2012 Toyota Rav4 EvToyota Rav4 Ev 2012

Vehicle Details: Recalls, Fuel Economy, Emissions, Crash Tests, Investigations, Consumer Complaints, Service Bulletins

Toyota Logo

Below you will find all available information on the 2012 Toyota Rav4 Ev, manufacturered by Toyota Motor Manufacturing Canada.
The vehicle is described as a Front-Wheel Drive Sport Utility Vehicle - 2WD Compact Utility (Utility Vehicle Categories "Small" and "Midsize").

ManufacturerKnown WMI(s)Fuel Type
Toyota2T3 4T3 JT3 JTE JTJ JTL JTM JTM JTJ JTL Electricity
EV 120V ChargeEV 240V ChargeRange
Unlisted Hours6 Hours103 Miles
Toyota VIN Decoder

Use the box here to look up VINs from Toyota as well as other manufacturers

#
Frequently Asked Questions
  • What is the range of a 2012 Toyota Rav4 Ev?
     - The 2012 Toyota Rav4 Ev has an EPA estimated range of 103 miles.
  • What is the charge time of a 2012 Toyota Rav4 Ev?
     - The 2012 Toyota Rav4 Ev has a full charge time of 6 hours at 240V.
  • What is the fuse box diagram for the 2012 Toyota Rav4 Ev?
     - Fuse box diagrams for the 2012 Toyota Rav4 Ev can be found here
  • What is the annual fuel cost for the 2012 Toyota Rav4 Ev?
     - EPA estimated annual fuel cost for the 2012 Toyota Rav4 Ev is $900.
  • Where is the 2012 Toyota Rav4 Ev produced?
     - The 2012 Toyota Rav4 Ev is produced in Cambridge On, Canada.
  • Are there recalls for the 2012 Toyota Rav4 Ev?
     - There are 11 recall(s) for the 2012 Toyota Rav4 Ev, additional information is below.
  • How much does the 2012 Toyota Rav4 Ev weigh?
     - The 2012 Toyota Rav4 Ev is listed to weigh 1703 lbs.
Available Engine & Drive Classes
  • 2.5L 4 cylinder 4-speed automatic
  • 3.5L 6 cylinder 5-speed automatic
NHTSA Mandated Recalls

  • Recall 110760 [USA]: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.

  • Recall 117536 [USA]: Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.

  • Recall 109652 [USA]: A loss of drive power may increase the risk of a crash.

  • Recall 101542 [USA]: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.

  • Recall 96926 [USA]: An inaccurate label could lead to owners overloading their vehicles and tires. an overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

  • Recall 96121 [USA]: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. this could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

  • Recall R/2016/024 [UK]: Seatbelt may not perform as designed

  • Recall 2021723 [Canada]: Accessories

  • Recall 2016075 [Canada]: Seats and restraints

  • Recall 2015409 [Canada]: Structure

  • Recall 2014043 [Canada]: Brakes

To ensure accuracy and for your safety, it is recommended to do a free VIN recall check here or here [USA] - UK - Canada.

Recalls are also available on the Complaints page
NHTSA Submitted Mechanical & Emissions Details

  • Automatic (variable gear ratios) Front-Wheel Drive Rav4 Ev

    Description Data
    Combined electricity consumption in kw-hrs/100 miles44.0
    TransmissionAutomatic (variable gear ratios)
    You save/spend over 5 years compared to an average car ($). savings are positive; a greater amount spent yields a negative number. for dual fuel vehicles, this is the cost savings for gasoline5250
    Electric motor (kw-hrs)115 kW AC Induction
    Description Data
    Annual petroleum consumption in barrels for fuel type 10.1056
    Time to charge an electric vehicle in hours at 240 v6
    City mpg for fuel type 1,78
    Unrounded city mpg for fuel type 1,78.4283
    City electricity consumption in kw-hrs/100 miles43
    Combined mpg for fuel type 1,76
    Unrounded combined mpg for fuel type 1,76.169
    Combined electricity consumption in kw-hrs/100 miles44.0
    Drive axle typeFront-Wheel Drive
    EPA model type index86
    Annual fuel cost for fuel type 1 ($)900
    Fuel type with fuel type 1 and fuel type 2 (if applicable)Electricity
    Fuel type 1. for single fuel vehicles, this will be the only fuel. for dual fuel vehicles, this will be the conventional fuel.Electricity
    Highway mpg for fuel type 1,74
    Unrounded highway mpg for fuel type 1,73.5784
    Highway electricity consumption in kw-hrs/100 miles46.0
    Vehicle record id33308
    Model name (carline)Rav4 Ev
    Has my mpg data; see yourmpgvehicle and yourmpgdrivervehicleN
    If true, this vehicle operates on a blend of gasoline and electricity in charge depleting modefalse
    EPA range for fuel type 1103
    EPA city range for fuel type 1107.0
    EPA highway range for fuel type 198.9
    TransmissionAutomatic (variable gear ratios)
    Unadjusted city mpg for fuel type 1112.0404
    Unadjusted highway mpg for fuel type 1105.112
    EPA vehicle size classSport Utility Vehicle - 2WD
    You save/spend over 5 years compared to an average car ($). savings are positive; a greater amount spent yields a negative number. for dual fuel vehicles, this is the cost savings for gasoline5250
    Electric motor (kw-hrs)115 kW AC Induction
    3-character manufacturer codeTYX
    Date the vehicle record was created (iso 8601 format)Tue Jan 01 00:00:00 EST 2013
    Date the vehicle record was last modified (iso 8601 format)Wed Feb 02 00:00:00 EST 2022
    Vehicle has start-stop technology (y, n, or blank for older vehicles)N
NHTSA Submitted Crashtests

  • Ncap Side Impact - 2012 Toyota Rav4 5-doo: Impactor Into Vehicle

    There are 12 videos for NHTSA test number 7738

    There are 102 photos for NHTSA test number 7738

    Click HERE to view content

  • 35 Mph Ncap Frontal - 2012 Toyota Rav4 4w: Vehicle Into Barrier

    There are 20 videos for NHTSA test number 7744

    There are 77 photos for NHTSA test number 7744

    Click HERE to view content

  • Fmvss 208 Frontal Impact - 2012 Toyota Ra: Vehicle Into Barrier

    There are 24 videos for NHTSA test number 8147

    Click HERE to view content

  • Fmvss 301 Test Reports/photos/video: Impactor Into Vehicle

    There are 22 photos for NHTSA test number 9879

    Click HERE to view content

  • Fmvss 305 Test Reports/photos/video: Impactor Into Vehicle

    There are 2 videos for NHTSA test number 9880

    There are 81 photos for NHTSA test number 9880

    Click HERE to view content

Bulletins

Bulletins are notices put out by manufacturers in conjunction with the NHTSA to notify the public of manufacturing issues or changes.

