Toyota Tundra 2002

• Recall 67003 [USA]: Separation of the spare tire and diminished brake capacity could increase the risk of a crash.
  Toyota is recalling model year 2000-2003 tundra vehicles originally sold in or currently registered in the following states: connecticut, delaware, illinois, indiana, kentucky, maine, maryland, massachusetts, michigan, minnesota, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia, west virginia, wisconsin and the district of columbia. Excessive corrosion of the rear cross member may cause the separation of the spare tire stowed under the truck bed which would present a road hazard that could cause a crash. Also, corrosion of the rear cross member could affect the rear brake lines and the proportioning valve resulting in diminished braking capability.
  toyota is asking owners of the affected vehicles to remove the spare tire from under the vehicle until a remedy can be obtained. Dealers will inspect the rear cross member and related components, including the brake lines, and replace them if necessary. If the cross member does not need to be replaced, it will be sprayed with a corrosion protection compound. These services will be performed free of charge, however multiple visits to the dealer may be required. The safety recall is expected to begin on or about april 30, 2010. Owner may contact toyota at 1-800-331-4331.
  toyota safety recall no. Ssc90/90m.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 85893 [USA]: Decreased lighting visibility may result in a vehicle crash.
  Dope, inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
  dope, inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on july 28, 2009. Owners may contact dope, inc. At 1-626-272-1798.
  this recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.In order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.The list can be found under "document search" located at the bottom of your screen. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 36925 [USA]: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
  Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
  aj motorsport will notify owners and offer reimbursement for the lamps. The recall began on july 31, 2006. Owners may contact aj motorsport at 626-618-2026.
  this recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.For more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 61074 [USA]: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
  Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
  pro-a motors will notify owners and offer to repurchase the lamps. The recall began on april 3, 2006. Owners may contact pro-a motors at 323-838-2988.
  this recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.For more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.Safercar.Gov.

  Show Content

• Recall 41208 [USA]: The lower ball joint may separate from the knuckle causing loss of steering control and a crash could occur.
  On certain sport utility vehicles, due to a manufacturing issue in the front suspension lower ball joint, there is a possibility that the surface of the ball of the joint may have been scratched. The ball joint may eventually experience excessive wear and looseness, resulting in increased steering effort.
  dealers will replace the front suspension lower ball joints free of charge. The recall began on july 5, 2005. Owners may contact toyota at 1-800-331-4331.
  toyota recall no. 50j.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

  Show Content

• Recall 2209 [USA]: Different operating characteristics can be experienced when the spare tire is installed on the vehicle.
  On certain 4x2 vehicles equipped with an alloy wheel tire upgrade (options wm4, wm8, zl1-zl4, dh4, or dh5) installed by the processing centers in jacksonville, florida or commerce, georgia, a label identifying the spare tire as a temporary use spare tire was not installed. The upgrade includes 4 larger size tires with alloy wheels. The original spare tire/steel wheel is not part of the upgrade and was not changed.
  owners will be provided with a caution label and an insert for their owner's manual. Owner notification began july 15, 2002. Owners who do not receive the free remedy within a reasonable time should contact southeast toyota at 1-800-301-6859.
  customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

  Show Content

• Recall 2009329 [Canada]: Structure
  On certain vehicles operated in areas of heavy road salt usage, excessive corrosion of the rear cross member may cause separation of the spare tire stowed under the truck bed. Corrosion of the rear cross member may also affect the functionality of the rear brake line at the proportioning valve. A spare tire that separates during vehicle usage could impact nearby persons or objects resulting in personal injury and/or vehicle and property damage. Correction: dealers will inspect the rear cross member and surrounding components and, depending on the amount of corrosion detected, either apply a corrosion-resistant compound or replace the cross member assembly.

  Show Content

• Recall 2005151 [Canada]: Suspension
  On certain vehicles, a manufacturing issue with the front lower ball joint could result in premature wear. If the vehicle is operated for an extended period of time in this condition, the ball joint may eventually experience excessive wear and looseness, resulting in increased steering effort, reduced vehicle self-centering and noise in the front suspension. In extreme cases, when the driver continues to operate the vehicle in this condition, the lower ball joint may separate from the knuckle causing a loss of vehicle steering control. Correction: dealers will inspect and, if necessary, replace the front lower ball joints.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

The following is a list of any known keyfobs for the Toyota Tundra 2002 as well as their FCC IDs if available

• ASP-C-30-156: 2000-2006 Toyota Tundra / 8-Cut / TR47 / Ignition Lock Cylinder / Coded / C-30-156 (ASP)

• Frame corrosion investigation # PE09049

  There is no summary currently available
  

  Show Content

• Ball joint separation investigation # EA04024

  There is no summary currently available
  

  Show Content

• Front suspension ball joint breakage investigation # PE04040

  There is no summary currently available
  

  Show Content

I've owned this vehicle for 18 yrs. During that time air bags have been replaced on models above and below my year model. Every two or three years, i inquired at dealerships when this series will be replaced. Always with the same answer, not required because not enough accident reports to warrant replacement. During that time i've only had one small finder bender not affecting the air bags to deploy. Curious why this year and model was never required to replace air bags?

