Toyota Fj Cruiser 2wd 2011

• Recall 104811 [USA]: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
  Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2008-2014 fj cruiser and tacoma vehicles equipped with accessory wheels and tires installed by toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with federal motor vehicle safety standard no. 110, "tire selection and rims for passenger cars."
  for the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in september 2014. Owners may contact toyota customer service at 1-800-331-4331.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

• Recall 96647 [USA]: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
  Toyota motor corporation (toyota) is recalling certain model year 2007-2013 fj cruiser vehicles manufactured january 25, 2006 through february 23, 2013 and equipped with a toyota auxiliary driving lamp kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
  toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on june 6, 2013. Owners may contact toyota at 1-800-331-4331.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

• Recall 96921 [USA]: An inaccurate label could lead to owners overloading their vehicles and tires. an overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
  Southeast toyota is recalling certain model year 2008 and 2010-2013 toyota tundra, 2010-2012 rav4, 2012 toyota sequoia, 2010-2011 toyota corolla, 2010-2011 toyota camry and camry hybrid, 2010-2013 toyota highlander and highlander hybrid, 2010-2013 toyota fj cruiser, 2011 toyota land cruiser, 2010-2013 toyota venza, 2010-2011 toyota 4runner, 2010-2013 toyota tacoma, 2011-2012 toyota sienna, 2012 toyota prius, 2013 scion fr-s, 2011 scion xd, 2011 scion xb, and 2012 scion tc vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 110, "tire selection and rims."
  southeast toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on may 28, 2013. Owners may contact southeast toyota at 1-800-301-6859.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

• Recall 91946 [USA]: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
  Toyota is recalling certain model year 2007 through 2013 fj cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
  the safety recall began on june 6, 2013. Toyota will mail an interim letter to owners late in april 2013. Remedy notifications to the owners for the repair will begin in late may 2013. Owners may contact toyota at 1-800-331-4331.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

• Recall 90579 [USA]: If a brake tube becomes damaged and leaks fluid, it may result in increased stopping distances, and in some cases, loss of vehicle front braking performance, which could increase the risk of a crash.
  Toyota is recalling certain toyota racing development (trd) brake kits, p/n ptr09-35070, and trd high-performance brake kits, p/n ptr09-35100, installed by toyota vehicle processing centers and sold by toyota dealers as an optional accessory for model year 2007 through 2012 toyota fj cruiser vehicles. The subject trd brake kit is specifically designed for the front wheels of 2007-2012 model year fj cruiser vehicles. Due to the shape of the outer brake tube of the brake kit, the clearance between the outer brake tube and a trd 16 inch 6-spoke alloy wheel is minimal. If wheel balance weights are installed in an incorrect location, there is a possibility that the outer brake tube could be damaged due to interference with the balance weight, and brake fluid could leak from the damaged tube.
  all known owners of 2007-2012 model year fj cruiser vehicles will be notified by first class mail. If the vehicle is equipped with one of the trd brake kits, the brake caliper outer brake tube will be replaced with a newly designed one at no charge. During this service, if necessary, the dealer will make wheel balance adjustments. This remedy will be performed even if the vehicle has original equipment 16 inch or 17 inch wheels or trd 16 inch beadlock ring type wheels, which are not affected by the condition, to assure sufficient clearance in the event wheels are changed at a later time. Notification to owners began on december 17, 2012. Owners may contact toyota customer experience center at 1-800-331-4331.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

• Recall 77233 [USA]: Drivers will not receive a warning from the tire pressuring monitor that one or more tires are underinflated increasing the risk that a vehicle will be driven with one or more underinflated tires and increasing the risk of a tire failure that may lead to a crash.
  Gulf states toyota is recalling certain model year 2011 fj cruiser and model year 2009-2011 tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring systems." the tpms on some vehicles may not have been properly calibrated and as a result the low tire pressure warning lamp may not illuminate should the inflation pressure in one or more of the vehicle's tires fall below the threshold for when the low tire pressure warning lamp should illuminate.
  dealers will recalibrate the tire pressure monitoring system in accordance with the regulation free of charge. The safety recall is expected to begin during june 2011. Owners may contact gulf state toyota customer assistance center toll free at 1-800-444-1074 monday through thursday, 8:30 am to 5:00 pm, or friday 8:30 am to 4:00 pm central standard time.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