  • T-SB-0043-14 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL: Obsolete notice january 22, 2024: this bulletin is now obsolete. Please see t-sb-0057-18.
  • TSB003220 - AIR BAGS: Tsb: replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) (see figure 1) for most 1979 ? 2023 model year vehicles may be available provided the re
  • T-SB-0057-18 - ELECTRICAL SYSTEM: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to
  • Z3G_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • Z2G_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • ZKG_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • Z3G_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • Z2G_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • ZKG_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • ZKG_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • Z3G_Technical_In - STRUCTURE:BODY: Ti: technical instructions customer support program zkg multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint color coverage for peeling of factory-applied paint
  • Z3G_Paint_Repair - STRUCTURE:BODY: Csp: customer support program zkg ? Paint repair process
  • Z3G_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • Z2G_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • T-SB-0094-21 Rev - AIR BAGS: Tsb: some 2005 ? 2022 model year toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur
  • TSB001221Rev2 - STRUCTURE: Tsb: some 2010 ? 2022 model year toyota vehicles may exhibit paint stains after the removal of rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the rapgard?. The wrinkles may trap water and
  • TSB001221Rev2 - STRUCTURE: Tsb: some 2010 ? 2022 model year toyota vehicles may exhibit paint stains after the removal of rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the rapgard?. The wrinkles may trap water and
  • TSB009421Rev1 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL: Tsb: some 2005 ? 2022 model year toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur
  • Support Program - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • Toyota Safety Re - EQUIPMENT: Toyota safety recall and service campaign - technician certification requirements 4.14.2022
  • TTT063620 - BACK OVER PREVENTION: Tt: some toyota vehicles installed with toyota complete maintenance care (tcmc) brake pads may exhibit a groan or squeak noise in various driving conditions
  • ZKG_Dealer_Lette - EQUIPMENT: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh
  • ZKG_Technical_In - EQUIPMENT: Ti: technical instructions customer support program zkg multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint color coverage for peeling of factory-applied paint
  • ZKG_Paint_Repair - EQUIPMENT: Csp: customer support program zkg - paint repair process operation flow chart
  • T-SB-0014-22 - PARKING BRAKE: Tsb: this service bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the repair procedure in this bulletin to replace the loose or damaged carpet floor retai
  • T-SB-0012-21 Rev - SEATS: Tsb: some 2010 ? 2022 model year toyota vehicles may exhibit paint stains after the removal of rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the rapgard?. The wrinkles may trap water and
  • T-SB-0003-22 - ELECTRICAL SYSTEM:WIRING: Tsb this service bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. This service bulletin should be used in conjunction with the applicable model and model year el
  • Toyota PRO19-02 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Pol: this consolidated tire warranty guide contains the complete warranty terms for all brands of ground and spare tires currently in use by toyota. This information must be kept near the point of vehicle sale and be available to any custom
  • T-SB-0094-21 - STRUCTURE: Tsb: some 2005 ? 2022 model year toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur
  • ZKG Important Up - STRUCTURE: Dl: customer support program zkg multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint color coverage for peeling of factory-applied paint
  • ZKG Customer Sup - STRUCTURE: Rl: customer support program zkg multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint color coverage for peeling of factory-applied paint
  • T-TT-0578-19 Rev - EQUIPMENT:ELECTRICAL: Tt: some customers may encounter bluetooth connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. ?Various bluetooth audio function
  • T-SB-0080-19 Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: some 2006 ? 2022 model year toyota vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (arinix tip) is avai
  • T-PG007-01 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Replacement vin plates.
  • T-PG002-91 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Product general information.
  • Toyota Safety Re - AIR BAGS: Toyota safety recall and service campaign - technician certification requirements
  • T-TT-0636-20 Rev - BACK OVER PREVENTION: Tt: some toyota vehicles installed with toyota complete maintenance care (tcmc) brake pads may exhibit a groan or squeak noise in various driving conditions.
  • T-SB-0044-16 Obs - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Obsolete notice march 08, 2021: this bulletin is now obsolete. Please see t-sb-0012-21.
  • T-SB-0040-08 Obs - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Obsolete notice march 08, 2021: this bulletin is now obsolete. Please see t-sb-0044-16.
  • T-SB-0012-21 - SEATS: Tsb: some 2010 ? 2021 model year toyota vehicles may exhibit paint stains after the removal of rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the rapgard?. The wrinkles may trap water an
  • T-SB-0032-20 Rev - EQUIPMENT: Tsb: replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) (see figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re
  • T-SB-0125-20 - BACK OVER PREVENTION:DISPLAY FUNCTION: Tsb: toyota models equipped with the premium hdd navigation (avn/aw-emv) system will periodically require an update to the gracenote database. Gracenote includes detailed information for songs (genre, artist, song title, album name, etc.)
  • T-TT-0636-20 - BACK OVER PREVENTION: Tt: some toyota vehicles installed with toyota complete maintenance care (tcmc) brake pads may exhibit a groan or squeak noise in various driving conditions.
  • T-SB-0125-20 - EQUIPMENT: Tsb: toyota models equipped with the premium hdd navigation (avn/aw-emv) system will periodically require an update to the gracenote database. Gracenote includes detailed information for songs (genre, artist, song title, album name, etc.)
  • T-TT-0636-20 - SERVICE BRAKES, HYDRAULIC: Tt: some toyota vehicles installed with toyota complete maintenance care (tcmc) brake pads may exhibit a groan or squeak noise in various driving conditions.
  • T-SB-0108-15 Obs - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Obsolete notice december 16, 2020: this bulletin is now obsolete. Please see t-sb-0125-20.
  • Customer Support - STRUCTURE: Re: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh
  • ZKG_Dealer_Lette - STRUCTURE: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v
  • T-TT-0628-20 - ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS: Tt: hvac drain tube is found to be blocked/clogged.
  • T-TT-0578-19 Rev - EQUIPMENT ADAPTIVE/MOBILITY: Tt: some customers may encounter bluetooth connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. ?Various bluetooth audio functio
  • ZKG_Proper_Photo - EQUIPMENT ADAPTIVE/MOBILITY: Zkg website proper photograph submission
  • ZKG_Dealer_Lette - EQUIPMENT ADAPTIVE/MOBILITY: Ti: technical instructions customer support program zkg multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint color coverage for peeling of factory-applied paint
  • ZKG_Dealer_Lette - EQUIPMENT: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh
  • ZKG_Dealer_Lette - EQUIPMENT ADAPTIVE/MOBILITY: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh
  • 20R001 Customer - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : De: safety recall is an integral part of our commitment to meet customer expectations of toyota products. Toyota will be sending follow-up notices to remind owners whose vehicles have not yet had safety recall repairs completed for the ca
  • 20R001 Customer - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Re: toyota will be sending safety recall follow-up notices to owners whose vehicles have not yet had the following safety recall repairs completed. Please note the following information for regional and pd associates.
  • 20R001 Toyota Cu - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Dl: safety recall completion is an important part of our commitment to customer satisfaction of toyota products. Toyota will be conducting follow-up notifications to remind owners whose vehicles have not yet had safety recall repairs comp
  • 20R001 Toytoa Cu - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Rl: toyota plans to conduct safety recall follow-up notifications to owners whose vehicles have not yet had the following safety recall repairs completed. Please note the following information for regional and pd associates.
  • 20R001 Toyota Cu - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Dl: toyota plans to send safety recall follow-up notices for the above referenced campaigns to remind owners whose vehicles have not yet had campaign repairs completed.
  • T-TT-0468-17 Rev - ENGINE AND ENGINE COOLING:COOLING SYSTEM: Tt: hvac drain tube is found to be blocked/clogged.
  • T-SB-0391-08 Obs - SUSPENSION: Tsb: obsolete notice june 23, 2020: this bulletin is now obsolete. Please see t-sb-0063-20.
  • T-SB-0063-20 - WHEELS: Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. St005-01, su001-08, and t-sb-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure
  • DOR-M9J4S-07 - ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR: These skus are exhaust manifolds with catalytic converters. The customer communication requested return of unsold inventory due to a loss of carb certification. These skus can no longer be sold as they do not meet carb standards, but part
  • DOR-M3J3F-07 - ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR: These skus are exhaust manifolds with catalytic converters. The customer communication requested return of unsold inventory due to a loss of carb certification. These skus can no longer be sold as they do not meet carb standards, but part
  • ZKG_Technical_In - EQUIPMENT: Ti: technical instructions customer support program zkg multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint color coverage for peeling of factory-applied paint
  • ZKG_Dealer_Lette - EQUIPMENT: Dl: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh
  • T-SB-0304-17 Obs - EQUIPMENT: Tsb: obsolete notice april 07, 2020: this bulletin is now obsolete. Please see t-sb-0032-20. Replacement certification labels and vin plates
  • T-SB-0032-20 - EQUIPMENT: Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. Pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, pg006-01, pg004-97, t-sb-0144-08, and t-sb-0304-17. The a
  • T-SB-0142-13_Obs - EQUIPMENT: Obsolete notice february 12, 2020: this bulletin is now obsolete. Please see t-sb-0010-20.
  • ZKG_Technical In - EQUIPMENT: Technical instructions customer support program zkg phase 2 ? Customer renotification and repair phase repair is now available multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint c
  • ZKG_Technical_In - EQUIPMENT: Technical instructions customer support program zkg phase 2 ? Customer renotification and repair phase repair is now available multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint c
  • ZKG_Paint_Repair - EQUIPMENT: Customer support program zkg ? Paint repair process operation flow chart
