Volvo Vhd 2008

• Recall 139001 [USA]: The driver may operate the vehicle with the snow plow headlights on but the marker and tail lamps off, reducing the vehicle's visibility and increasing the risk of a crash.
  Volvo trucks north america (volvo) is recalling certain 2004-2019 volvo vhd trucks equipped with snow plow lamp preparation kits. The snow plow headlights can be turned on without other exterior lights, and high beam indicator will not work when the snow plow high beams are on. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 108, "lamps, reflective devices, and associated equipment."
  volvo will notify owners, and dealers will update the software related to the plow lights, free of charge. The recall began december 19, 2018. Owners may contact volvo customer service at 1-800-528-6586. Volvo's number for this recall is rvxx1804.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

• Recall 97114 [USA]: Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.
  Volvo trucks north america (volvo) is recalling certain model year 2007-2014 vah, vhd, vnl, vnm, and vt models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
  volvo trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on august 26, 2013. Volvo's recall number is rvxx1303. Owners may contact volvo at 1-336-393-2000.
  owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.Safercar.Gov.

• Recall 90798 [USA]: In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. this increases the risk of injury to the seat occupant.
  Volvo is recalling certain model year 2002-2013 vhd and vn trucks, manufactured from august 4, 2000, through june 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 210, "seat belt assembly anchorages."
  volvo trucks of america will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on may 10, 2013. Owners may contact volvo at 1-336-393-2000.
  volvo's recall campaign number is rvxx1204.Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153), or go to www.Safercar.Gov.

• Recall 80176 [USA]: The misinformation on these labels could lead to a vehicle overloading that can increase risk of a crash.
  Volvo is recalling certain model year 2008-2011 vhd, vnl, vnm, as well as 2008-2010 vt vehicles for failing to comply with the requirements of part 567, "certification." the tire description may be incorrect on the vehicle's certification label.
  dealers will inspect and replace the labels free of charge. The safety recall began on february 25, 2011. Owners may contact volvo at 1-800-458-1552.
  volvo safety recall no. Rvxx1005.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

• Recall 67651 [USA]: If this happens a short circuit may occur, which over time could possibly lead to a vehicle fire.
  Volvo trucks is recalling 127,764 my 2001-2008 vhd, vnl, vnm, and my 2005-2008 vt trucks. A seal may fail allowing water and contaminants to seep into the windshield wiper motor.
  volvo will replace the wiper motor free of charge. Since this recall involves a large number of vehicles, volvo will release the recall in stages as parts are received. Priority will be given to the vehicles located in the regions/states that have a corrosive environment. The recall began on september 30, 2009. Owners may contact volvo trucks at 1-800-528-6586.
  volvo trucks recall no. Rvxx0902.Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov .

• Recall 74788 [USA]: If a short circuit occurs and is left untreated, components and wiring may be subject to overheating which could possibly result in a vehicle fire.
  On certain heavy duty trucks, the circuit protection (i.E. Automatic circuit breakers) used to protect the vehicle lighting system may not provide adequate protection.
  dealers will replace the circuit breakers with fuses. The recall began on february 25, 2008. Owners may contact volvo trucks at 1-800-528-6586.
  volvo trucks recall no. Rvxx0707.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

• Recall 71846 [USA]: There is a possibility that the pivot bolt can become loose without the driver's knowledge. when this occurs, the driver could drive away and the trailer could become disengaged, increasing the risk of a crash.
  On certain trucks equipped with a saf holland simplex fifth wheel, the lever arm pivot bolt may have been over tightened. An over tightened pivot bolt can distort the pivot bolt spacer sleeve, which may prevent the fifth wheel latch jaw from closing and latching securely around the trailer king pin.
  dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer free of charge. The recall began on january 28, 2008. Owners may contact volvo trucks at 1-800-528-6586.
  volvo trucks recall no. Rvxx0705.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

• Recall 72121 [USA]: The cylinders could possibly separate, which would leave the hood unrestrained when opening and closing the hood.
  On certain trucks, the hood restraint cylinder does not contain enough dampening to adequately restrain the hood.
  dealers will replace the hood restraint cylinders free of charge. The recall began on october 15, 2007. Owners may contact volvo trucks at 1-800-528-6586.
  volvo recall no.Rvxx0704.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

• Recall 88916 [USA]: If the condition exists and the key is left on without fuel in the filter, the heating element may heat to a point where a flame becomes present at the tip of the element which could result in a vehicle fire.
  On certain trucks, an unprotected lead in the thermoswitch of the heater may make contact with another post possibly creating a short circuit, which can result in continuous operation of the heating element.
  dealers will inspect the thermoswitch and will replace it if necessary. The recall began on september 10, 2007. Owners may contact volvo trucks at 1-800-528-6586.
  volvo truck recall no. Rvxx0703.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

• Recall 32197 [USA]: If the nut were to come loose, the steering shaft could potentially separate resulting in loss of steering control which could cause a crash.
  On certain trucks, the nut used to retain the steering shaft may or may not be a lock nut that has the locking feature. A lock nut is required to provide additional resistance to ensure that the nut does not come loose.
  dealers will replace the steering shaft pinch bolts and locknuts free of charge. The recall began on august 24, 2007. Owners may contact volvo trucks at 1-800-528-6586.
  volvo recall no. Rvxx0702.Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.Safercar.Gov.

