Ford F-350 2012

• Recall 146092 [USA]: If the steering locks, it can increase the risk of a crash.
  Icon vehicle dynamics, llc (icon) is recalling all 05-up fsd 2.5 centerline stabilizer kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 ford f-250 4x4 and f-350 4x4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
  icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began december 21, 2020. Owners may contact icon customer service at 1-951-689-4266.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 116765 [USA]: Engine shut down and a subsequent cool down period may delay medical treatment or assistance to those needing it, increasing their risk of injury.
  Ford motor company (ford) is recalling certain model year 2011-2015 ford f-350, f-450, and f-550 trucks manufactured february 22, 2010, to january 30, 2015, and equipped with ambulance or fire engine preparation packages. The affected vehicles may detect an incorrect exhaust gas temperature sensor (egt) fault indicating that the vehicle is too hot, causing the engine management system to shut down the engine and prevent its immediate restart.
  ford will notify owners, and dealers will update the powertrain control module (pcm) software, free of charge. The recall began on april 22, 2015. Owners may contact ford customer service at 1-866-436-7332. Ford's number for this recall is 15s09.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 105713 [USA]: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
  Jerr-dan corporation (jerr-dan) is recalling certain model year 2009-2014 ford f-350 super duty, f-450 super duty, and f-550 superduty chassis modified by jerr-dan and equipped with certain muncie power products pto assemblies. In the affected vehicles, oil may leak from the pto pressure switch onto a thermal blanket covering the exhaust.
  jerr-dan will notify owners, and dealers will install a new pressure switch kit that moves away from the exhaust system, free of charge. The recall began in october 2014. Owners may contact jerr-dan customer service at 1-800-926-9666.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 99692 [USA]: An unexpected engine stall increases the risk of a crash. additionally, if this were to occur when the ambulance is transporting a patient, there is an increased risk of injury to the patient.
  Ford motor company (ford) is recalling certain model year 2011-2012 f-350/450/550 ambulance package vehicles manufactured february 22, 2010, through october 19, 2012 and equipped with a 6.7l diesel engine. Due to an exhaust sensor problem, the vehicles may experience loss of power followed by an engine stall.
  ford will notify owners, and dealers will replace the exhaust gas temperature sensor, free of charge. The recall began on november 25, 2013. Owners may contact ford motor company customer relationship center at 1-866-436-7332. Ford's recall campaign number is 13s10.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 98612 [USA]: Excessive heat build up in rear compartment could result in fire.
  Manning equipment inc. Llc (manning) is recalling certain model year 2012 ford f-350, f-450 and f-550 gasoline engined dual rear wheel chassis vehicles manufactured october 2011 through june 2012. The tailpipe on the exhaust system does not extend out beyond the edge of the body, allowing heat to build up in rear curbside storage compartment.
  manning equipment has notified owners, and dealers will install tailpipe extensions free of charge. The recall has already begun. Owners may contact manning equipment at 1-502-426-5210.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

  Show Content

• Recall 91495 [USA]: This will allow the operator to inadvertently shift the vehicle into gear without the brake pedal being depressed, increasing the risk of a crash or injury to a nearby pedestrian.
  Ford is recalling certain model year 2011 f-150 vehicles manufactured from september 9, 2011, through september 22, 2011, and model year 2012 f-250, f-350, f-450 and f-550 heavy duty vehicles manufactured from september 12, 2011, through september 22, 2011. These vehicles fail to comply with the requirements of federal motor vehicle safety standard number 114, ?Theft protection.? The transmission can be shifted out of the park position without pressing the brake pedal due to brake shift interlock switch problem.
  ford will notify owners, and dealers will inspect the brake shift interlock switch function and replace the switch if necessary, free of charge. The safety recall began on december 22, 2011. Owners may contact the ford motor company customer relationship center at 1-866-436-7332.
  owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

  Show Content

• Recall 2019420 [Canada]: Other
  Issue: this recall is for aftermarket replacement rear window glass produced by vitro automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: this is a voluntary recall that is not being conducted under the requirements of the motor vehicle safety act. Safety risk: glass that breaks in to large pieces could create a risk of injury. Corrective actions: the company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “dot 287” along with the lettering “vmr” (replacement market) and a date code that is before july 2019. This information is printed on the bottom corner of the glass. Consumers should contact vitro's customer service at 1-412-995-6457 or [email protected] to arrange for replacement of the glass.