  • ZKG_Dealer_Lette - STRUCTURE: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the vehicle
  • ZKG_Dealer Email - STRUCTURE: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied during the vehicle
  • T-SB-0010-20 - EQUIPMENT: Tsb: some 2004 ? 2017 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. Although there is no way to eliminate these odors, follow the general procedure in this bull
  • T-SB-0008-20 - EQUIPMENT: Tsb: vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?Leak? Should b
  • ZKG_Technical In - EQUIPMENT ADAPTIVE/MOBILITY: Technical instructions: customer support program zkg ? Technical instructions. December 12, 2019. This document has been updated to clarify that only authorized toyota dealerships are authorized to confirm if the paint peeling condition is
  • ZKG_Dealer Packa - EQUIPMENT ADAPTIVE/MOBILITY: Dealer package: december 12, 2019 this document has been updated to clarify that only authorized toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. However, after confirming that the pain
  • ZKG_Technical In - STRUCTURE: Technical instructions: technical instructions customer support program zkg phase 2 ? Customer renotification and repair phase repair is now available multiple models and model years vehicles painted with blizzard pearl (070) or super whit
  • ZKG_Paint Repair - STRUCTURE: Repair process: customer support program zkg ? Paint repair process.
  • ZKG_Dealer Packa - STRUCTURE: Dealer package: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied du
  • ZKG_Dealer Email - STRUCTURE: Dealer email: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied duri
  • ZKG_Region Lette - STRUCTURE: Region letter: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied dur
  • ZKG_Region Email - STRUCTURE: Region email: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied duri
  • Customer Support - STRUCTURE: Dealer daily message: ***phase 2 ? Customer renotification and repair phase*** repair is now available multiple models and model years vehicles painted with blizzard pearl (070) or super white (040) paint color coverage for peeling of fact
  • T-SB-0162-19 - STRUCTURE: Tsb: some 2008 ? 2019 model year toyota vehicles painted with either 070 blizzard pearl or 040 super white may exhibit peeling paint on one or more metal body panels. The paint may peel between the primer and e-coat layer, exposing the gray
  • ZKG_Technical In - EQUIPMENT ADAPTIVE/MOBILITY: Technical instructions: december 12, 2019. This document has been updated to clarify that only authorized toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. However, after confirming that
  • T-SB-0101-15_Obs - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Tsb: obsolete notice december 18, 2019: this bulletin is no longer applicable and is now obsolete.
  • T-SB-0294-17_Rev - EQUIPMENT: Tsb: revision notice november 11, 2019 rev2: ? The parts information and required tools & equipment sections have been updated. Any previous printed versions of this bulletin should be discarded. Supersession notice the information contain
  • T-TT-0578-19 - STEERING: Tt: some customers may encounter bluetooth connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. ? Various bluetooth audio functions a
  • T-SB-0025-19_Rev - BRAKES (PWS): Tsb: revision notice september 26, 2019 rev1: ? The warranty information, parts information, and repair procedure sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2018 model year ra
  • ZKG_Dealer Packa - STRUCTURE:BODY: Dealer package: toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indicate that vehicles with these specific paint colors, applied du
  • ZKG_Dealer Packa - STRUCTURE:BODY: Dealer package: phase 1 - customer notification phase repair not yet available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports ind
  • ZKG_Region Lette - STRUCTURE:BODY: Region letter: phase 1 ? Customer notification phase repair not yet available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports ind
  • ZKG_Dealer Email - STRUCTURE:BODY: Dealer email: phase 1 - customer notification phase repair not yet available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indic
  • ZKG_Region Email - STRUCTURE:BODY: Region email: phase 1 - customer notification phase repair not yet available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied blizzard pearl or super white paint colors. These reports indic
  • T-SB-0080-19 - EQUIPMENT ADAPTIVE/MOBILITY: Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. T-sb-0033-14. ? Applicability has been updated to include 2019 model year toyota vehicles. Service bulletin no. T-sb-0033-14 is obsolete and
  • T-SB-0076-19 - EQUIPMENT: Tsb: some 2009 ? 2019 model year toyota vehicles with super chrome wheel finishes may become discolored and/or damaged when aftermarket cleaners, polishes, or brake dust removal products are used on wheels with super chrome finishes. Wheel
  • T-SB-0134-16-Rev - ENGINE (PWS): Tsb: revision notice july 01, 2019 rev2: ? Applicability has been updated to 2019 ? 2020 model year toyota vehicles. ? The techstream preparation and process overview sections have been updated. October 30, 2017 rev1: ? Applicability has be
  • T-SB-0142-16_Rev - ELECTRICAL SYSTEM: Tsb: revision notice may 23, 2019 rev1: ? The applicable warranty has been updated. Any previous printed versions of this bulletin should be discarded. Some 2012 ? 2016 model year avalon hybrid, camry hybrid, and rav4 hybrid vehicles may ex
  • T-SB-0025-19 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS: Tsb: some 2009 ? 2018 model year rav4 and 2017 ? 2018 model year im vehicles may exhibit a grind/groan noise from the front brake pads. An updated pad kit is now available as a service part. Follow the repair procedure in this bulletin to a
  • T-TT-0414-16-Rev - EQUIPMENT:ELECTRICAL: Tt: some customers may encounter bluetooth connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. ? Various bluetooth audio functions a
  • T-TT-0468-17-Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tt: hvac drain tube is found to be blocked/clogged.
  • T-SB-0044-16_Rev - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Tsb: revision notice february 7, 2019 rev2: * applicability has been updated to include 2010 - 2014 model year matrix, 2017 - 2019 model year c-hr, 2019 model year corolla hatchback, and 2018 - 2019 model year toyota vehicles. G418 the intr
  • T-SB-0151-18 - ELECTRICAL SYSTEM: Tsb: some 2009 ? 2012 model year rav4 and 2010 ? 2011 model year camry vehicles equipped with 2ar-fe (non-pzev) engines may exhibit a mil on condition with diagnostic trouble code (dtc) P0138 (oxygen sensor circuit high voltage [bank 1 sens
  • T-SB-0033-14_Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: some vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (arinix tip) is now available to help minimize fut
  • ZF4-WPB POL15-04 - POWER TRAIN: Wpb: in certain 2006 to 2012 model year rav4 4wd vehicles, toyota has received some reports where the vehicle may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing.
  • ZF4-Dealer Daily - POWER TRAIN: Dd: in our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for rear differential coupling growl noise on 2006-2012 model year rav4 4wd
  • ZF4-Dealer Lette - POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT: Dl: in our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for rear differential coupling growl noise on 2006-2012 model year rav4 4wd
  • T-TT-0380-15 - ELECTRICAL SYSTEM: Tt: some customers may experience a ?Check ev system? Message after attempting to charge their vehicle. No other vehicle operation or performance issues are present. This may be a result of incompatibility with unapproved ev charging stati
  • T-TT-0374-15 - EQUIPMENT: Tt: since my 2011, several different update or upgrade usb sst's have been issued for toyota audio and navigation system. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabili
  • TSB018217 - ELECTRICAL SYSTEM: Tsb: supersession notice the information contained in this bulletin supersedes sb no. T-sb-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service bulletin no. T-sb-0101-11 is obsolete and any printed
  • T-SB-0294-17_Rev - EQUIPMENT: Tsb: revision notice november 14, 2018 rev1: ? The required tools & equipment section has been updated. Any previous printed versions of this bulletin should be discarded. Supersession notice the information contained in this bulletin super
  • T-SB-0134-16 - ELECTRICAL SYSTEM: Tsb: supersession notice. Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service
  • T-TT-0414-16-Rev - EQUIPMENT:ELECTRICAL: Tt: some customers may encounter bluetooth connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. ? Various bluetooth audio functions a
  • T-SB-0134-16 - ENGINE (PWS): Tsb: supersession notice. Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service
  • Safety Recall an - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Update on technician certification requirements.
  • PG006-01-Obsolet - EQUIPMENT:OTHER:LABELS: Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. Please see t-sb-0304-17.
  • PG004-97-Obsolet - EQUIPMENT:OTHER:LABELS: Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. Please see t-sb-0304-17.
  • T-SB-0304-17_Rev - EQUIPMENT: Tsb: revision notice july 31, 2018 rev2: ? The supersession notice has been updated. January 11, 2018 rev1: ? The supersession notice has been updated. Any previous printed versions of this bulletin should be discarded. Supersession notice
  • T-SB-0057-18 - EQUIPMENT: Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. T-sb-0043-14. ? Applicability has been updated to include 2017 ? 2018 model year toyota vehicles. Service bulletin no. T-sb-0043-14 is obso
  • T-SB-0047-16 - EQUIPMENT ADAPTIVE/MOBILITY: Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
  • T-SB-0044-16 - EQUIPMENT ADAPTIVE/MOBILITY: Tsb: on some vehicles, when rapgard? Is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the rapgard?
  • T-SB-0047-16 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
  • T-SB-0044-16 - STRUCTURE:BODY: Tsb: on some vehicles, when rapgard? Is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the rapgard?
  • T-TT-0392-16 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tt: some customers may experience bluetooth connection issues after updating the android operating system to 5.X.X (lollipop) or later.
  • T-SB-0080-13 Rev - POWER TRAIN: Tsb: some 2006 - 2012 model year 4wd rav4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this co
  • T-TT-0234-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
  • T-TT-0234-13 Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
  • T-TT-0086-11 - POWER TRAIN: Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
  • T-SB-0163-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: use the following procedures to check and/or update the software version of entune/navigation for non-hdd type units.
  • T-SB-0061-15 - EQUIPMENT:ELECTRICAL: Tsb: some 2012 model year vehicles equipped with a display audio navigation system and entune? (version less than 2.1.0) may exhibit one or more of the following conditions: ? Vehicle orientation slow to update after vehicle startup ? Fiv
  • T-TT-0392-16 - EQUIPMENT:ELECTRICAL: Tt: some customers may experience bluetooth connection issues after updating the android operating system to 5.X.X (lollipop) or later.
  • T-TT-0391-16 - EQUIPMENT: Tt: when replacing the hard disk drive (hdd) or navigation unit (navi unit) follow the instructions below.
  • T-TT-0374-15 - ELECTRICAL SYSTEM:SOFTWARE: Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicab
  • TTT-0268-13 Rev3 - ELECTRICAL SYSTEM: Tt: some customers may encounter bluetooth connectivity concerns such as: ? Difficulty pairing the phone. ? Intermittent bluetooth failure to connect when first turning on the vehicle. ? Various bluetooth audio functions are no lon