• Recall 2018604 [Canada]: Lights and instruments
  Certain vehicles equipped with a snowplow preparation kit may fail to comply with the requirements of canada motor vehicle safety standard (cmvss) 108 - lighting system and retroreflective devices. The snowplow headlamps can be turned on without other exterior lights, and the high beam indicator does not work when the snowplow high beams are turned on, which is contrary to the requirements of the standard. This could allow the vehicle to be operated with the snowplow headlamps on and marker and tail lamps off, making the vehicle harder to see and potentially increasing the risk of a crash causing injury and/or damage to property. Correction: dealers will update vehicle software to correct the non-compliance.

• Recall 2016494 [Canada]: Steering
  On certain vehicles, a defect in the ball joint seals on the drag link could allow corrosion to form in the joint, leading to accelerated wear. This could result in ball joint failure, potentially resulting in a loss of steering control which could increase the risk of a crash causing injury and/or damage to property. Correction: dealers will replace the non-greasable drag link with a greasable drag link.

• Recall 2013221 [Canada]: Other
  On certain vehicles, the secondary clutch disengagement switch may have been omitted during vehicle assembly or, in some instances, removed during servicing. As such, primary switch failure would cause the automated manual transmission’s clutch to remain engaged when the brakes are applied. This could increase stopping distances, possibly resulting in a crash causing property damage and/or personal injury. Correction: dealers will install a micro-switch at the brake pedal and update the software to run a diagnostic on the switch during engine start-up.

• Recall 2012356 [Canada]: Seats and restraints
  Certain vehicles may fail to conform to canada motor vehicle safety standard 210 – seatbelt assembly anchorages. The weld used to secure the nut to the center-passenger seatbelt d-ring mounting bracket may not be sufficient to meet the strength requirements of the standard. Failure of the seatbelt d-ring anchorage to restrain the occupant would increase the risk of personal injury during a crash. Correction: dealers will replace the d-ring for the middle seating position.

• Recall 2010347 [Canada]: Label
  On certain vehicles, the tire description may be incorrect on the certification label, which is a non-compliance to canada motor vehicle safety standard 120 - tire selection and rims. The description listed on the label may be for a tire with a lower rating that cannot support the gross axle weight rating (gawr) listed, which may result in a potential tire failure. Correction: updated labels will be mailed to owners of affected vehicles, along with instructions for proper installation.

• Recall 2009144 [Canada]: Other
  On certain vehicles, the windshield wiper motor may be susceptible to water intrusion, which could result in an electrical short circuit and a fire. This could cause property damage, personal injury or death. Correction: dealers will affect repairs.

• Recall 2007253 [Canada]: Steering
  On certain trucks, the locknut used to retain the steering shaft may not have had the lock feature. As a result, the nut could loosen, allowing the steering shaft to separate, causing a loss of steering control which could result in a vehicle crash with injury or death. Correction: dealers will replace the steering shaft pinch bolt and locknut.

• Recall 2007257 [Canada]: Fuel supply
  On certain trucks, when the ignition key is in the 'on' position, the pre-heater, located in the fuel filter base, is energized. If this pre-heater is energized while maintenance is being performed on the fuel filter, diesel fuel could ignite within the filter housing. A fire within the fuel filter housing may spread possibly resulting in property damage or personal injury. Correction: dealers will inspect and, if required, replace the fuel heater assembly.

• Recall 2007293 [Canada]: Other
  On certain vehicles, inadequate hood cylinder dampening may allow the hood to be opened with too much force. Once the cylinders reach full extension, this lack of dampening could cause them to separate from the hood, allowing the hood to keep tilting forward, possibly injuring its operator or a bystander. Correction: dealers will replace the hood restraint cylinders.

• Recall 2007338 [Canada]: Other
  On certain trucks, the fifth wheel hitch assembly's lever arm may have been incorrectly installed during the manufacturing process. The lever arm pivot bolt may have been over-tightened which could distort the pivot bolt spacer sleeve and prevent the fifth wheel latch jaw from closing and latching securely around the trailer king pin. This could allow the towed unit to separate from the towing vehicle while underway, potentially causing a crash with injury or death. Correction: dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer.