  Show Content

• Recall 2015125 [Canada]: Engine
  Certain ambulance or fire package vehicles with 6.7l diesel engines may experience a "stop safety now" warning message and 5 audible chimes if an exhaust gas temperature (egt) sensor fault is detected. Engine torque would be gradually reduced by 70 percent over a period of 45 seconds to a power-reduced level that is maintained. During this time, there would be no effect on steering, braking, lighting, electrical, or restraint systems, allowing the operator to maneuver the vehicle to a safe location. Such an occurrence could also result in an engine shut down and subsequent inability to quickly restart the vehicle. If this condition were to occur when an ambulance or fire engine vehicle was transporting a patient or providing medical assistance, it could delay medical treatment and increase the risk of injury to the patient. Correction: dealers will reprogram the powertrain control module with updated software.

  Show Content

• Recall 2013372 [Canada]: Engine
  Certain ambulance package vehicles with 6.7l diesel engines may experience a "stop safety now" warning message and 5 audible chimes while the vehicles gradually loses power, eventually resulting in the engine stalling when speed falls below 5 km/h. If this were to occur while the ambulance is transporting a patient, engine shutdown with no ability to restart could interfere with patient care and increase the risk of injury to the patient. Correction: dealers will replace the exhaust gas temperature (egt) sensor located downstream of the diesel particulate filter (dpf).

  Show Content

• Recall 2014103 [Canada]: Airbag
  Certain vehicles may not comply with canada motor vehicle safety standard 208 - occupant protection in frontal impacts. Prescribed text may have been omitted from the airbag warning label in the french language only. As a result, the french-language warning label is more restrictive than the english. Correction: no corrective recall action is required as this technical non-compliance is deemed to be non-safety related.

  Show Content

• Recall 2011426 [Canada]: Powertrain
  Certain vehicles fail to comply with the requirements of canada motor vehicle safety standard 102 - transmission control functions. The brake transmission shift interlock (btsi) switch may have been incorrectly manufactured and could fail. This would allow the transmission gear shift lever to be moved out of the park position without depressing the brake pedal. Depending which gear the driver selects, the vehicle could begin to move forward or backward immediately. This movement could result in property damage, or cause the vehicle to strike a bystander, potentially resulting in personal injury. Correction: dealers will inspect and, if necessary, replace the btsi switch.

  Show Content

• Recall 2014103 [Canada]: Airbag
  Certain vehicles may not comply with canada motor vehicle safety standard 208 - occupant protection in frontal impacts. Prescribed text may have been omitted from the airbag warning label in the french language only. As a result, the french-language warning label is more restrictive than the english. Correction: no corrective recall action is required as this technical non-compliance is deemed to be non-safety related.

  Show Content

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Vehicle commanded engine shutdown investigation # RQ14005

  The office of defects investigation (odi) opened this rq to investigate allegations that the scope and remedy of safety recall 13v-535 were inadequate. Recall 13v-535 was limited to a relatively small population of "ambulance package" vehicles and odi received complaints of pickup trucks and "fire engine prep package" vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between february 22, 2010 and january 30, 2015 that may be affected by defective egt sensors and powertrain control module (pcm) software calibration. The subject vehicles are equipped with four (4) egt sensors to monitor engine operating conditions. An egt sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the powertrain control module (pcm) implements a failure management effects mode (fmem) and the driver receives a "stop safely now" (ssn) system warning on the instrument cluster message center. The fmem triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The pcm then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the pcm software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute "cool down" period.Ford and its component supplier(s) made numerous changes to the pcm software calibration and the design, material and manufacture of the egt sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to "ambulance package" and "fire engine prep package" vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15v-175) to address the 13v-535 remedy concerns in the "ambulance package" vehicles and "fire engine prep package" vehicles. The 15v-175 remedy reprograms the pcm with a new software calibration that stops a single egt sensor fault to cause the vehicle to enter the fmem shutdown mode.Ford also initiated an epa emissions recall (14e03) for all subject vehicles that reprograms the pcm with the software calibration employed in safety recall 15v-175. Finally, ford initiated a customer satisfaction program (15m01) providing extended warranty coverage of 8 years or 80,000 miles for the the egt sensors on certain my2011-2012 subject vehicles.Due to the epa emissions recall, that had a 66.6% completion rate in fords december 2015 progress report to the epa, the defect trend is in decline. Odi is not aware of any crashes, deaths or injuries related to the alleged defect.Odi believes the alleged defect poses a safety risk but notes that the epa emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this recall query is closed.This action is not a finding that no defect exists and nhtsa will take further action if such action is warranted.
  