  • T-TT-0385-16 - ELECTRICAL SYSTEM:SOFTWARE: Tech tip: this tech tip is being provided to bring attention to the new location of the entune/nav/map update and upgrade usb directory. Click on the tis tab, diagnostics tab, telematics tab, and the document is now located under the refer
  • TTT-0337-15 Rev1 - ELECTRICAL SYSTEM:SOFTWARE: Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
  • TTT-0234-13 Rev6 - EQUIPMENT:ELECTRICAL: Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
  • T-TT-0362-15 - ENGINE (PWS): Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
  • T-TT-0360-15 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. The customer's iphone is connected to the vehicle via bluetooth. The customer may complain of the f
  • T-TT-0381-16 - ELECTRICAL SYSTEM:SOFTWARE: Tech tip: some customers may experience difficulty programming homelink.
  • TSB-0012-13 Rev2 - ENGINE (PWS): Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. This bull
  • T-TT-0206-12 - ELECTRICAL SYSTEM: Some customers may complain of a 'check ev system' message illuminating after attempting to charge their vehicle at a public charging station.
  • T-TT-0205-12 - ELECTRICAL SYSTEM: Customers who purchase new or replacement iphones running ios 6 may find that toyota a entune application will not launch on the iphone. The issue can occur when the customer restores/transfers their apps, contacts, etc.
  • T-SB-0126-12 Rev - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL: A new pds check sheet has been developed for the 2012 model year rav4 ev. Some check points have been added, expanded or clarified. Bulletins are available for items in bold type.
  • T-SB-0125-12 Rev - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL: Pre-delivery service check sheet
  • T-SB-0187-12 - STRUCTURE:BODY: Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se
  • T-TT-0005-10 Rev - ENGINE (PWS): Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
  • T-TT-0005-10 Rev - ENGINE (PWS): Starting with the 2010 my, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.
  • T-SB-0093-09 Rev - EQUIPMENT: A revised procedure has been developed to ensure proper removal and installation of the sun visor. Please use the following procedure for removal and installation of the sun visor.
  • SET Airbag Senso - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : This communication pertains to a current safety recall being conducted by the southeast toyota distributors llc (set). Tms is sending this communication for informational purposes in the event you are contacted by a customer covered by th
  • T-TT-0208-12 Rev - ELECTRICAL SYSTEM:SOFTWARE: When connecting to a rav4 ev with techstream software, some dtc codes from the electronic propulsion control system will be displayed incorrectly.
  • T-TT-0118-11 Rev - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Technicians should confirm the following key points to minimize the potential for future mil "on" concerns after hv battery replacement.
  • T-TT-0213-13 - AIR BAGS: Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the srs airbags or pretensioner devi
  • T-SB-0064-10 Rev - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : This bulletin is now obsolete. Please see t-sb-0012-13.
  • T-SB-0012-13 - ELECTRICAL SYSTEM:SOFTWARE: Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. This bulletin de
  • T-SB-0093-12 Rev - EQUIPMENT:ELECTRICAL: Three new application have been developed to enhance the entune experience in vehicles equipped with the display audio navigation system with entune. All customers with these vehicles have been shipped instructions on this update along wit
  • T-SB-0026-12 Rev - ELECTRICAL SYSTEM:SOFTWARE: Use the following procedures to check and/or update the software version of entune/navigation for non-hdd type units.
  • T-SB-0030-12 Rev - EQUIPMENT:ELECTRICAL: Vehicles equipped with a display audio navigation system and entune (version less than 2.1.0) may exhibit one or more of the following conditions.
  • T-SB-0007-13 - ELECTRICAL SYSTEM:SOFTWARE: Toyota models equipped with the premium hdd navigation (avn/aw-emv) system require a special service tool (sst) usb drive to update the map, points of interest, gracenote and system software. The sst is used with all vehicles to deliver th
  • T-SB-0006-13 - ELECTRICAL SYSTEM: Toyota models equipped with the premium hdd navigation (avn/aw-emv) system will periodically require an update to the gracenote database. Gracenote includes detailed information for songs (i.E. Genre, artist, song title, album name, etc.)
  • T-SB-0005-13 - ELECTRICAL SYSTEM:SOFTWARE: Toyota models equipped with the display audio hdd navigation system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all vehicles to deliver the upda
  • T-SB-0064-10 Rev - ELECTRICAL SYSTEM:SOFTWARE: Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. This bulletin de
  • SST Requirements - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
  • T-TT-0226-13 - ELECTRICAL SYSTEM: The customer is having difficulty changing the multi-display screen from day mode. If the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
  • T-TT-0223-13 - STEERING: STEERING WHEEL/HANDLE BAR: The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side.
  • T-SB-0391-08 Rev - POWER TRAIN: This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
  • T-SB-0033-13 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Some customers may inquire about the frequency and power output of the smart key/smart entry systems used on various models. The smart key/smart entry systems conform to all applicable fcc rules. This bulletin details the applicable specifi
  • T-TT-0206-12 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL: Some customers may experience a 'check ev system' message illuminating after attempting to charge their vehicle at a public charging station. No other vehicle operation or performance issues are present.
  • T-TT-0005-10 - ENGINE (PWS): Starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There a re man benefits of this oil.
  • T-TT-0228-13 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL: Below are step-by-step instructions on how to remove and install the service plug.
  • T-SB-0030-12 Rev - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : This bulletin is now obsolete. Please see t-sb-0051-13.
  • T-SB-0051-13 - EQUIPMENT:ELECTRICAL: 2012-2013 model year vehicles equipped with a display audio navigation system and entune (version less than 2.2.0) may exhibit one or more of the following conditions.
  • T-SB-0050-13 - ELECTRICAL SYSTEM:SOFTWARE: The ev gateway control ecu logic has been updated to improve vehicle operation and charging timer operation. Use the following procedure to reprogram the ecu.
  • T-SB-0043-13 - ELECTRICAL SYSTEM:SOFTWARE: Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for the rav4 ev are released as field-fix procedures described in individual service bulletins. This bulletin details the ecu fla
  • T-SB-0041-13 - ENGINE (PWS): Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1ar-fe or 2ar-fe engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. Follow the repair proced
  • E0A Dealer Notic - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : In late april 2014, toyota will be mailing an update to the owner?S manual for certain 2010 through 2013 model year prius plug-in hybrid vehicles (phv) and certain 2012 through 2013 rav4 electric vehicles (ev). Sample owner letter labels ar
  • E0A Region Notic - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : In late april 2014, toyota will be mailing an update to the owner?S manual for certain 2010 through 2013 model year prius plug-in hybrid vehicles (phv) and certain 2012 through 2013 rav4 electric vehicles (ev). Sample owner letter labels ar
  • T-TT-0223-13 - ELECTRICAL SYSTEM: The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. If the operator attempts to ready-on or start the vehicle while there is tension on
  • T-TT-0228-13 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Below are step-by-step instructions on how to remove and install the service plug. Note: if these steps are not followed, it's possible to damage the service plug installation/removal mechanism.
  • E0A Dealer Notic - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : In late april 2014, toyota will be mailing an update to the owner?S manual for certain 2010 through 2013 model year prius plug-in hybrid vehicles (phv) and certain 2012 through 2013 rav4 electric vehicles (ev). Sample owner letter labels ar
  • E0A Region Notic - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : In late april 2014, toyota will be mailing an update to the owner?S manual for certain 2010 through 2013 model year prius plug-in hybrid vehicles (phv) and certain 2012 through 2013 rav4 electric vehicles (ev). Sample owner letter labels ar
  • T-SB-0080-13 - POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT: Some 2006 ? 2012 model year 4wd rav4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this condition
  • T-SB-0229-12_Rev - ELECTRICAL SYSTEM: Tsb: revision notice november 22, 2017 rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a toyota vehicle becomes submerg
  • T-SB-0133-14_Obs - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: obsolete notice november 16, 2017: this bulletin is now obsolete. Please see t-sb-0294-17.
  • T-SB-0012-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. Please see t-sb-0134-16.
  • T-TT-0426-16 - ELECTRICAL SYSTEM:SOFTWARE: Tt: some technicians have experienced communication issues between the techstream tesla software program and gateway ecu when attempting to read mil on information or firmware update. Utilize the troubleshooting steps provided in the reco
  • T-SB-0142-13 Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: revision notice november 10, 2016 rev2: ? Applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? Parts information section has been updated. Some 2004 ? 2017 model year toyota vehicles may exhibit odor
  • T-TT-0010-10 Rev - BACK OVER PREVENTION: Tech tip: low battery voltage can contribute to a mil "on" condition for P0335 (crankshaft position
  • T-SB-0012-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. This bullet
  • T-TT-0246-13 Rev - VISIBILITY: Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
  • T-TT-0262-13 Rev - ENGINE (PWS): Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. There are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
  • T-TT-0180-12 Rev - EQUIPMENT: Tech tip: when replacing the hard disk drive (hdd) or navigation unit (navi unit) follow the instructions below:
  • T-SB-003-01 - OB - UNKNOWN OR OTHER: Tsb: obsolete notice: july 7, 2014: this bulletin is now obsolete.
  • T-SB-0043-14 Rev - EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
  • T-SB-0043-14 - EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
  • T-SB-0294-17 - EQUIPMENT: Tsb: supersession notice the information contained in this bulletin supersedes sb no. T-sb-0133-14. ? The parts information, required tools & equipment, and on-vehicle navigation update sections have been updated. Toyota models equipped wit
  • T-SB-0108-15_Rev - EQUIPMENT: Tsb: revision notice october 11, 2017 rev2: ? The required tools & equipment section has been updated to include a new usb drive map update. Supersession notice the information contained in this bulletin supersedes sb no. T-sb-0006-13. Toyo
  • T-TT-0453-17-Rev - EQUIPMENT: Tt: previously, an error message was received when performing dcm activation initiated by techstream. This condition has been remedied, and dcm activation utilizing techstream can now be resumed.