• Recall 76843 [USA]: Failure to warn of tire deflations is a non-compliance with fmvss 138 and could lead to tire failure increasing the risk of a crash.
  Toyota is recalling certain model year 2008 through 2011 fj cruiser, land cruiser, tacoma, sequoia and tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring system (tpms)." when factory-installed wheels and tires were replaced with toyota authorized accessory wheels and lt tires prior to first sale, the tire pressure monitoring systems were not re-calibrated correctly and therefore do not start illuminating the low tire pressure warning telltale at the required minimum activation pressure.
  for the land cruiser, sequoia, tacoma and tundra vehicles, the dealer will re-calibrate the tire pressure monitoring system on affected vehicles and install an updated tire and loading information label at no charge. For the fj cruiser vehicles, the tpms cannot be reset so the electronic control unit (ecu) for the tpms will be replaced. Toyota is currently developing the remedy ecu. If an owner is not certain whether his or her vehicle is equipped with these accessories, please contact any toyota dealer for an inspection at no charge. The safety recall began on march 31, 2011. Owners may contact toyota at 1-800-331-4331.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

• Recall 2013084 [Canada]: Seats and restraints
  On certain vehicles, due to insufficient strength of the access door (rear door) panels, cracks may develop if the access doors are repeatedly and forcefully closed over an extended period of time. As the driver and front passenger seat belt retractors are mounted in the access door panels, if cracks occur in the panel around the lower retractor anchor, the seat belt retractors could become detached. This could increase the risk of injury to an occupant in the event of a crash. Correction: dealers will inspect the rear door panels for cracks or separation. Depending on the results of the inspection, the dealer will repair as necessary.

• Recall 2012353 [Canada]: Brakes
  On certain vehicles equipped with a toyota racing development (trd) high-performance brake kit sold and installed by toyota dealerships, the clearance between the front outer brake tubes and the trd 16-inch 6-spoke alloy wheels is small. If wheel weights are installed in an incorrect location, the outer brake tubes could be damaged. This could cause a brake fluid leak which could result in a loss of front brake function. In conjunction with traffic and road condition, and the driver’s reactions, this could increase the risk of a crash causing property damage and/or personal injury. Correction: dealers will replace both front outer brake tubes with updated versions.

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

Common OBD Error codes specific to this vehicle.

• P0335 [1] Crankshaft Position Sensor A Circuit Malfunction

Rust to the frame of the car not consummate with the age of the vehicle, rust to the straps that secure the fuel tank. Points that affix the brake lines to the vehicle frame have rusted to the point they're no longer affixed to the frame. The rate at which rust gestates on this vehicle (and i am much more attentive than the typical consumer) is unsafe and will continue to create unsafe conditions as these vehicles rapidly deteriorate. The rust prevention methods used by the factory are entirely inadequate.

Rust to the frame of the car not consummate with the age of the vehicle, rust to the straps that secure the fuel tank. Points that affix the brake lines to the vehicle frame have rusted to the point they're no longer affixed to the frame. The rate at which rust gestates on this vehicle (and i am much more attentive than the typical consumer) is unsafe and will continue to create unsafe conditions as these vehicles rapidly deteriorate. The rust prevention methods used by the factory are entirely inadequate.

The vehicle has heavy rust all along the undercarriage and frame. I have friends and acquaintances that have the same problem and to remove as much of this rust as possible toyota will charge somewhere between $800 and $1,000.

Lower control arms rusted. Need replaced couldn't adjust them for alignment. Frame rusting front and rear diff rusting. Stock skid plate replaced rusted through completely. I thoroughly wash salt off my vehicle, yet it still has rusted just like the original frame recall toyota hasn't gotten it right. Need another recall. I've lived with mine, but others have it much worse.

