Toyota T100 1998

• Recall 61655 [USA]: If the vehicle is continued to be operated in this condition, the relay rod may fracture, increasing the risk of a crash.
  On certain pickup trucks and sport utility vehicles, if the steering wheel is repeatedly turned under certain conditions where high steering effort and power assist are required, for instance, when fully turning the wheel while the vehicle is stopped, a fatigue crack may develop in the steering relay rod.
  dealers will replace the steering relay rod. The recall began october 5, 2005. Owners may contact toyota at 1-800-331-4331.
  toyota recall no. Ssc 50n.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

• Recall 2005261 [Canada]: Steering
  On certain vehicles, if the steering wheel is repeatedly turned under conditions where high steering effort and power assist are required, for instance, when fully turning the wheel while the vehicle is stopped, a fatigue crack may develop in the steering relay rod. Correction: dealers will replace the steering relay rod.

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Clutch pedal bracket/firewall investigation as of 20020401

  
  

  Show Content

Common OBD Error codes specific to this vehicle.

• P0335 [1] Crankshaft Position Sensor A Circuit Malfunction

Owned since 2003, the truck has only 140,000 miles, but my mechanic advises that frame is badly rusted and is unsafe to drive. I've learned this is a common issue and that toyota has an active recall. Rear bumper has also rusted through. I need advice on how to proceed. Vehicle is parked at my residence.

Tl* the contact owns a 1998 toyota t100. The contact stated that the entire frame of the vehicle had severe corrosion. The contact observed brake fluid leaking from the front of the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 99,300.

The truck has 98,000 miles. The frame is rusted through on the right side behind the front wheel and in front of the back wheel. The truck will not pass pa state inspection.

The body to frame mount has rusted away breaking three parts of the frame. The top of the frame is the only part holding the truck together, causing a safety hazard which resulted in not being able to pass state inspection.

I have a 1998 toyota t100 with 143k miles on it. The frame is now broke under the bed near the front leaf spring shackle, beside a bed mount. The other side is also cracked bad and is about to break. I also noticed the cross-member that the carrier bearing attaches too is also cracked on one side and all but cracked on the other side. I called toyota because i know they are doing the tacomas around the same year as well as the tundras. Toyota said that there is no recall or anything they can do. I know this is an issue with several other t100s and am very upset that they wont do anything with the t100s.

Tl* the contact owns a 1998 toyota t100. The contact stated that the tire specialist advised him that the driver's side rear frame springs mount were severely corroded and exhibited holes. The tire specialist advised that it was unsafe to drive the vehicle. The tire was replaced. The manufacturer was made aware of the failure. The failure and the current mileage was 137,925.

This 1998 t100 was an awesome truck, but like all toyotas the frame is rotted through. The steel that is used on these is complete junk.. This is where the american company's have it. I like the questions to answer, was there a crash? Not yet, was there an injury or fatality? Will that make toyota do a recall? I think not!! The frame on all these t100 should be taken care of by toyota.. It just seems like toyota just doesn't care anymore. Toyota should get a huge fine for knowing this problem, and doing nothing about it... Lets see how many people have to die before something is done.. *tr

The frame has extensive rust/damage. *tr

When backing out of a parking space lower left a-arm broke (rust) and left front tire collapsed. Have learned that toyota tacoma trucks made in '90s had defective frames and there was a buy back. Shop tells me my frame is bad. Truck has only 69k miles on it. Truck is practically the same as a tacoma, is toyota doing anything for t-100s? Dealer said no? *js

1998 toyota t100 rusted frame issues. Filed a complaint to toyota, had frame inspected by gene reed and failed. But corporate refused to address issue even though they did for the sister trucks with similar parts the tacoma and tundra. Dealer said vehicle is not safe, told the corporate office it was not safe and toyota even refused to investigate saying they were not addressing any issues on the sister truck.

Clutch pedal bracket on toyota t 100 went through fire wall while driving. Could not get truck in our out of gear. Looked on net and found many have had this same problem. Contacted dealer no recall and no help with pricing to repair truck. Safety concern about not being able to get vehicle out of gear! *tr

Tl*the contact owns a 1998 toyota t100. The contact stated that the seat belt locks, but becomes loose when driving. The seat belt fails to retract when the failure occurs, but the seat belt warning indicator light illuminates. The current mileage is 105,000 and failure mileage was 100,000.