  • T-SB-0142-16 - ENGINE (PWS): Tsb: some 2012 ? 2016 model year avalon hv, camry hv and rav4 hv vehicles may exhibit a mil ?On? Condition with dtc P0A7A with information code 122 (generator inverter fail signal detection). Follow the procedure in this bulletin to addres
  • T-TT-0309-14 Rev - ELECTRICAL SYSTEM: Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones running os 4.4 or later. Condition tends to occur to customers who have many previous t
  • T-SB-0133-14 Rev - EQUIPMENT: Tsb: revision notice: the parts information section, and the required tools & equipment section has been updated. Toyota models equipped with the premium hdd navigation (avn/aw-emv) system require a special service tool (sst) usb drive t
  • T-TT-0234-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
  • T-TT-0234-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
  • T-TT-0086-11 - ENGINE (PWS): Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
  • T-SB-0163-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: use the following procedures to check and/or update the software version of entune/navigation for non-hdd type units.
  • T-SB-0061-15 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: some 2012 model year vehicles equipped with a display audio navigation system and entune? (version less than 2.1.0) may exhibit one or more of the following conditions: ? Vehicle orientation slow to update after vehicle startup ? Fiv
  • T-TT-0453-17 - EQUIPMENT:ELECTRICAL: Tt: an error message is received when performing dcm activation initiated by techstream. This is a known condition and will be remedied in the near future. Please discontinue dcm activations utilizing techstream until further notice.
  • T-SB-0218-17_Rev - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
  • T-TT-0234-13 - EQUIPMENT: Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
  • T-PG006-00 Obsol - EQUIPMENT:OTHER:LABELS: This bulletin is now obsolete. Please see t-sb-0054-13.
  • T-SB-0007-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Toyota models equipped with the premium hdd navigation (avn/aw-emv) system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all the vehicles to deliv
  • T-SB-0005-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Toyota models equipped with the display audio navigation system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all the vehicles to deliver the upda
  • T-SB-0054-13 - EQUIPMENT: California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?S parts department utilizing standard replacement parts ordering procedures. Follow the guide
  • T-SB-0141-10 Rev - EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT: If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
  • T-TT-0246-13 - VISIBILITY: Tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
  • T-TT-0208-12 Rev - ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY: When connecting to a rav4 ev with techstream software, some dtc codes from the electronic propulsion control system will be displayed incorrectly.
  • T-TT-0206-12 Rev - FUEL SYSTEM, OTHER: Some customers may experience a 'check ev system' message after attempting to charge their vehicle. No other vehicle operation or performance issues are present. This may be a result of incompatibility with unapproved ev charging stations
  • T-SB-0050-13 Rev - POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM): The ev gateway control ecu logic has been updated to improve vehicle operation and charging timer operation. Use the following procedure to reprogram the ecu
  • T-SB-0083-13 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable repair manual for vehicle specific repair procedures and parts.
  • T-SB-0082-13 - POWER TRAIN: Some 2012 ? 2013 model year rav4 ev vehicles may experience a condition where the charge schedule function is intermittently inoperative. The condition may result from power interruption including: momentary blackout from the utility compan
  • T-TT-0257-13 - EQUIPMENT: Itunes radio is a new feature for iphone 4, 4s, 5, 5s, and 5c running ios 7 or later. This feature does work with the in-vehicle audio system either via bluetooth or by usb cable. Details on how to access this feature are described below.
  • T-TT-0206-12 Rev - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Some customers may experience a ?Check ev system? Message after attempting to charge their vehicle. No other vehicle operation or performance issues are present.
  • T-TT-0256-13 - EQUIPMENT: Customers using iphone 4, 4s, 5, 5s, or 5c running ios 7.0 or later now have the ability to make facetime audio calls (no video). When a customer is paired by bluetooth hands free and they make a facetime audio call the vehicle radio will t
  • T-TT-0199-12 Rev - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Some users may experience no sound from the pandora or iheartradio entune applications after attaching the iphone usb cable to the multimedia system. This can also occur if the user chooses the ipod selection on the multimedia system and th
  • T-TT-0250-13 Rev - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with xm satellite radio inc. After entering into a contract, registration of an 8-digit xm radio id is required. This 8
  • T-TT-0051-10 Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
  • T-TT-0251-13 - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Some customers may experience a/c is inoperative with the dtc B1479 present. This can be caused by debris stuck in the flow control valve.
  • T-TT-0051-10 - EQUIPMENT:APPLIANCE:AIR CONDITIONER: If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
  • T-TT-0269-13 - VISIBILITY:GLASS, SIDE/REAR: The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
  • T-TT-0268-13 - EQUIPMENT:ELECTRICAL: These concerns can be caused by changes made on the customer?S phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d
  • T-TT-0267-13 - EQUIPMENT:ELECTRICAL: Some vehicles equipped with display audio may exhibit a condition where the touch screen is inoperative.
  • T-TT-0262-13 - ENGINE (PWS): Due to the improved performance and durability of 0w-20 synthetic oil, toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. With this change, the following should be noted
  • T-TT-0260-13 - EQUIPMENT:ELECTRICAL: Customer?S experiencing this condition can use a 3rd party podcast application on their iphone (such as pocket casts or instances) instead of the native apple podcast application.
  • T-SB-0041-13 Rev - ENGINE (PWS): Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1ar-fe or 2ar-fe engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. Follow the repair proced
  • T-SB-0007-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: This bulletin is now obsolete. Please see t-sb-0133-14
  • T-SB-0006-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Toyota models equipped with the premium hdd navigation (avn/aw-emv) system will periodically require an update to the gracenote database. Gracenote includes detailed information for songs (i.E., genre, artist, song title, album name, etc.
  • T-SB-0071-11 Rev - POWER TRAIN: The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?On,? Shifting issues, and/or transmission damage. Use the information in this bulletin when
  • T-SB-0050-13 Rev - POWER TRAIN: The rav4 ev power management control ecu and ev gateway control ecu logic have been updated to improve vehicle operation and charging timer operation. Use the following procedure to reprogram the rav4 ev power management control ecu and ev
  • T-SB-0093-12 Rev - UNKNOWN OR OTHER: This bulletin is no longer applicable and is now obsolete.
  • T-SB-0163-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Use the following procedures to check and/or update the software version of entune/navigation for non-hdd type units.
  • T-SB-0051-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Applicability has been updated to include 2014 model year avalon, avalon hv, camry, camry hv, prius, prius c, prius phv, prius v, venza vehicles. Vehicle equipped with a display audio navigation system and entune (version less than 2.1.0)
  • T-SB-0026-12 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): This bulletin is now obsolete. Please see t-sb-0163-13 .
  • T-SB-0122-11 Rev - EQUIPMENT: Beginning in 1998, toyota introduced side airbags as optional equipment. Toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
  • T-TT-0128-11 - EQUIPMENT: The premium display audio type entune system does not connect to the internet when using an iphone.
  • T-TT-0124-11 - TIRES: Please refer to the following recommendations for the best practices for vehicle tire rotations.
  • T-TT-0240-13 - EQUIPMENT: When diagnosing audio, navigation, and bluetooth concerns on toyota vehicles equipped with premium display audio with entune, adhere to the guidelines listed below.
  • T-TT-0278-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): The customer is unable to delete their call history or contacts from the denso gen7 navigation system. The ?Delete? Soft button on the multi-information display is greyed out and not selectable.
  • TS-BO030-01 Obso - VISIBILITY/WIPER (PWS): This bulletin is now obsolete. Please see t-sb-0185-13.
  • T-SB-0187-13 - ELECTRONIC STABILITY CONTROL: Some 2006 ? 2012 model year rav4 vehicles may exhibit a clunking noise coming from the rear of the vehicle. Upon inspection, one or both of the rear stabilizer links may be damaged. Follow the repair in this bulletin to address this conditi
  • T-SB-0185-13 - VISIBILITY: The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
  • T-SB-0142-13 - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. Although there is no way to eliminate these odors, follow the general procedure in this bulletin to
  • T-SB-0141-13 - EQUIPMENT: A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the b
  • T-SB-0082-13 Rev - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Some 2012 ? 2013 model year rav4 ev vehicles may experience a condition where the charge schedule function is intermittently inoperative. The condition may result from power interruption including: momentary blackout from the utility compan
  • T-TT-0213-13 - AIR BAGS: Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the
  • T-SB-0051-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Some 2012 model year vehicles equipped with a display audio navigation system and entune? (version less than 2.1.0) may exhibit one or more of the following conditions:
  • T-SB-0187-12 Rev - TIRES: Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se
  • T-TT-0268-13 - EQUIPMENT: Customer complains of bluetooth connectivity concerns such as: difficulty to pair phone, intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. These concerns can be caused by changes made on the custom
  • T-TT-0234-13 - EQUIPMENT: Since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicability.
  • T-TT-0132-11 - EQUIPMENT: A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general
  • T-TT-0262-13 - ENGINE (PWS): Starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the improved performance and durability of 0w-20 synthetic oil, toyot
  • T-SB-0015-14 - EQUIPMENT: The following three critical replacement electric powertrain parts for the rav4 ev will be offered on an exchange basis only: on-board charger, final drive/inverter, ev battery. Special requirements for ordering and handling of these compo
  • T-SB-0043-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for the rav4 ev are released as field-fix procedures described in individual service bulletins. This bulletin details the ecu fla
  • T-SB-0050-13 Rev - POWER TRAIN: This bulletin is now obsolete. Please see t-sb-0010-14.