  Show Content

Death wobble. At 30 mph & 70 mph. Jerked steering wheel from my hands & pulled us off the road onto grass on road side. Full brakes & skidded to a stop.

While traveling down the road at approximately 72 mph my vehicle front end began to shake unbelievably. It felt like all four tires had gone flat. I could not control the vehicle until the speed got down to around 40 mph.

I was 300 miles from home for work for a week. On day 1, while driving on a residential street, i suddenly got a message on the dash that stated "stop safely now". Seconds later, as i was pulling over by the curb, the truck shut itself down and would not start back up. I had to rent a vehicle (being away from home). On day 3, i tried again and it started. I drove it a block away to the place i was staying. Entering the parking lot, i got the message and it shut down again just as fast. At this point i had to arrange transport of my truck back home. $650 and 3 days later, i finally got it home. Started it, ran for a few minutes parked so tried to drive it. Made it about 1000 feet when it shut down again and left me stranded on the highway. Each time it shut itself down, i had to wait a minimum of 1 hour before it would restart. After researching, it seems that my egt13 sensor has gone bad and has to be replaced. Had it shut down while i was on the interstate, the results of this could have been a whole lot worse than the expense of a rental and transport. My research brought to light that this seems to be an ongoing problem with fords that needs to be addressed and

Driving on highway at 60 m/h violent shaking of the front end and steering occurs when there is a change in pavement, also known as the "death wobble" replacing suspension, ty-rods and sway bar ,etc. Did not fix the problem

Driving on highway at 60 m/h violent shaking of the front end and steering occurs when there is a change in pavement, also known as the "death wobble" replacing suspension, ty-rods and sway bar ,etc. Did not fix the problem

Driving at higher speeds in my 2012 f350 lariat, the truck gets to 60 fine but any faster then that and it begins to get a speed wobble that causes the entire truck to vibrate at a uncontrollable shake that throws the steering and i found it unsafe to hit the brakes, which forces you to just coast while the trucks shakes violently. For a truck that people pay up to $40,000 ot should be able to cruise at speeds above 60-70 mph with no problem. It seems to be thrown off by the smallest divit or bump in the roads but only at highway speeds. Which makes it that much more dangerous. I have a 6 year old that was in the truck many times as this happens and it's a scary thing it feels like the wheels are going toncome off. Only had this truck for about 6 months now also. It seems in mint condition except for the speed wobble.

Driving at higher speeds in my 2012 f350 lariat, the truck gets to 60 fine but any faster then that and it begins to get a speed wobble that causes the entire truck to vibrate at a uncontrollable shake that throws the steering and i found it unsafe to hit the brakes, which forces you to just coast while the trucks shakes violently. For a truck that people pay up to $40,000 ot should be able to cruise at speeds above 60-70 mph with no problem. It seems to be thrown off by the smallest divit or bump in the roads but only at highway speeds. Which makes it that much more dangerous. I have a 6 year old that was in the truck many times as this happens and it's a scary thing it feels like the wheels are going toncome off. Only had this truck for about 6 months now also. It seems in mint condition except for the speed wobble.

Truck started to wobble violently that it was extremely difficult to maintain control of vehicle and get the truck to the side of the interstate. I drove over a small bump in the road before the incident.