Wires to fan connector melted the insulation just short of the connector and shorted out. Pictures of failed wiring are available. *tr

Dt*: the contact stated while driving 10 mph, the drag link broke on the steering. The vehicle was pulled to the side of the road. It was towed to an independent repair shop for steering repairs. Updated 04/06/06.

The driver's seat belt latch was defective. The buckle will not latch. The consumer stated it was a state law that the seat belts were to be worn while driving. *ak the seat belt would not retract. *sc *jb

Calipers on the brakes of toyota t100 pickup trucks lockup causing irrepairable damage to brake pads and rotors. This necessitates replacement of the brake assembly and rotor-hub parts and significant labor cost ($931). This has happened twice in less than 18 months on my 1998 t100. When i prompted the dealership to pay for materials the second time, they told me it happens all the time with t100, tundra and tacomas. They said there was nothing i could do to prevent or aviod the situation and they will not absorb the material costs (approx $450) for the second repair because it was a "mechanical failure" of the calipers. When i suggested to them the fact its a known issue among toyota dealership repair shops should make it a recall issue. It was their equipemnt, installed by them that was failing. My request for discount in the second repair was dismissed. I suspect the problem is continuing, based on an intermitten noise and hesitation in the front right of the truck now and again and excessive brake pad soot on the wheel rims. Toyota needs to address this situation and owners should not be expected to fork out $931 every year to maintain brakes. I am not looking forward to a third repair of this type.*ak

On july 28, 2004, my 1998 toyota t-100 4x4 suffered a complete lack of steering control as i started down my driveway. The cause was a steering rod relay that broke in two. I have the failed part. It appears to have been either a two-part failure or a flaw in the original casting. One-half of a cross-section through the break is bright gray steel with the rough surface characteristic of fatigue failures, the other half is comparatively smooth and the same rust-color as the outside of the part. My truck has never been used for rock-climbing, nor has it been rammed into a solid obstacle such as a curb or large pothole. The only trauma it has been subject to is low-speed maneuvering in heavy snow and ice. Although the failure did not cause death or damage, if it had occured a few minutes later, i would have been doing 60 mph on the highway. While i don't think toyota owes me anything on a six-year-old vehicle, i am worried that this flaw might represent a bad batch of steering rod relays. If so, then there are other t-100s out there that could kill their owners.*ak

I have a 1998 toyota t100 4x4 pick up truck. The wiring harness that connects to the blower motor shorted out about two years ago. I had to go to the junkyard and take one out of another model toyota car to fix it. Since then the wire has shorted out twice more. Basically i believe that the blower is creating too many volts that causes the wires to overheat and melt together. There was no fire but it does smoke when it shorts out. I noticed that toyota has not issued a recall and this could cause a fire. *nm

We have a toyota t-100 sr 5, extend cab 4x4 truck. We have been having problems with the driver's side seat belt. The belt will not lock in place and is loose. I have asked at dealers and i am told they are not aware of any safety warranty. We had a vehicle that was less than 10 years old and it had a seat belt problem. The dealer was required by law to replace the seat belt. I cannot find any information on this issue. "safety devices are under warranty for 10 years (by law)." i need your assistance on this matter. Thank you. Have a good day. [xxx] note: the address is still a toyota dealer, but is no longer bales toyota. I do not know the new name.*ak odi spoke to consumer and the retractor will always lock when under heavy braking and may not lock when the webbing is suddenly tugged. Also at times the webbing will not retract. Intermittent issue. Cw information redacted pursuant to the freedom of information act (foia), 5 u.S.C. 552(b)(6). *tr

While driving about 55 mph, vehicle will start vibrating at the front. Had taken vehicle to dealer and they said that vibration was coming from defective wheels that had to be replaced to correct the problem. Three of the wheels were warped, a factory defect. *jg *ak

The left rear axle was spraying oil onto the left rear wheel well and brake assembly while driving. Vehicle was towed to the dealer, who resealed the axle. Within 100 miles the problem recurred.*ak

Rear tire blew out. (dunlop 265/70r16 1115). Yh

Vehicle vibrates violently while driving between 35 and 60 mph.

Twice i have had to replace the rear axel seals due to them leaking. When i had the rear axel seals replaced i have also had to replace the rear brakes due to the oil getting on the brakes. I discovered where the seals were all but gone when i had my tires replaced. I was told that i did not have any rear brakes due to so much oil leaking on the brakes. I live in the mountains of nc and i would have lost my brakes if i was hauling anything down the mountains. *nm

The seat belt failed to restrain the consumer when the brakes were applied. *jb