  • T-SB-0010-14 - POWER TRAIN: The rav4 ev power management control ecu and ev gateway control ecu software has been updated to improve charging performance. To ensure the best ownership experience, it is important to confirm the software is the most current version avai
  • T-SB-0005-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Toyota models equipped with the display audio navigation system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all vehicles to deliver the update,
  • T-SB-0033-14_Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: revision notice march 08, 2017 rev1: ? Applicability has been updated to include 2015 - 2017 model year toyota vehicles. ? The parts information section has been updated. Some vehicles in particular geographic areas may exhibit a c
  • HR1_Dealer Lette - AIR BAGS: Dealer letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
  • HR1_Region Lette - AIR BAGS: Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
  • T-SB-0044-16_Rev - STRUCTURE:BODY: Tsb: revision notice march 07, 2017 rev1: ? Applicability has been updated to include 2017 model year toyota vehicles. On some vehicles, when rapgard? Is removed the paint may have a stained appearance. These stains appear to be under the c
  • T-SB-0033-14 - ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS: Some vehicles in particular geographic areas may exhibit a condition where the hvac evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (arinix tip) is now available to help minimize future o
  • T-SB-0187-12_Rev - TIRES: Tsb: revision notice february 12, 2018 rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print
  • T-SB-0009-18 - EQUIPMENT: Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. As an additional resource, if the vehicle is equipped with factory leather seats, the ve
  • T-SB-0304-17_Rev - EQUIPMENT: Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. Pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. Service bulletin nos. Pg021-88, pg015-89
  • T-SB-0187-12_Rev - TIRES: Tsb: revision notice february 12, 2018 rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print
  • T-SB-0009-18 - EQUIPMENT: Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. As an additional resource, if the vehicle is equipped with factory leather seats, the ve
  • T-SB-0134-16_Rev - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. Supersession notice the information contained in this bulletin supersedes sb no. T-sb-0012-13. Flash reprogramming allows the
  • T-SB-0304-17 - STRUCTURE:BODY:DOOR : Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
  • SET-TSB-16-001 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Southeast toyota accessory advent navigation system displays splash screen only or randomly shuts off, discusses audio system hard reset procedure and updated software card.
  • SET-TSB-16-001 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Revised document- southeast toyota accessory advent navigation system displays splash screen only or randomly shuts off, discusses audio system hard reset procedure and updated software card. Updated contact information for radio software
  • T-TT-0414-16 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Tt: some customers may encounter bluetooth connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. *various bluetooth audio functions a
  • T-SB-0101-15 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: revision notice august 23, 2016 rev1: applicability has been updated to include 2015 model year prius and prius phv vehicles. Any previous printed versions of this bulletin should be discarded. Toyota models equipped with the displ
  • T-SB-0096-16 - BRAKES (PWS): Tsb: some 2012 - 2016 model year rav4 vehicles may exhibit a squeak noise which is heard coming from the front brakes with light to moderate braking. To address this squeak noise condition, use the following repair procedure.
  • T-SB-0061-15 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: revision notice: introduction has been updated. Any previous printed versions of this bulletin should be discarded. Some 2012 model year vehicles equipped with a display audio navigation system and entune (version less than 2.1.0)
  • T-SB-0083-13 Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable repair manual for vehicle specific repair procedures and parts.
  • T-TT-0309-14 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones running os 4.4 or later. Condition tends to occur to customers who have many previous te
  • T-SB-0108-15 - ELECTRICAL SYSTEM:SOFTWARE: Tsb: toyota models equipped with premium hdd navigation (avn/aw-emv) system will periodically require an update to the gracenote database. Gracenote includes detailed information for songs (eg., genre, artist, song, title, album name, etc.)
  • T-SB-0133-14 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: toyota models equipped with the premium hdd navigation (avn/aw-emv) system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all vehicles to deliv
  • T-SB-0006-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: obsolete notice november 5, 2015: this bulletin is now obsolete. Please see t-sb-0108-15
  • T-SB-0005-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: obsolete notice november 2, 2015: this bulletin is now obsolete. Please see t-sb-0101-15
  • T-SB-0101-15 - ELECTRICAL SYSTEM:SOFTWARE: Tsb: toyota models equipped with the display audio navigation system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all vehicles to deliver the upda
  • T-SB-0051-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: august 19, 2015: this bulletin is now obsolete. Please see t-sb-0061-15
  • T-SB-0043-14 Rev - EQUIPMENT:ELECTRICAL: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to
  • T-TT-0337-15 - ELECTRICAL SYSTEM:SOFTWARE: Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
  • T-TT-0234-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
  • T-TT-0262-13 Rev - ENGINE AND ENGINE COOLING: Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the them improved performance and durability of 0w-20 synthetic oil, to
  • T-SB-0101-11 Rev - ELECTRICAL SYSTEM: Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe
  • T-SB-0142-13 Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. Although there is no way to eliminate these odors, follow the general procedure in this bullet
  • FR1_Remail_Deale - BRAKES (PWS): Dl: safety recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of toyota products. Toyota will be sending safety recall follow-up notices
  • FR1_Remail_Regio - BRAKES (PWS): Rl: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for regional and pd associates.
  • T-TT-0268-13 Rev - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Tt: some customers may encounter bluetooth connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. * various bluetooth audio function
  • TT-0307-14 Rev2 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. Conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
  • T-SB-0040-08 - STRUCTURE:BODY: Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the rapgard. T
  • T-TT-0267-13 Rev - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Tt: some vehicles equipped with display audio may exhibit a condition where the touch screen is inoperative.
  • T-TT-307-14 Rev1 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. Conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
  • T-TT-0321-15 - ENGINE AND ENGINE COOLING: Tt: customer complaint of mil (:check engine light) on condition. Health check retrieves dtc P2118 (throttle actuator motor current range/performance).
  • T-SB-0108-15 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: revision notice: required tools and equipment has been updated to include a new usb drive map update. Any previous printed versions of this bulleting should be discarded. Toyota models equipped with the premium hdd navigation (avn/a
  • T-TT-0267-13 Rev - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Tt: some vehicles equipped with display audio may exhibit a condition where the touch screen is inoperative.
  • T-TT-307-14 Rev1 - ELECTRICAL SYSTEM:SOFTWARE: Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. Conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
  • T-TT-0321-15 - ENGINE AND ENGINE COOLING: Tt: customer complaint of mil (:check engine light) on condition. Health check retrieves dtc P2118 (throttle actuator motor current range/performance).
  • T-TT-0268-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tt: some customers may encounter bluetooth connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth failure to connect to the vehicle when first turning on the vehicle. * various bluetooth audio function
  • TT-0307-14 Rev2 - ELECTRICAL SYSTEM:SOFTWARE: Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. Conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
  • T-SB-0040-08 - STRUCTURE:BODY: Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the rapgard. T
  • T-TT-0337-15 - ELECTRICAL SYSTEM:SOFTWARE: Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
  • T-TT-0234-13 Rev - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
  • T-TT-0262-13 Rev - ENGINE AND ENGINE COOLING: Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the them improved performance and durability of 0w-20 synthetic oil, to
  • T-SB-0101-11 Rev - EQUIPMENT:ELECTRICAL: Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe
  • T-SB-0142-13 Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. Although there is no way to eliminate these odors, follow the general procedure in this bullet
  • T-SB-0083-13 Rev - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable repair manual for vehicle specific repair procedures and parts.
  • T-SB-0043-14 Rev - EQUIPMENT:ELECTRICAL: Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to
  • FR1_Remail_Deale - BRAKES (PWS): Dl: safety recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of toyota products. Toyota will be sending safety recall follow-up notices
  • FR1_Remail_Regio - BRAKES (PWS): Rl: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for regional and pd associates.
  • T-TT-0234-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tech tip: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems.
  • T-SB-0111-14 - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Tsb: some 2012 - 2014 model year rav4 ev vehicles may experience a lack of heat from the hvac system. An updated ptc heater is available to address this condition.
  • T-SB-0200-08 Rev - POWER TRAIN:AUTOMATIC TRANSMISSION: Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
  • T-SB-0134-14 - POWER TRAIN:AUTOMATIC TRANSMISSION: Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. Use the information in this bulletin when insta
  • T-SB-0133-14 - ELECTRICAL SYSTEM:SOFTWARE: Tsb: toyota models equipped with the premium hdd navigation (avn/aw-emv) system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all vehicles to deli
  • T-SB-0006-13 Rev - ELECTRICAL SYSTEM:SOFTWARE: Tsb: toyota models equipped with the premium hdd navigation (avn/aw-emv) system will periodically require an update to the gracenote database. Gracenote includes detailed information for songs (e.G., genre, artist, song title, album name, e
  • T-TT-0309-14 - ELECTRICAL SYSTEM:SOFTWARE: Tech tip: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones running os 4.4 or later. Condition tends to occur to customers who have many previ
  • T-TT-0307-14 - ELECTRICAL SYSTEM:SOFTWARE: Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. Conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
  • T-SB-0260-08 Rev - POWER TRAIN:AUTOMATIC TRANSMISSION: Tsb: the purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