• Recall 2007394 [Canada]: Electrical
  On certain trucks, the automatic circuit breakers used to protect the vehicle lighting system may not provide adequate protection. If a short circuit occurs, components and wiring may be subject to overheating, which could result in a vehicle fire, causing property damage and/or personal injury or death. Correction: dealers will replace the circuit breakers with fuses.

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

• Stop lamp switch signal investigation as of 20130207

  The office of defects investigation (odi) received early warning reporting (ewr) data from the manufacturer that indicated some number of subject vehicles equipped with the subject automated manual transmission had allegedly experienced a condition where the clutch failed to automatically disengage the transmission from the engine as intended. This may result in extended stopping distances and/or unintended forward motion of a vehicle previously at rest.To date, odi is aware of 134 subject vehicles with one or more complaints or field reports related to this condition.Also, odi is aware of 164 subject vehicles with one or more warranty claims related to this condition.By letter dated june 25, 2013, volvo trucks north america (volvo) notified odi that it has initiated a safety recall (nhtsa recall no. 13v268 and volvo recall no. Rvxx1303) to address a safety defect in approximately 23,003 model year (my) 2007 through 2014 volvo vah, vhd, vnl, vnm and vt model trucks. The affected vehicles were manufactured from december 20, 2006 through may 22, 2013 and were originally equipped with the subject automated manual transmissions.According to volvo, reports of the subject transmission clutch mechanism failing to automatically disengage as intended are associated with the removal of a brake pedal micro switch that provided a redundant signal to the transmission control module indicating the brakes had been applied.Previously, volvo had removed this brake pedal micro switch from new vehicle production and from certain vehicles already in-service via two field service campaigns (sp 432-024 and sp 432-026) because it decided the switch was unnecessary and/or a maintenance issue.In the absence of this redundant brake pedal micro switch, the clutch mechanism may fail to disengage the transmission from the engine at low vehicle speed should the stop lamp switch fail to send and/or the transmission control module fail to receive the primary signal.At the time of this closing, volvo is evaluating available remedies and will provide nhtsa with details when the recall remedy procedure has been finalized.Volvo will notify affected owners by mail by august 25, 2013.Please see nhtsa recall no. 13v268 for details.Accordingly, this investigation is closed.
  

  Show Content

• Saf holland fifth wheel assembly investigation as of 20070914

  On october 18, 2007 volvo trucks north america filed defect report 07v-496 which outlines a safety recall program to notify the affected owners and correct the affected vehicles.
  

  Show Content

Common OBD Error codes specific to this vehicle.

• P10AE [1] P10AE
• P215A [1] Vehicle Speed - Wheel Speed Correlation
• P071A [1] Transmission Mode Switch "A" Circuit
• P07CE [1] P07CE
• U0121 [1] Lost Communication With Anti-Lock Brake System (ABS) Control Module
• P0420 [1] Catalyst System Efficiency Below Threshold (Bank 1)
• P1072 [1] P1072
• P111C [1] P111C
• P040A [1] Exhaust Gas Recirculation Temperature Sensor "A" Circuit
• P040B [1] Exhaust Gas Recirculation Temperature Sensor "A" Circuit Range/Performance
• P1121 [1] Engine Coolant sensor out of range/ECT Sensor Out Of Self Test Range
• P1052 [1] P1052
• P009E [2] Fuel Pressure Relief Control Performance/Stuck Off
• P208E [2] Reductant Injection Valve Stuck Closed Bank 1 Unit 1
• P103B [2] P103B
• P2459 [2] Diesel Particulate Filter Regeneration Frequency
• P0194 [1] Fuel Rail Pressure Sensor A Circuit Intermittent
• P249F [1] Excessive time to enter closed loop Diesel particulate filter (DPF) regeneration control
• P24A0 [1] Closed loop Diesel particulate filter (DPF) regeneration control, control limit reached – temperature too low
• P226C [1] ISO/SAE Reserved
• P2002 [1] Diesel Particulate Filter Efficiency Below Threshold Bank 1
• P24A4 [1] P24A4
• P10FE [1] P10FE
• P249C [1] Excessive time to enter closed loop reductant injection control
• P0422 [1] Main Catalyst Efficiency Below Threshold (Bank 1)

Repairs on a class 8 over the road tractor, two fuel pump has being install with no,resort the third one will be install on friday the 23 of january hoping that will be enough to do the job. *tr

This is a compliance investigation inspection request for the following public transportation systems: (1) houston - metro bus (2) san antonio - via bus. *tr