AND ENGINE COOLING: Service campaign: volvo trucks has determined that certain vah, vhd, and vn model trucks built with a d13 engine could experience a reduced clamping load on the turbocharger mounting hardware causing the hardware to become loose. On affecte
- CBR-2356 202403 - ELECTRICAL SYSTEM: Cbr: after cluster replacement and programming, the driver information display (did) may not function as designed.
- CBR-2139 202403 - ENGINE AND ENGINE COOLING: Cbr: vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil. It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head.
- CBR-408 202403 - EQUIPMENT ADAPTIVE/MOBILITY: Cbr: on a volvo chassis - us16 - with the bendix lane departure warning system ( ldw )the alarm would not cancel once the turn signals were activated.
- KC-2350 - ELECTRICAL SYSTEM: Cbr - telematics gateway (tgw) connect ability issues.
- KC-2347 - ELECTRICAL SYSTEM: Cbr - active "set park brake" message on drivers information display (did)
- KC-202 - POWER TRAIN: Cbr - automated manual transmission ( amt ) flywheel pilot bearing wear on input shaft.
- KC-2014 - SUSPENSION: Cbr - driveline noise, suspension ride height too high, suspension will not exhaust - chassis built 2016w01 and newer
- CBR-2333 202401 - ELECTRICAL SYSTEM: Cbr: tgw will not connect after sim card replacement
- CBR-2286 202401 - ENGINE AND ENGINE COOLING: Cbr: diagnostic trouble code (dtc) P113600 nox sensor 1/2 correlation calibration error bank 1 - model year 2024.
- S3856 202401 - STRUCTURE: Service campaign: vin label engine serial number
- CBR-2326 202312 - ENGINE AND ENGINE COOLING: Cbr: engine control module (ems) software (msw) information october 2023 improvement list (change log) - us20-obd23 emissions.
- CBR-2320 202312 - VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM: Cbr: 11l engine - air conditioner (a/c) line damaged at bracket - model year 2007 to present.
- PSM23vna73 - POWER TRAIN: Parts sales and marketing bulletin: volvo trucks is excited to announce an additional year warranty program on volvo reman amt i-shift complete transmissions. This extended warranty of 3 years or 350,000 miles on the transmission will be ap
- CBR-399 202310 - ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL: Vehicle overspeed warning comes active at a lower speed than expected; vehicle overspeed warning in driver information display (did) - model year 2018 and newer with new style instrument cluster.
- CBR-206 202310 - ELECTRICAL SYSTEM: Cbr: vehicle speed factor (k-factor) programming - speed factor value incorrect when calculated in premium tech tool (ptt); speedometer reading incorrectly following a change to vehicle speed factor - us17+obd16 and newer emissions, common
- V-258-002 202309 - ENGINE AND ENGINE COOLING: Tsb: aftertreatment diesel exhaust fluid (def) tank, level sensor, replacement
- V-258-001 202309 - ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:SUMP/TANK:DRAIN PLUG: Tsb: aftertreatment diesel exhaust fluid (def) tank, level sensor, replacement
- CBR-2297 202309 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Cbr: volvo chassis - nonfunctioning 12vaccessory power supply - model year(my) 2017 to present
- CBR-2120 202308 - ELECTRICAL SYSTEM: Cbr: volvo vhd & vn models - vehicle wil not start, pto active message displayed in cluster, pto light on when pto switch is turned off
- CBR-2301 202307 - ELECTRICAL SYSTEM: Cbr: volvo chassis - instrument cluster (ic) immobilizer pass code not working
- CBR-2298 202307 - ENGINE AND ENGINE COOLING: Cbr: volvo def dosing valve diagnostic trouble codes (dtc) P202D00, P208E00, P103B00 - us10+obd13 and newer emissions
- CBR-2297 202307 - ELECTRICAL SYSTEM: Cbr: volvo chassis - nonfunctioning 12v accessory power supply - model year (my) 2017 to present
- CBR-2112 202307 - ELECTRICAL SYSTEM: Cbr: programming failure - chassis with cummins engine and an allison transmission
- KC-2094 Rev 3 - ELECTRICAL SYSTEM: Infotainment system - volume drop during a phone call, phone connected via bluetooth