  • T-SB-0014-11 Rev - POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER: Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w
  • T-SB-0006-11 Rev - POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES: Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with atf-ws in toyota vehicles r
  • T-SB-0381-09 Rev - WHEELS: Tsb: the only acceptable towing method for vehicles equipped with an active torque control 4wd system is to have all four wheels off the ground. Flat towing or towing where only the front or rear wheels are supported may damage the all-whee
  • T-SB-007-13 Rev2 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: september 30, 2014: this bulletin is now obsolete. Please see t-sb-0133-14.
  • T-TT-0374-15 REV - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): "tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applica
  • T-TT-0268-13 REV - EQUIPMENT: "tt: some customers may encounter bluetooth connectivity concerns such as: difficulty pairing the phone. Intermittent bluetooth failure to connect when first turning on the vehicle. Various bluetooth audio functions are no lo
  • T-SB-0047-16 - HYBRID POWERTRAIN: INVERTER: Tsb: the breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the
  • T-SB-0044-16 - EQUIPMENT: Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the rapgard
  • T-SB-0051-13 REV - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: august 19, 2015: this bulletin is now obsolete. Please see t-sb-0061-15
  • T-TT-0234-13 REV - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
  • T-TT-0360-15 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. The customer's iphone is connected to the vehicle via bluetooth. The customer may complain of the f
  • T-TT-0309-14 REV - EQUIPMENT:ELECTRICAL: Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones running os 4.4 or later. Condition tends to occur to customers who have many previous te
  • T-TT-0381-16 - EQUIPMENT: Tech tip: some customers may experience difficulty programming homelink.
  • T-SB-0012-13 REV - ENGINE (PWS): "tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. This bul
  • T-SB-0108-15 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: toyota models equipped with premium hdd navigation (avn/aw-emv) system will periodically require an update to the gracenote database. Gracenote includes detailed information for songs (eg., genre, artist, song, title, album name, etc.)
  • T-SB-0133-14 REV - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: toyota models equipped with the premium hdd navigation (avn/aw-emv) system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all vehicles to deliv
  • T-SB-0006-13 REV - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: obsolete notice november 5, 2015: this bulletin is now obsolete. Please see t-sb-0108-15
  • T-SB-0005-13 REV - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: obsolete notice november 2, 2015: this bulletin is now obsolete. Please see t-sb-0101-15
  • T-SB-0101-15 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: toyota models equipped with the display audio navigation system require a special service tool (sst) usb drive to update the map, points of interest, gracenote, and system software. The sst is used with all vehicles to deliver the upda
  • POL15-04 - POWER TRAIN: Wpb: in certain 2006 to 2012 model year rav4 4wd vehicles, toyota has received some reports where the vehicle may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing.
  • ZF4_DEALERD 12/3 - POWER TRAIN: "dd: in our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for rear differential coupling growl noise on 2006-2012 model year rav4 4w
  • ZF4_DEALER 12/3 - POWER TRAIN: "dl: in our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for rear differential coupling growl noise on 2006-2012 model year rav4 4wd
  • T-TT-0380-15 - ELECTRICAL SYSTEM: "tt: some customers may experience a check ev system‟ message after attempting to charge their vehicle. No other vehicle operation or performance issues are present. This may be a result of incompatibility with unapproved ev chargin
  • T-TT-0374-15 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): "tt: since my 2011, several different update or upgrade usb sst's have been issued for toyota audio and navigation system. Refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabil
  • T-TT-0385-16 - EQUIPMENT: "tech tip: this tech tip is being provided to bring attention to the new location of the entune/nav/map update and upgrade usb directory. Click on the tis tab, diagnostics tab, telematics tab, and the document is now located under the refe
  • T-TT-0392-16 REV - EQUIPMENT: Tt: some customers may experience bluetooth connection issues after updating the android operating system to 5.X.X (lollipop) or later.
  • T-SB-0080-13 REV - POWER TRAIN: Tsb: some 2006 - 2012 model year 4wd rav4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this co
  • T-SB-0096-16 - BRAKES (PWS): Tsb: some 2012 2016 model year rav4 vehicles may exhibit a squeak noise which is heard coming from the front brakes with light to moderate braking. To address this squeak noise condition, use the following repair procedure.
  • T-SB-0061-15 REV - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Tsb: revision notice: introduction has been updated. Any previous printed versions of this bulletin should be discarded. Some 2012 model year vehicles equipped with a display audio navigation system and entune (version less than 2.1.0)
  • T-TT-0208-12 - ELECTRICAL SYSTEM:SOFTWARE: When connecting to a rav4 ev with techstream software, some dtc codes from the electronic propulsion control system will be displayed incorrectly
  • T-TT-0206-12 - ENGINE (PWS): Some customers may experience a 'check ev system' message after attempting to charge their vehicle . No other vehicle operation or performance issues are present. This may be a result of incompatibility with unapproved ev charging stati
  • T-TT-0206-12*2 - ENGINE (PWS): Some customers may experience a 'check ev system' message after attempting to charge their vehicle. No other vehicle operation or performance issues are present. This may be a result of incompatibility with unapproved ev charging statio
  • T-TT-0199-12 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Some users may experience no sound from the pandora or iheartradio entune applications after attaching the iphone usb cable to the multimedia system. This can also occur if the user chooses the ipod selection on the multimedia system and
  • T-SB-0050-13 - ELECTRICAL SYSTEM:SOFTWARE: Summary to be provided on a future date.
  • T-SB-0082-13A - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-SB-0050-13B - ELECTRICAL SYSTEM:SOFTWARE: Summary to be provided on a future date.
  • T-SB-0050-13A - ELECTRICAL SYSTEM:SOFTWARE: Summary to be provided on a future date.
  • T-TT-0268-13 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Summary to be provided on a future date.
  • T-TT-0262-13 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Summary to be provided on a future date.
  • T-TT-0260-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0257-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0256-13A - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0250-13 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Summary to be provided on a future date.
  • T-TT-0248-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0246-13 - EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT: Summary to be provided on a future date.
  • T-TT-0240-13 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Summary to be provided on a future date.
  • T-TT-0240-13 R1 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Summary to be provided on a future date.
  • T-TT-0234-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0228-13 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-TT-0226-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0208-12 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-TT-0208-12 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-TT-0206-12 R3 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-TT-0206-12 R2 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-TT-0206-12 R1 - ENGINE (PWS): Summary to be provided on a future date.
  • T-TT-0206-12 - ENGINE (PWS): Summary to be provided on a future date.
  • T-TT-0205-12 - EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.: Summary to be provided on a future date.
  • T-TT-0199-12 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0128-11 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0124-11 - TIRES: Summary to be provided on a future date.
  • T-TT-0051-10 - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Summary to be provided on a future date.
  • T-TT-0005-10 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Summary to be provided on a future date.
  • T-TT-0005-10 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Summary to be provided on a future date.
  • T-TT-0005-10 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Summary to be provided on a future date.
  • T-SB-0187-12 - TIRES: Summary to be provided on a future date.
  • T-SB-0163-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-SB-0093-12 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-SB-0083-13 - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Summary to be provided on a future date.
  • T-SB-0082-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-SB-0050-13 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-SB-0043-13 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-SB-0041-13 - ENGINE (PWS): Summary to be provided on a future date.
  • T-SB-0026-12 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-SB-0111-14 - EQUIPMENT:APPLIANCE:AIR CONDITIONER: Summary to be provided on a future date.
  • T-SB-0007-13 R1 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-SB-0006-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-SB-0006-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-SB-0005-13 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM): Summary to be provided on a future date.
  • T-TT-0228-13 - ENGINE (PWS): Summary to be provided on a future date.
  • T-SB-0050-13 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-SB-0043-13 R1 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-SB-0015-14 - ELECTRICAL SYSTEM:12V/24V/48V BATTERY: Summary to be provided on a future date.
  • T-SB-0010-14 - ENGINE (PWS): Summary to be provided on a future date.
  • TSB-0041-13 - ENGINE (PWS): Toyota: on certain vehicles, a knock or rattle noise, coming from engine compartment, is heard during a cold soak startup, and the condition lasts approximately one second. Model years 2009-2012 camry, highlander, sienna, venza, rav4.
  • TSB-0187-13 - SUSPENSION:REAR: Toyota: there is a clunking noise heard coming from rear of vehicle and one or both rear stabilizer links are damaged. Model 2006-2012 rav4. *pe
  • TSB-004-13-A - ENGINE (PWS): Toyota: there is a knocking or rattling noise coming from engine compartment, for a short period of time, after a cold soak startup. Model 2010-2012 camry, 2009-2013 highlander, venza, 2009-2012 rav4, 2011-2013 sienna. *pe
  • TSB-0080-13 - SUSPENSION:FRONT:WHEEL BEARING: Toyota: the rear differential coupling, when driving some vehicles, may exhibit a growl noise, due to contamination to front bearing. Model 2006-2012 rav4 (42wd). *pe
  • TSB-0087-12 - VEHICLE SPEED CONTROL:ACCELERATOR PEDAL: Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
  • TSB-0122-11 - SEATS: Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
  • TSB-0025-11 - EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL : Toyota: long-term storage procedure for some 2012 models. *rm
Known Recall Investigations