Hello, i was sold a used vehicle by toyota dealership of downtown los angeles (ca) that has a broken windshield. They state they will not assist me in any way for a broken windshield. The windshield has multiple cracks and chips in it strewn across the windshield. It causes serious visual disturbance, especially at night since the chipped glass distorts lights and vehicles, almost blurs the view. Initially, i believed it was traces of tree sap, i made several attempts to remove this 'tree sap' spots, only to discover that they wouldn't go away because it's actually broken glass.

Cruse controll quit working in motion.

Tl* the contact owns a 2011 toyota fj cruiser. While driving unknown speeds and making turns, the steering hesitated. The vehicle was taken to a local dealer (carbone toyota of bennington, located at 751 n bennington rd bennington, vt 05201) where it was diagnosed that the steering shaft needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The vin was unknown. The failure mileage was 144,900.

At 55,000 miles (6 years old) my front gravel shield had completely rusted off and was found in my driveway. I took my car to my toyota service center and they notified me that both control arms and both front struts were very badly rusted and needed to be replaced. I called toyota corporate and after much debate, i was told there was no recall for this matter and therefore they would only reimburse me 50% of all costs to replace said parts. I found toyota has recalls for rust issues on other models and would like this matter looked into. Due to the limited production of this vehicle type it is possible it is being overlooked. I am terrified at the thought that i could've been driving and my control arms could've rusted off like my gravel shield did. A six year old vehicle with only 55,000 should not have this type of rust or parts falling off.

June 19, 2016 my wife stopped the vehicle at the top of our driveway, which has a slight decline to the front of our house. She left it running, put it in park, put the emergency brake on. She got out of the vehicle, walked back down to the house and back up, the vehicle took off down the driveway, running into the house. The vehicle bounced back from the house about 10-12 feet. It was still running, with the emergency brake still on, but the gear shift was now in reverse. My wife then turned the engine off, where the vehicle sat for about 5 days. The front end of the vehicle had to be replaced, and the wall into the house had to be rebuilt. $10,000 repair to the vehicle, $16,000 to the house. Toyota sent an engineer to review the damage and pull edr readings. He stated that the emergency brake was working properly, the gear shift was working properly, and that he could not duplicate the issue (even though the engine could not run at that time). He also stated that he could not pull any readings from the edr. Toyota was not easy to work with, and their communication with me left a lot to be desired.

My issue started around june, i get the wheel shake/ shimmy at speeds of 55-65. Toyota sees the shake is there and then balances the tires and says its fixed . Toyota inspected the truck saying nothing is broken bent or anything saying they don't think anything is wrong. You can still see the shake is there and they keep blaming that the road is causing the shake. Saying its a crowing. In the road. I've went to a toyota dealer to get it inspected they say nothing is wrong and then 2 more times i went there and then they admit it and try fixing it. I am very upset with toyota and corporate . I feel scared to drive it above 50 because there is a bad shake. And feels unsafe its causing the car to be all over the road. *tr

2011 toyota fj cruiser. Customer would like the car to be included in the recall regarding premature air bag deployment. *ta toyota claimed there were signs of water in the engine intake air system and there was no manufacturing or design defect with the air bags. The consumer stated his son did drive through a field with water and mud. However, it was after the air bags inadvertently deployed, so the presence of water had nothing to do with the deployment. *jb

The issue started on 8/23/2012 while driving on i-95 in sc, my 2011 fj cruiser trail teams edition tire pressure warning indicator light came on. The very next day, i took my vehicle to a toyota dealership in west columbia, sc to have it inspected. The dealership could not find anything wrong with the vehicle as the light had turned off that night. However, they did discover an unusual amount of error code messages from the cpu system and thought this may have caused the light to intermittently turn on/off. The dealership reset all error messages and released the vehicle back to me. As it was an isolated incident, i thought there was no reason to worry about it. A week later, while driving my vehicle on i-95 in nc, the same indicator light turned back on, this time for the remainder of my trip home to md. After contacting toyota of bowie to inspect the issue, they found nothing wrong with it and released the vehicle back to me. Soon thereafter, the same indicator light turned back on until mid-january 2013 when driving the vehicle to ga, the indicator light turned off. I had the vehicle serviced at i-95 toyota (near brunswick, ga) and they indicated no issues were found with the vehicle even though i advised them of the incidents. They concluded that when i return home to have the vehicle looked at then. While returning home to md, the indicator light turned back on and has stayed on ever since. Considering i have not received notice from toyota for the safety recalls for the vehicle, i discovered them through the nhtsa website and i have an appointment for this morning to have a few current recalls that the dealership knows about to be fixed and will advise toyota of annapolis (koon's) (where i originally purchased the vehicle) of the indicator light issue and concern. If any further information is needed, please do not hesitate to contact me. *tr