- KC-2286 - ENGINE AND ENGINE COOLING: Cbr - diagnostic trouble code (dtc) P113600 nox sensor 1/2 correlation calibration error bank 1 - model year 2024
- KC-2279 - POWER TRAIN: Cbr - ilok fastener torque
- KC-2043 Rev 4 - ELECTRICAL SYSTEM: Cbr - engine control module (ems) software (msw) information - improvement list, through june 2023 - us21+obd2020 emissions
- KC-2289 - ENGINE AND ENGINE COOLING: Cbr - diagnostic trouble code (dtc) P103200: particulate matter sensor removed from exhaust - us21+obd22 emissions
- KC-2292 - SUSPENSION: Cbr - vehicles equipped with chalmers suspension - frame bracket hardware loose or interfering
- KC-2286 - ENGINE AND ENGINE COOLING: Cbr - diagnostic trouble code (dtc) P113600 nox sensor 1/2 correlation calibration error bank 1 - model year 2024
- KC-2194 - ENGINE AND ENGINE COOLING: Cbr - volvo selective catalytic reduction (scr) muffler troubleshooting guide - us10+obd13 and newer emissions
- SLV23-005 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL: Service literature published and released in may, 2023
- KC-2050 - ENGINE AND ENGINE COOLING: Cbr: diagnostic trouble code (dtc) P225C00 : nox1 sensor stuck high - us17+obd2019 and newer emissions
- KC-331-Ver6 - FUEL SYSTEM, DIESEL: Cbr: model year 2017 to current - fuel filter change ( primary and secondary ) for the em - usa17 emission engines
- KC-503-Ver3 - POWER TRAIN: Cbr: automated manual transmission ( amt ) - transmission electronic control unit ( tecu ) mid130 psid 29 fmi 7 / P10AE81 fault codes being generated
- KC-2229-Ver2 - POWER TRAIN: Cbr: automated manual transmission (amt) transmission kickdown mode
- KC-2226-Ver3 - ELECTRICAL SYSTEM: Cbr: diagnostic trouble code (dtc) U1FFF68 - factory mode active, event information - model year (my) 2023
- KC-474-Ver5 - POWER TRAIN: Cbr: diagnostic trouble code (dtc) P215A-64, fault code spn 84 fmi 19
- V-773-005a - WHEELS: Hub cap, leaking
- V-366-008 - FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL: Tsb: adaptive cruise control, deactivation
- KC-2272 - FUEL SYSTEM, OTHER:FUEL FILTER: Cbr: diagnostic trouble code (dtc) P008A - low pressure fuel system pressure - too low
- KC-2269 - ENGINE AND ENGINE COOLING: Cbr: 11l engines, non-common rail - air compressor coolant pipe, parts substitution - us14+obd13 to us14+obd16
- KC-2274 - SUSPENSION: Cbr: volvo - pre-delivery inspection (pdi) torque values. This solution provides the torque specs needed to complete a pre- delivery inspection (pdi).
- KC-2265 - ENGINE AND ENGINE COOLING: Cbr: volvo vhd models - allison reduced engine load at a stop (rels) diagnostic trouble code P071A or P07CE - non-split/drop box pto. Vhd chassis may experience diagnostic trouble code P071A or P07CE along with symptoms of no reduced engin
- KC-2260 - ENGINE AND ENGINE COOLING: Cbr: volvo chassis - timing gear plate repair. This solution provides supplementary information to be used when installing a timing gear plate with integrated seal.
- KC-2191 - ENGINE AND ENGINE COOLING: Cbr: volvo nox sensor troubleshooting guide - us10+obd13 and newer emissions. The primary failure mode the nox sensors is internal failure, which will generate a sensor specific fault code.
- KC-2033 - ELECTRICAL SYSTEM: Cbr: volvo on-highway vehicles - bendix abs fault spn 807 fmi 13 blink code 19-4. The new central pressure control (cpc) system has changed the way that the abs chuff test is performed.
- KC-776 - SERVICE BRAKES, AIR: Volvo chassis - electronically controlled air dryer system (ecads) building too much air pressure; pressure relief valve opening
OBD-II Error Codes
Common OBD Error codes specific to this vehicle.
- P1074 [1] P1074
- P1136 [3] Lack Of HO2S Switch - Sensor Indicates Lean
- P202D [1] Reductant Leakage
- P208E [1] Reductant Injection Valve Stuck Closed Bank 1 Unit 1
- P103B [1] P103B
- P1032 [1] P1032
- P225C [1] ISO/SAE Reserved
- P10AE [1] P10AE
- U1FFF [1] U1FFF
- P215A [1] Vehicle Speed - Wheel Speed Correlation
- P008A [1] Low Pressure Fuel System Pressure - Too Low
- P071A [1] Transmission Mode Switch "A" Circuit
- P07CE [1] P07CE
| Crash | Fire | Towed | Injured | Deaths | Failure Date |
|---|