Truck started to wobble violently that it was extremely difficult to maintain control of vehicle and get the truck to the side of the interstate. I drove over a small bump in the road before the incident.

Common OBD-II Error Codes

• P2073 [4] Manifold Absolute Pressure/Mass Air Flow - Throttle Position Correlation at Idle
• P2074 [4] Manifold Absolute Pressure/Mass Air Flow - Throttle Position Correlation at Higher Load
• P2457 [2] Exhaust Gas Recirculation Cooling System Performance
• P0401 [2] Exhaust Gas Recirculation Flow Insufficient Detected
• P0627 [2] Fuel Pump "A" Control Circuit /Open
• P025A [2] Fuel Pump Module Control Circuit/Open
• P025B [2] Fuel Pump Module Control Circuit Range/Performance
• P2700 [1] Transmission Friction Element "A" Apply Time Range/Performance
• P0730 [1] Incorrect Gear Ratio
• P0751 [1] Shift Solenoid A Performance or Stuck Off
• P204F [2] Reductant System Performance Bank 1
• P208E [2] Reductant Injection Valve Stuck Closed Bank 1 Unit 1
• P218F [2] ISO/SAE Reserved
• B141B [1] B141B
• B141C [1] B141C
• U0109 [1] Lost Communication With Fuel Pump Control Module
• P2201 [5] NOx Sensor Circuit Range/Performance Bank 1
• P20EE [3] SCR NOx Catalyst Efficiency Below Threshold Bank 1
• P207F [6] Reductant Quality Performance
• P229F [2] Nitrogen oxides (NOx) sensor 2, bank 1 – circuit range/performance
• P0299 [1] Turbocharger/Supercharger "A" Underboost Condition
• P2452 [1] Diesel Particulate Filter Pressure Sensor "A" Circuit
• P2459 [1] Diesel Particulate Filter Regeneration Frequency
• P2463 [1] Diesel Particulate Filter Restriction - Soot Accumulation
• P246C [1] Diesel Particulate Filter Restriction - Forced Limited Power
• P2043 [2] Reductant Temperature Sensor Circuit Range/Performance
• P205C [1] Reductant Tank Temperature Sensor Circuit Low
• P161A [1] P161A
• P2200 [2] NOx Sensor Circuit Bank 1
• P2209 [2] NOx Sensor Heater Sense Circuit Range/Performance Bank 1
• P0133 [2] 02 Sensor Circuit Slow Response (Bank 1 Sensor 1)
• P2A00 [1] O2 Sensor Circuit Range/Performance Bank 1 Sensor 1
• P164A [2] P164A
• P2270 [1] O2 Sensor Signal Biased/Stuck Lean Bank 1 Sensor 2
• P2272 [1] O2 Sensor Signal Biased/Stuck Lean Bank 2 Sensor 2
• P054F [2] ISO/SAE Reserved
• P202D [2] Reductant Leakage
• P204B [1] Reductant Pressure Sensor Circuit Range/Performance
• P20E8 [2] Reductant Pressure Too Low
• P2031 [1] Exhaust Gas Temperature Sensor Circuit Bank 1 Sensor 2
• P2032 [1] Exhaust Gas Temperature Sensor Circuit Low Bank 1 Sensor 2
• P2033 [2] Exhaust Gas Temperature Sensor Circuit High Bank 1 Sensor 2
• P2479 [1] Exhaust Gas Temperature Out of Range Bank 1 Sensor 2
• P247B [1] Exhaust Gas Temperature Out of Range Bank 1 Sensor 4
• P2003 [1] Diesel Particulate Filter Efficiency Below Threshold Bank 2
• P200C [1] Diesel Particulate Filter Over Temperature Bank 1
• P242D [1] Exhaust Gas Temperature Sensor Circuit High Bank 1 Sensor 3
• P2471 [1] Exhaust Gas Temperature Sensor Circuit High Bank 1 Sensor 4
• P2100 [1] Throttle Actuator "A" Control Motor Circuit/Open
• P1636 [1] Theft Deterrent Start Enable Signal Not Correct/ Main Relay Malfunction (Power Hold)
• C2020 [2] C2020