First the gas tank let loose and fell half way off. Result was a new gas tank installed. Then part of the frame rusted from the cab. This resulted in having to have it welded. Have had several service repair lights come on that resulted in more fixes. Today just about does it. The spare tire fell to the road because rust ate through what was holding it up. I have all the papers that show the repairs and what it has cost me. I have not done anything yet about spare tire. I have had the truck since 2013 and it has less then 94k miles on it. It had 35 when i bought it and i knew nothing about the rust problem recall. I certainly believe i should have a new frame or some kind of compensation. Over the years i have talked to several dealers that got me no where. I guess this is my last shot.

I almost hit another vehicle while braking at a stop light. My front brakes gave out. Had new brakes and rotors installed 2 yrs ago and after this incident found that my brakes failed because toyota refused to fix this problem they knew existed 1 gen toyota tundra. They changed enlarged the front caliber and pads on 2 gen toyota because they realized the brakes whe re w to small on the big v8 trucks. I drove aprox 25000 miles on brand new brakes. I should not have to pay for upgrading my front brakes due to a manufacturer defect, how can they get out of recalling these vehicles it is very dangerous and hope they accept responsibility for improper equipment installed on vehicles. I read that they did upgrade some vehicles that where still in warranty why not all?? Vehicles regardless of warranty.???

On june 9th at about 2pm while driving through my neighborhood, my upper an lower ball joints on my 2002 toyota tundra separated from my vehicle causing a catastrophic loss of control of truck and tore my hub with tire from vehicle ripping the brake fuel line and shoving entire components up under my tundra while losing control with no brakes or steering capability. It also destroyed the drivers side front tire. Needless to say if i was say...Going 55 to 60 miles per hour on highway...I would not be writing this. Had truck towed to checkered flag toyota and they quoted me a price of over1300$ in repairs... They are fighting me on fixing my truck damages even though said damages were caused by the ball joint recall on the 2002 tundra...Recall i d#05v

2002 tundra was recalled for the rusty frame. I had mine inspected at the time of the recall. The dealership sprayed the frame of my truck. Now my frame is severely rusted and unsafe to drive. The balance of my vehicle is in good condition with approximately 200,000 miles. Will i be eligible for repair or replacement? Who should i contact? Thank you bridgette gartmann

My vehicle is unsafe to drive due to how badly the frame is rusted.

Loud knock turning the wheel to the left, rack and pinion leakage, inner outer tie rods can snap cause an injury or death. Headlights are very dim even the bright lights are dim. An oncoming car is not even phased when i have my bright lights on. It's difficult to see very well with those [xxx] lights they're almost in amber color tried to use lens renew did not work. Information redacted pursuant to the freedom of information act (foia), 5 u.S.C. 552(b)(6). *tr

Loud knock turning the wheel to the left, rack and pinion leakage, inner outer tie rods can snap cause an injury or death. Headlights are very dim even the bright lights are dim. An oncoming car is not even phased when i have my bright lights on. It's difficult to see very well with those [xxx] lights they're almost in amber color tried to use lens renew did not work. Information redacted pursuant to the freedom of information act (foia), 5 u.S.C. 552(b)(6). *tr

The frame has rusted so badly that the spare tire fell off into the highway and nearly caused the vehicle behind to almost wreck.Upon arrival at home i looked at the frame and noticed that the u-bolts holding the rear differential are almost rusted off and will need to be replaced. The entire frame is rusted badly. I think something should be done!!! This vehicle has been taken care of and has seldom been off-road. I am a 72 year old man who does not abuse my vehicle. Thank you jerry wakeland

Common OBD-II Error Codes

• P0335 [1] Crankshaft Position Sensor A Circuit Malfunction
• P0135 [2] 02 Sensor Heater Circuit Malfunction (Bank 1 Sensor 1)
• P0155 [2] 02 Sensor Heater Circuit Malfunction (Bank 2 Sensor 1)
• P0440 [1] Evaporative Emission Control System Malfunction
• P0770 [1] Shift Solenoid E Malfunction
• B0133 [1] Seat belt return # 1 circuit - high input
• B1100 [1] B1100
• B0103 [1] erownik immobilisera - no / incorrect signal. Wiring harness, immobilizer control computer