  • Pedestrian alert sounds investigation # DP22005

    Nhtsa received a petition on or about july 18, 2022, requesting that federal motor vehicle safety standard (fmvss) 141 be applied to all electric and hybrid vehicles operating in the united states. The petition can be reviewed at nhtsa.Gov under odi number 11486072.Fmvss 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 kg or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after march 1, 2021.The petitioner asserts that hybrid and electric vehicles to which the standard does not apply should be found to contain a safety defect. In support of the petition, the petitioner includes findings contained in a bill introduced in the house of representatives in 2009, the pedestrian safety enhancement act of 2009, h.R. 734, 111th cong. (2009). A related bill, the pedestrian safety enhancement act of 2010, became law in january 2011 (pub. L. 111-373). The petitioner requests that nhtsa require all electric and hybrid vehicles comply with fmvss 141, regardless of production date.The defect petition has been opened to evaluate the issue and determine whether to grant or deny the petition.The associated product list is not exhaustive and may contain vehicles that are equipped with pedestrian alert sounds.

Recall investigations are also available on the Complaints page
Vehicle Documentation
[pdf] User Manual Owner's Manual Instructions Reference Guide Guide
RAV4 EV Every owner should review the Owner s Manual that accompanies this vehicle   Toyota reserves right to make changes at any time without notice RAV4EV Owners myrav4ev docs Rav4 Ev Text The has two charge modes which can be selected depending on your intended usage * An approximation based a traction battery capacity  Forum View topic How do I program garage door opener |||
RAV4 EV 2 0 12 Quick RefeRence Guide 2012 RAV4 EV This Quick Reference Guide is a summary of basic vehicle operations. It contains brief descriptions of fundamental operations so you can locate and use the vehicle s main equipment quickly and easily. The Quick Reference Guide is not intended as a ...
lang:en score:46 filesize: 29.82 M page_count: 576 document date: 2013-03-14
[pdf]
mary zhang asia toyota v11 en carmod ru docs v31
TOYOTA V1.1 Mark X Description Function is supported. Special Function Automaker Model Year Engine Type Option 1 Option 2 TOYOTA 4Runner 1996 3RZ-FE TOYOTA 4Runner 1996 5VZ-FE TOYOTA 4Runner 1997 3RZ-FE TOYOTA 4Runner 1997 5VZ-FE TOYOTA 4Runner 1998 3RZ-FE TOYOTA 4Runner 1998 5VZ...
lang:en score:15 filesize: 9.45 M page_count: 1107 document date: 2016-12-06
Most Recent Consumer Complaints and Accidents
CrashFireTowedInjuredDeathsFailure
Date
NoNoN NoneNone20210106

I have just begun having the issue that many others complain about - the check engine light + 4wd + trac lights all came on (2012 toyota rav4, 100,000 miles). We tried some simple fixes at home, based on the many online posts about this issue (checked/refastened hoses, battery connections, etc.), and the lights came right back on. Took to our usual mechanic, and they diagnosed o2 sensor problems, both bank 1 & bank 2. Paid $750 for them to replace both sensors. The 3 dashboard lights came back on as i was driving home after picking up my car from the service. The sensors were replaced with genuine toyota parts. The car is now back at the mechanic - they said the same o2 sensor codes are coming up when they check the diagnostics. This appears to be a chronic problem for toyota, and really needs to be investigated and dealt with. I had the same problem with an earlier toyota sienna, and spent much time and money trying to fix the issue, which was never resolved. There are more than 15 years of complaints about this issue - please help us, the consumers!

NoNoN NoneNone20210105

I have just begun having the issue that many others complain about - the check engine light + 4wd + trac lights all came on (2012 toyota rav4, 100,000 miles). We tried some simple fixes at home, based on the many online posts about this issue (checked/refastened hoses, battery connections, etc.), and the lights came right back on. Took to our usual mechanic, and they diagnosed o2 sensor problems, both bank 1 & bank 2. Paid $750 for them to replace both sensors. The 3 dashboard lights came back on as i was driving home after picking up my car from the service. The sensors were replaced with genuine toyota parts. The car is now back at the mechanic - they said the same o2 sensor codes are coming up when they check the diagnostics. This appears to be a chronic problem for toyota, and really needs to be investigated and dealt with. I had the same problem with an earlier toyota sienna, and spent much time and money trying to fix the issue, which was never resolved. There are more than 15 years of complaints about this issue - please help us, the consumers!

NoNoN NoneNone20201105

Both front drive axles exhibited signs of severe corrosion damage leading to complete loss of lubricant and had to be replaced at 34,056 miles. The vehicle is garaged and not subject to any unusual operating conditions. Symptoms included severe cracking and popping noises on turns.

NoNoN NoneNone20201104

Both front drive axles exhibited signs of severe corrosion damage leading to complete loss of lubricant and had to be replaced at 34,056 miles. The vehicle is garaged and not subject to any unusual operating conditions. Symptoms included severe cracking and popping noises on turns.

NoNoN NoneNone20201001

Tl* the contact owns a 2012 toyota rav4. The contact stated while the vehicle was receiving routine maintenance at fred anderson toyota (9101 glenwood ave, raleigh, nc 27617, (919) 890-3686) the contact was informed that there was a crack in the windshield wiper reservoir. The contact was informed that the windshield wiper motor pump was defective and needed to be repaired. The vehicle was not repaired. The low windshield washer fluid warning light was illuminated. The manufacturer was not contacted. The failure mileage was 150,000.

NoNoN NoneNone20201001

Driver's side sun visor had to be replaced a couple years ago because it would not stay in an upright position and hung in a loose dropped position.The passenger side sun visor is now doing the same thing. This is a safety hazard as it can drop unexpectedly and block the drivers visual field.

NoNoN NoneNone20200930

Driver's side sun visor had to be replaced a couple years ago because it would not stay in an upright position and hung in a loose dropped position.The passenger side sun visor is now doing the same thing. This is a safety hazard as it can drop unexpectedly and block the drivers visual field.

NoNoN NoneNone20200930

Tl* the contact owns a 2012 toyota rav4. The contact stated while the vehicle was receiving routine maintenance at fred anderson toyota (9101 glenwood ave, raleigh, nc 27617, (919) 890-3686) the contact was informed that there was a crack in the windshield wiper reservoir. The contact was informed that the windshield wiper motor pump was defective and needed to be repaired. The vehicle was not repaired. The low windshield washer fluid warning light was illuminated. The manufacturer was not contacted. The failure mileage was 150,000.

NoNoN NoneNone20200701

2012 toyoya rav4. Consumer writes in regards to the sound of the turn signal being too low. Consumer would like for the volume of the turn signal to be adjustable *ld *js

Read and Submit Vehicle Complaints -- 51+ complaints filed
Common OBD-II Error Codes
  • C0140 [1] C0140
  • C0141 [1] C0141
  • U1400 [1] U1400
  • P0138 [1] 02 Sensor Circuit High Voltage (Bank I Sensor 2)
  • P0335 [1] Crankshaft Position Sensor A Circuit Malfunction
  • P0A7A [1] Generator Inverter Performance
  • B1479 [1] Wiper Washer Fluid Level Sensor Circuit Failure
  • P2118 [2] Throttle Actuator Control Motor Current Range/Performance
  • P0607 [1] Control Module Performance
  • C1523 [1] C1523
For a complete list of all consumer complaints and OBD II codes, see the Complaints page
Latest VINs Decoded for this Manufacturer
VIN Year Model Manufactured In
2T3YK4DV0CW0175052012RAV4WOODSTOCK ONTARIO, CANADA
2T3ZF4DV5CW1170092012RAV4WOODSTOCK ONTARIO, CANADA
2T3ZF4DV2CW1424512012RAV4WOODSTOCK ONTARIO, CANADA
2T3YF4DV8CW1269282012RAV4WOODSTOCK ONTARIO, CANADA
2T3BF4DV6CW2293662012RAV4WOODSTOCK ONTARIO, CANADA
2T3BF4DV3CW2404542012RAV4WOODSTOCK ONTARIO, CANADA
2T3BF4DV7CW2330542012RAV4WOODSTOCK ONTARIO, CANADA
2T3YK4DV2CW0191882012RAV4WOODSTOCK ONTARIO, CANADA
2T3ZF4DV2CW1136452012RAV4WOODSTOCK ONTARIO, CANADA
2T3BF4DV2CW2420202012RAV4WOODSTOCK ONTARIO, CANADA
2T3YF4DV4CW1538042012RAV4WOODSTOCK ONTARIO, CANADA
JTMWF4DVXC50468192012RAV4TAHARA AICHI, JAPAN
2T3BF4DV6CW2572472012RAV4WOODSTOCK ONTARIO, CANADA
2T3ZF4DV3CW1528912012RAV4WOODSTOCK ONTARIO, CANADA
2T3KF4DV2CW1116232012RAV4WOODSTOCK ONTARIO, CANADA
2T3RF4DV9CW2256962012RAV4WOODSTOCK ONTARIO, CANADA
2T3ZF4DV7CW1251132012RAV4WOODSTOCK ONTARIO, CANADA
2T3BF4DV7CW2411372012RAV4WOODSTOCK ONTARIO, CANADA
2T3BF4DV3CW2422532012RAV4WOODSTOCK ONTARIO, CANADA
2T3DK4DV8CW0825982012RAV4WOODSTOCK ONTARIO, CANADA
2T3BF4DV6CW2691382012RAV4WOODSTOCK ONTARIO, CANADA
JTMBD31V5C53003082012RAV4TAHARA PLANT, TOYOTA CITY AICHI, JAPAN
JTMBD31V5C53003092012RAV4TAHARA PLANT, TOYOTA CITY AICHI, JAPAN
2T3DK4DV8CW0794092012RAV4WOODSTOCK ONTARIO, CANADA

© dot.report 2024

Use of this information constitutes acceptance for use in an AS IS condition. There are NO warranties, implied or otherwise, with regard to this information or its use. Any use of this information is at the user's risk. It is the responsibility of user to evaluate the accuracy, completeness or usefulness of any information, opinion, advice or other content. EACH USER WILL BE SOLELY RESPONSIBLE FOR ANY consequences of his or her direct or indirect use of this web site. ALL WARRANTIES OF ANY KIND ARE EXPRESSLY DISCLAIMED. This site will NOT BE LIABLE FOR ANY DIRECT, INDIRECT or any other kind of loss.