Since new my vehicle has had a shaking steering wheel when reaching speeds over 55mph. After trying several different sets of tires, wheels and balancing my dealer has not been able to correct the issue. Toyota will not help and the steering is shaking so bad it feels unsafe to drive on the highway. *tr

Vehicle shimmy between 55 and 65 mph after being at dealer for routine tire rotation. Tires were replaced, rebalanced & alignment done multiple times and vehicle brought to 4 diff locations for inspection and problem still exists. Has been to toyota dealer multiple times with no resolution. Not safe to drive and will most likely cause other parts in front end/vehicle to fail. Contacted toyota and nothing was done to fix problem. *tr

Tl* the contact owns a 2011 toyota fj cruiser. While parked, the contact noticed excessive corrosion throughout the undercarriage of the vehicle. The manufacturer was made aware of the failure. The contact was awaiting a response from the manufacturer. During cold weather, the contact also noticed that the rear view camera fogged and froze, making the visibility blurry and difficult to see. The vehicle was not repaired. The approximate failure mileage was 2,500. ..Updated 04/26/12 *bf updated 06/15/2012 *js

Steering column shakes between speeds 55-65 mph, have had the wheels and tires rebalanced with a road force machine without any resolve of the problem. *tr

Vehicle steering wheel shakes violently between 55 and 70 mph. Several other fj owners seem to have this issue. Dealer can not fix even though they have tired multiple wheel balances and tire rotations. Not safe to drive on the highway like this. *tr

Vehicle exhibited excessive steering wheel shake indicative of wheels being off balance. After attempting to re-balance 6 times at 4 different shops the symptom persists intermittently. Other fj owners of 2010 model year and newer fj cruisers have complained that their vehicles have exhibited the same behavior. The problem (based on feed back from other owners on internet forums) is spread across different models, wheel and tire combinations. Many of them have taken their vehicles back to toyota who claims the shaking is normal. However the vehicle seems unstable at speed ranging from 45 to 60mph, most evident at about 50mph. *tr

Vehicle exhibits steering shimmy between 55-65 mph, vehicle can not maintain stable performance at highway speeds. Toyota have replace both wheel and tires and have the same result. Fj cruisers are having a problem, and toyota will not do anything on this saftey issue. *tr

The day i bought my new toyota fj i took it to a tire shop for larger off-road tires. I watched the tech as he changed tires and remounted the wheels. He carefully tightened the lug nuts with a torque wrench, but on one, it was obvious to him and me both that the tightening effort suddenly got easier. He made another easy 1/4 turn and the stud came off. The manager looked at the stud and said it had to have been overtightened previously by the factory or was defective. They fixed it. About 4 months later i was putting on my wheels after installing a suspension lift. I used a torque wrench set at 80lbs and before it ever got to a normal tight the stud twisted off. Please look at this forum thread: http://www.Fjcruiserforums.Com/forums/problems-dealer-service/85927-broken-wheel-studs.Html there are likely more threads on this subject and there is also mention of similar threads on a toyota tacoma site. I have removed/replaced many dozens of wheels in my lifetime and before buying this fj had never broken a stud even though i put far more effort into tightening studs. *tr

Received a safety recall notice from toyota to have the auxiliary light kit replaced due to it being a hazard. Brought the vehicle into the toyota dealer 4 times over a 6 month period to have the replacement done, and yet it has still not been performed. We will continue to drive the vehicle since it is likely only a hazard to oncoming traffic more so than to ourselves, but we are upset that the toyota dealer has not yet completed the replaced the hazardous lights in accordance with the recall notice. Note, the date of first incident is approximate. Dealer info: big two toyota of chandler, 480-302-4651. They are located in chandler arizona. *tr